Inhaltszusammenfassung zur Seite Nr. 1
NATURAL GAS GRILL OWNER'S MANUAL
# 3200 & 5200
GUÍA DEL PROPIETARIO DE LA PARRILLA DE GAS NATURAL - PG 24
-
GUIDE DE L’UTILISATEUR DU BARBECUE AU GAZ NATUREL PG 39
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 3
#20208551 Customer Service: 1-800-382-2637
NOTICE TO INSTALLER: These instructions
YOU MUST READ THIS OWNER’S GUIDE
must be left with the owner and the owner
BEFORE OPERATING YOUR GAS GRILL
should keep them for future use.
DANGER
THIS GAS APPLIANCE IS DESIGNED FOR
If you smell gas:
OUTD
Inhaltszusammenfassung zur Seite Nr. 2
DANGERS AND W DANGERS AND WARNINGS ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING Do not lift the barbecue using the control panel as a handle. Lifting by the control panel can damage gas handling and electrical components. Damage to gas handling and electrical components can result in serious bodily injury or death and damag
Inhaltszusammenfassung zur Seite Nr. 3
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inher- ent with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful while handling any parts during assembly. It is strongly recommended that hands be protected with a pair of work gloves. WARNING: Care must be taken to ensure that this gr
Inhaltszusammenfassung zur Seite Nr. 4
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE TOOLS NEEDED: HERRAMIENTAS REQUERIDAS: OUTILS NECESSAIRES: 11mm (7/16”) 3 BRNR. 5 BRNR. 3 BRNR. 5 BRNR. 0 1 1 1 0 1 1 1 1 1 2 3 4 4 3 5 4 4 2 6 1 1 2 6 1 1 3 3 4 www.ducane.com
Inhaltszusammenfassung zur Seite Nr. 5
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 - 1 - 2 - 1 - 1 NOTE: The two (2) lower bolts used to install the stainless steel side shelf (s) are CAUTION: Failure to install the Side Burner properly could threaded into the grill cart on the both sides of the grill. Remove the bolts and re- cause the unit to loosen and fall, causing bodily harm. install when attaching the stainless steel side shelf (s). NOTA: los dos (2) pernos inferiores para instalar el (los) anaquel
Inhaltszusammenfassung zur Seite Nr. 6
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 View from underneath Vista desde abajo Vue du dessous (1) (2) WARNING: The side burner orifice (1) must be parallel to the side burner tube opening (2). ADVERTENCIA: El orificio (1) del quemador lateral debe de estar paralelo a la abertura (2) del tubo del quemador lateral. AVERTISSEMENT: L’orifice du brûleur latéral (1) doit être parallèle à l’ouverture du tube du brûleur latéral (2). 6 www.ducane.com
Inhaltszusammenfassung zur Seite Nr. 7
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 - 1 - 2 - 1 - 3 3 - 4 5 7
Inhaltszusammenfassung zur Seite Nr. 8
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 6 5 4 - 4 - 7 BRNR. 8 www.ducane.com
Inhaltszusammenfassung zur Seite Nr. 9
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 3 5 8 8 BRNR. BRNR. 5 9 BRNR. 9
Inhaltszusammenfassung zur Seite Nr. 10
W WARRANTY ARRANTY, GARANTÍA, GARANTIE , GARANTÍA, GARANTIE This Limited Warranty does not cover failures or operating diffi culties due to accident, abuse, misuse, ® alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane Stain- less Series gas grill that it will be free of defects in material and workmanship from the date of maintenance, including but not limited to dam
Inhaltszusammenfassung zur Seite Nr. 11
SAFETY INFORMATION IMPORTANTWe urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation ® of your new Ducane Gas Grill. We also advise you to keep this manual for future reference. CALIFORNIA PROPOSITION 65 WARNING: Your grill has been designed to operate using WARNING: The burning of gas cooking fuel generates some only the gas specified on the rating plate. Do not attempt by-products wh
Inhaltszusammenfassung zur Seite Nr. 12
CONNECTION CONNECTION Natural Gas Grills Natural Gas Grills Type of Gas Your natural gas grill is factory built to operate using natural gas only. Never attempt to operate your grill on gases other than the type specifi ed on the grill rating plates. 1 Your grill operates at 7” of water column pressure. If replacement of the hose becomes necessary, factory specifi ed parts are required. See your local dealer. ® For safety and design reasons, the conversion of a Ducane grill from operation 4 2
Inhaltszusammenfassung zur Seite Nr. 13
C CONNECTION ONNECTION Natural Gas Grills Natural Gas Grills Gas Leaks Checks IMPORTANT Before operating your grill, check carefully to be certain that all connections are tight and there are no gas leaks. Never use a match or fl ame for leak detection. Use soapy Installation must conform with local codes or, in the absence of local codes, water or testing solution. Brush the solution on to connection points and look closely with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/
Inhaltszusammenfassung zur Seite Nr. 14
NORMAL OPERA NORMAL OPERATION TION Snap Ignition Operation Always open the lid before igniting the burners Each control knob has its own igniter electrode built in. To create a spark you must push the control knob in (A) and turn to “START/High” (B). This action will generate gas fl ow and a spark to the burner lighting tube (C). You will hear a “snap” from the igniter. You will also see a 3˝ - 5˝ orange fl ame coming from the burner lighting tube at the left side of the burner (D). B Continu
Inhaltszusammenfassung zur Seite Nr. 15
NORMAL OPERA NORMAL OPERATION TION Main Burner Snap Ignition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to 1 4 3 “START/HI”. This will ignite each individual burner. Follow the simple steps listed below to light the Main Burner(s) of your grill: 1. Open the lid and make sure that all burners are in the “OFF” position. 2. Turn main gas supply on. 3.
Inhaltszusammenfassung zur Seite Nr. 16
NORMAL OPERA NORMAL OPERATION TION Match Lighting Your Grill Main Burners Follow the simple steps listed below to match light the Main Burner(s) of grill, in the event snap ignition fails: 1 4 WARNING: (Make sure that 5 minutes have elapsed since last attempt of lighting.) Make sure that the lid is in the full open position any time you attempt to light your grill. Failure to open the lid could lead to delayed ignition which may result in serious bodily injury or death, or in a fire or an
Inhaltszusammenfassung zur Seite Nr. 17
2 1 5 4 3 1 5 N NORMAL OPERA ORMAL OPERATION TION Side Burner Ignition Follow the simple steps listed below to light the Side Burner (SB) of your grill: DANGER: Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in a explosive flame-up which can cause bodily injury or death. 1. Open the lids and check that the side burner valve is turned off (Push control knob in and turn clockwise to ensu
Inhaltszusammenfassung zur Seite Nr. 18
HELPFUL HINTS HELPFUL HINTS Flare Ups Any time you cook fatty foods over an open fl ame, you can expect fl are ups. Flare ups are caused by the fl ash which occurs when the natural juices fall on the heat distribu- tion plates. Controlled fl are ups give foods their delicious outdoor fl avor and appear- ance. Excessive fl are ups may occur when your grill is not level or when cooking fatty foods such as spare ribs and chicken parts, especially if the cooking temperature is set too high. These fl are
Inhaltszusammenfassung zur Seite Nr. 19
T TROUBLESHOOTING ROUBLESHOOTING PROBLEM CHECK and CURE IMPORTANT Be sure that there is gas fl ow to the burners by attempting to match light your burners. IGNITION SYSTEM If match lighting is successful, the problem lies somewhere in the ignition system and will need to be checked. MAIN GRILLING BURNERS If the main burner(s) still fails to ignite, make sure that there is gas fl owing to the burner(s) CAUTION: Always turn the gas supply off at the main gas by attempting to match light the b
Inhaltszusammenfassung zur Seite Nr. 20
MAINTENANCE MAINTENANCE Yes, you paid a lot of money for your grill, but even an expensive grill doesn’t clean IMPORTANT and maintain itself, and you want it to look good and function properly. That’s why � Keep appliance area clear and free from combustible materials, gasoline and other this section of your manual is so important. This section gives you the information fl ammable vapors and liquids at all times. necessary to help you keep your grill looking new and working properly. Reading
