Inhaltszusammenfassung zur Seite Nr. 1
®
MAGNUM OPUS
ALL-CHINA GRAVITY DISCHARGE TOILET
OWNER’S MANUAL
3000 Series Toilets
WARNING
!
This manual must be read and under-
stood before installation, adjustment,
service, or maintenance is performed.
Modification of this product can
result in property damage.
Dometic Corporation • Sanitation Systems
13128 State Rt 226, PO Box 38
Big Prairie, OH 44611
SeaLand Product Customer Service: 1-800-321-9886
(8:00 a.m. - 5:00 p.m. ET)
1
Inhaltszusammenfassung zur Seite Nr. 2
TABLE OF CONTENTS Toilet Model Identification . . . . . . . . . . . . . . . . 2 Deodorants and Special Tissue . . . . . . . . . . . 6 Ordering Parts . . . . . . . . . . . . . . . . . . . . . . . . 2 Flush Mechanism Components . . . . . . . . . . . 7 Important Information Before Operation . . . . . . 3 Troubleshooting . . . . . . . . . . . . . . . . . . . . 8 – 9 Toilet Controls . . . . . . . . . . . . . . . . . . . . . . . . 3 Manual Flush Operation . . . . . . . . . . . . . . . . . 9 Operating
Inhaltszusammenfassung zur Seite Nr. 3
IMPORTANT INFORMATION BEFORE OPERATION 1. Fill freshwater tank and add deodorant to holding tank through toilet bowl. ® 2. Make sure all guests understand the operation of the toilet system and the flushing instruction label is easy for guests to read. This label is located under the seat, and is easily read when the seat is raised. 3. Shut off the toilet system before servicing and do not leave the vehicle with toilet system circuit breaker on. 4. Never use drain openers, alcohol, solvents, et
Inhaltszusammenfassung zur Seite Nr. 4
OPERATING INSTRUCTIONS 1. Adding More Water To Toilet Bowl Pull up the handle until the desired water level is attained. To prevent overflowing the toilet, a timer inside the control module limits the amount of water that can be added. 2. Flushing The Toilet Push the handle down for a moment, then release it. Holding the handle down will not prolong the flush cycle nor start a new flush cycle. The lever must be allowed to return to the OFF position before another flush can occur. 3. Selectin
Inhaltszusammenfassung zur Seite Nr. 5
AUTOMATIC FLUSH OPERATION TIMING CHART ® Magnum Opus Flush and Forget Cycle Time Water Valve Low Refill Mid Refill High Refill Flush Valve Opening Time Held Open Closing Time 017 231 45161 89101123415 16 Flush Cycle In Seconds Additional “Add Water” Time Allowance Magnum Opus "Add Water" Time Limits Water Valve Low Position Mid Position High Position Service Position 017 231 45161 89101123415 16 “Add Water” Time In Seconds PROPER CLEANING AND MAINTENANCE The Magnum Opus toilet should be cleane
Inhaltszusammenfassung zur Seite Nr. 6
WINTERIZING At the end of each traveling season, the Magnum Opus toilet system must be winterized for storage. The following procedure should be used: 1. Pump out waste holding tank. 2. Thoroughly flush toilet system with fresh water. 3. Drain freshwater tank. 4. Add freshwater antifreeze to freshwater tank. 5. Flush freshwater antifreeze and water mixture through toilet and into the waste holding tank. Each installation is different so amounts may vary. User discretion is required to assure
Inhaltszusammenfassung zur Seite Nr. 7
FLUSH MECHANISM COMPONENTS 1. To access 2. Remove access cover. 3. Lift china toilet base assembly Lift up control module. straight up and set components, Disconnect power cable it down close to remove from control module. front of floor flange/ decorative Do not disconnect flush adapter assembly. screw caps handle cable or base Turn off water to and unscrew assembly cable. toilet and discon- four bolts that nect flexible water hold china line at rear of base toilet to floor. assembly. The toil
Inhaltszusammenfassung zur Seite Nr. 8
TROUBLESHOOTING Important: Always turn off electrical power and water to the toilet for disassembly. Problem Possible Cause Service Instructions 1. Toilet emits odor (flush ball a. Odor emitting from base of toilet. a. Use SeaLand brand deodorants. open). b. Plugged holding tank vent line. b. Clear obstructions from vent line. 2. Water will not stay in bowl. a. Dirt or debris on underside of flush a. Put Mode Switch in "Service" ball seal. position and clean underside of flush ball seal. b. Wo
Inhaltszusammenfassung zur Seite Nr. 9
TROUBLESHOOTING (cont’d) Problem Possible Cause Service Instructions 9. Water leaking from Water a. Water Valve body cracked due to a. Replace Water Valve. Valve. freeze damage. b. Water line connection is loose or b. Insure that threads are not not seated properly. cross-threaded and tighten. c. Defective Water Valve. c. Replace Water Valve. d. Stripped threads. d. Replace Water Valve. 10. Water will not enter toilet bowl a. Loose electrical connections or a. See Electrical Troubleshooting wh
Inhaltszusammenfassung zur Seite Nr. 10
ELECTRICAL TROUBLESHOOTING A volt/ohmmeter (VOM) and the Magnum Opus Wiring schematic (page 12) may be required for this section. Caution: Portions of this section will require that power be applied to the toilet. Keep hands away from the flush ball, motor drive arm and rotor shaft to prevent personal injury during testing and troubleshooting. The Magnum Opus control module uses a microprocessor to provide all the automatic and timing functions. The control module is on the right side under t
Inhaltszusammenfassung zur Seite Nr. 11
ELECTRICAL TROUBLESHOOTING (cont’d) ERROR CODE CORRECTIVE PROCEDURES Condition Corrective Action Mode Switch in SERVICE position. Return Mode Switch to NORMAL position. Valve Open Limit Switch problem. With the flush valve fully open, check the “VALVE OPEN” status light. If the light is off, then the Valve Open Limit Switch is out of alignment or defective, or related wiring is defective. Valve Closed Limit Switch problem. With flush valve in the fully closed position check the “VALVE CLOSED
Inhaltszusammenfassung zur Seite Nr. 12
ELECTRICAL TROUBLESHOOTING (cont’d) TOILET OPERATION CORRECTIVE PROCEDURES (cont’d) Symptom: Water will not enter the bowl when the Flush Handle is raised to add water. • Place the Water Level Switch in "Low" position and flush toilet. Check status light LED 7 (Add Water) while lifting up the Flush Handle. If LED 7 comes on, replace the Control Module. If LED 7 remains off, the Flush Switch or its related wiring is defective. Symptom: Water Level Switch has no effect on water level in "Lo
Inhaltszusammenfassung zur Seite Nr. 13
CUSTOMER SERVICE There is a strong, worldwide network to assist in servicing and You may also contact or have your local dealer contact the Parts maintaining your sanitation system. For the Authorized Service Distributor nearest you for quick response to your replacement Center near you, please call from 8:00 a.m. to 5:00 p.m. (ET) parts needs. They carry a complete inventory for the SeaLand Monday through Friday. You may also write us at Dometic Corp., product line. P.O. Box 38, Big Prairie Oh
Inhaltszusammenfassung zur Seite Nr. 14
NOTES 14
Inhaltszusammenfassung zur Seite Nr. 15
NOTES 15
Inhaltszusammenfassung zur Seite Nr. 16
MANUFACTURER’S THREE-YEAR AND TEN-YEAR LIMITED WARRANTIES ® Dometic Corporation warrants, to the original purchaser only, that this Magnum Opus gravity discharge toilet, if used for personal, family or household-like purposes, is free from defects in material and workmanship for a period of three (3) years from the date of purchase. Dometic also warrants, to the original purchaser only, that the vitreous china toilet bowl will not discolor, stain, scratch or craze for a period of ten (10) years
