Inhaltszusammenfassung zur Seite Nr. 1
Owners Manual
Manuel d’utilisation
Model No. / Modèle Nº
82300C
WARNING
FOR YOUR SAFETY
For Outdoor Use Only
(Outside any enclosure)
MISE EN GARDE
POUR VOTRE SÉCURITÉ:
Pour usage à l’extérieur
seulement
(hors de tout espace clos)
WARNING
FOR YOUR SAFETY
Improper installation,
adjustment, alteration,
service or maintenance
can cause injury or property
damage. Read the installation,
operation and maintenance
instructions thoroughly before
installing or servicing this
equipment.
MISE
Inhaltszusammenfassung zur Seite Nr. 2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. WARNING WARNING FOR YOUR SAFETY California Proposition 65: If you smell gas: Chemicals known to the state of 1. Shut off gas to the appliance. California to cause cancer, birth 2. Extinguish any open flame. defects, or other reproductive 3. If odor continues, immediately harm are created by the call your gas supplier. combustion of propane. WARNING WARNING FOR YOUR SAFETY FOR YOUR SAFETY 1. Gas leaks may cause a fi
Inhaltszusammenfassung zur Seite Nr. 3
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Table of Contents Safety First! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 . . . . . . . . . . . . . . . . . Assembly Instructions Hardware & Component Listing . . . . . . . . . . . . . . . . . . . . . . . . . 5 . . . . . . . . . . General Components & Features . . . . . . . . . . . . . . . . . . . . . . . 6 . . . . . . . . . . Additional Requirements . . . . . . . . . . . . . . . . . .
Inhaltszusammenfassung zur Seite Nr. 4
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Safety First! Read and become familiar with this entire manual, especially the following precautions . If you are unsure of anything in these instructions, STOP and contact .800 .762 .42 for assistance . Caution: This appliance is for outdoor use only (outside any enclosure). Always make sure there is fresh air ventilation. Before you do anything else, • Use only outdoors in a well-ventilated space, never use
Inhaltszusammenfassung zur Seite Nr. 5
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Caution: Liquid propane (LP) gas is flammable and hazardous if “20 lb.” LP Cylinder handled improperly. Become aware of the characteristics before using any LP product. Collar Valve • LP Characteristics – Flammable, explosive under pressure, heavier than air - settles in pools in low areas . • In its natural state, pr opane has no odor . For your safety, an odorant is added that smells like rotten cabbage . • Con
Inhaltszusammenfassung zur Seite Nr. 6
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Components Hardware Part Re-order Used in Name Number Picture Qty Description Step(s) 4 Medium Screw Finial . . . . . . . . 56-0 . . .-00 2-24 x 5/ 6” Stainless Steel Philips Head Screw 56-0-045 Dome Cap . . . . . 56-0 . -002 3 Nut 3 /4-20 Stainless Steel Dome . . . . . . . . 56-0 . .-003 Hex Nut 56-0-046 Top Wire Guard . . . 56-0-004 Emitter Assembly 56-0-005 Bottom
Inhaltszusammenfassung zur Seite Nr. 7
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Assembly Instructions General Components & Features Familiarize yourself with all components before proceeding . Refer to page 5 for hardware and components, and page 8 for specifications . Do NOT attempt assembly unless all components are available . If you believe a component is missing or damaged, contact .800 .762 .42 for assistance . Note: All hardware is mounted on a cardboard pack and numbered to match their
Inhaltszusammenfassung zur Seite Nr. 8
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Step 2–Attach Top Wire Guard Line up 4 prongs on Wire Guard Bottom with 4 holes on Emitter Bottom, and Insert . Note: It may be necessary to adjust the prongs slightly to line them up with the holes . Step 3–Attach Dome to Emitter Line up three studs in Emitter with holes in Dome . Slide Dome carefully over studs, clamping Top Wire Guard securely in place . Note: It may be necessary to adjust prongs of the Top Wire
Inhaltszusammenfassung zur Seite Nr. 9
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Step 5–Center Lockup Slide the threaded portion of the large thumbscrew through the slot in the center of the bracket mounted to the base . Thread the bottom bracket on to the thumbscrew with the round flat rubber pads facing up . To mount the heater to a hole in your table, tilt the bottom bracket/ thumbscrew assembly until it fits through the hole . Straighten the thumbscrew, and pull it up until the rubber pads cont
Inhaltszusammenfassung zur Seite Nr. 10
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Step 7 – Check for Leaks Caution To check for leaks: ® Your Charmglow Portable Make -2 oz . of leak solution by mixing one part liquid dishwashing soap and 3 parts water . Heater has been checked at all factory connections for leaks. Spoon several drops (or use squirt bottle) of the solution onto the Recheck all connections, as regulator/canister connections . movement in shipping can Inspect the connections and lo
Inhaltszusammenfassung zur Seite Nr. 11
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Step 9 – Securing the Tank Mount your 20 lb . cylinder to a sturdy object such as a table or post within 3 to 4 feet of your heater when in use, this will prevent movement or tipping of the cylinder during operation . The clamp on the cylinder ring will attach to any round pole from ” to 2” in diameter, or a square post from ” to 2” squar e . It will also adapt to various other shapes up to 2” wide . Determine wher
Inhaltszusammenfassung zur Seite Nr. 12
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Operation WARNING Inspect the visible portion of the hose before each use of the appliance . Inspect the entire hose assembly at least annually . FOR YOUR SAFETY • Do NOT attempt to operate heater until you have Before Turning Gas Supply ON read and understand all Your heater was designed and approved for OUTDOOR USE ONLY . DO precautions in Section 1 NOT use it inside a building, garage, or any other enclosed area
Inhaltszusammenfassung zur Seite Nr. 13
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Caution: Avoid inhaling fumes emitted from the heater’s first use. Smoke and odor from the burning of oils used in manufacturing will WARNING appear. Both smoke and odor will dissipate after approximately 30 FOR YOUR SAFETY minutes. The heater should NOT produce thick black smoke. Note: The burner may be noisy when initially turned on . To eliminate Be careful when attempting excessive noise from the burner, turn
Inhaltszusammenfassung zur Seite Nr. 14
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Operation Checklist For a safe and pleasurable heating experience, perform this check before each use . Before Operating q I am familiar with entire owner’s manual and understand all precautions noted in “Safety First” . q All components are properly assembled, intact and operable . q No alterations have been made . q All gas connections are secure and do not leak . q Wind velocity is below 0 mph . q Outdoor temp
Inhaltszusammenfassung zur Seite Nr. 15
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Troubleshooting If the problem is: And this condition exists: Then do this Burner won’t light Gas pressure is low Replace bottle/cylinder or canister Blockage in burner openings Clear blockage Blockage in venturi tube Clean venturi Blockage in gas line Check gas line for blockage Control knob is not in ON position Turn control knob to ON Burner won’t stay lit Bad thermocouple Replace ODS Corrosion at thermocouple Clean co
Inhaltszusammenfassung zur Seite Nr. 16
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Maintenance WARNING To enjoy years of outstanding performance from your heater, make sure you perform the following maintenance activities on a regular basis: FOR YOUR SAFETY Inspect the visible portion of the hose before each use of the appliance . • Do NOT touch or move Inspect the entire hose assembly at least annually . heater for at least 45 minutes Air flow must be unobstructed . Keep controls, burner, and ci
Inhaltszusammenfassung zur Seite Nr. 17
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Storage WARNING Between uses: FOR YOUR SAFETY Turn Control Knob OFF . Never attempt to refill disposable Disconnect LP source . canister. Refilling may cause Store heater upright in an area sheltered from direct contact with explosion. To discard, contact inclement weather (such as rain, sleet, hail, snow, dust and debris) . local refuse hauler or recycle If desired, cover heater to protect exterior surfaces and to
Inhaltszusammenfassung zur Seite Nr. 18
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Limited Warranty Blue Rhino Global Sourcing, LLC (“Vendor”) warrants to the original retail purchaser of this product, and to no other person, that if this product is assembled and operated in accordance with the printed instructions accompanying it, then for a period of one () year fr om the date of purchase, all parts in such product shall be free from defects in material and workmanship . Vendor may require reaso
Inhaltszusammenfassung zur Seite Nr. 19
Contact 1.800.762.1142 for assistance. Do not return to place of purchase. Specifications Certifications: CSA International Requirement 5 .90 (5th Ed .) Canadian National Standard CAN-2 .23-M82 Rating: Maximum ,000 BTU/hr . input Heat Range: Up to 0 foot diameter Fuel: Liquid Propane Gas (LP) Cylinder Size: Nominal 20 lb / 5 Gallon OR 4 . oz . (400 grams) 6 .4 oz . (465 grams) Inlet gas supply pressure: Maximum – 50 PSI Minimum – 5 PSI Manifold Pressure: .00 in . W .C . Supply Pr
Inhaltszusammenfassung zur Seite Nr. 20
Pour toute assistance appeler le 1.800.762.1142. Ne pas retourner cet appareil au point de vente. MISE EN GARDE MISE EN GARDE POUR VOTRE SÉCURITÉ: Proposition 65 de Californie: En cas d’odeur de gaz - L’État de la Californie reconnait 1. Fermez le robinet de gaz que la combustion du propane alimentant l’appareil. produit des émanations et 2. Éteignez toute flamme. des résidus chimiques qui provoquent le cancer, des 3. Si l’odeur persiste, contactez malformations congénitales vot
