Inhaltszusammenfassung zur Seite Nr. 1
Operator’s Manual
Manual del Operario
Manuel de l'Utilisation
Questions? Help is just a moment away!
Preguntas? La ayuda es justa un momento
lejos!
Vous avez des questions? Vous n'avez pas
besoin d'aller loin pour trouver de l'aide!
Call: Home Generator Helpline
Llamada: Línea Directa de Generador de Hogar
Appelez: Ligne Directe de Génératrice la Maison -
1-800-743-4115 M-F 8-5 CT
Web: www.homegeneratorsystems.com
10kW / 12kW Rated
Home Generator
Models 01938-0 & 01815-0 Part No. 192384GS Re
Inhaltszusammenfassung zur Seite Nr. 2
Briggs & Stratton Power Products Home Generator Operator’s Manual TABLE OF CONTENTS TABLE OF CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Battery Connection . . . . . . . . . . . . . . . . . . . . . . . . . . 12 SAFETY RULES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 Gaseous Fuel System . . . . . . . . . . . . . . . . . . . . . . . . 12 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 AUTOMATIC OPERATION . . . . . . . . . .
Inhaltszusammenfassung zur Seite Nr. 3
Briggs & Stratton Power Products Home Generator Operator’s Manual SAVE THESE INSTRUCTIONS IMPORTANT SAFETY DANGER Storage batteries give off explosive hydrogen gas RULES during recharging. Slightest spark will ignite hydrogen and cause The safety alert symbol ( ) is used with a signal word explosion. (DANGER, CAUTION,WARNING), a pictorial and/or a Battery electrolyte fluid contains acid and is safety message to alert you to hazards. DANGER indicates extremely caustic. a hazard which, if not avoi
Inhaltszusammenfassung zur Seite Nr. 4
Briggs & Stratton Power Products Home Generator Operator’s Manual WARNING CAUTION Generator produces powerful voltage. Excessively high operating speeds increase risk of injury and damage to generator. Failure to properly ground generator can result in electrocution. Excessively low speeds impose a heavy load. Failure to isolate generator from power utility � DO NOT tamper with governed speed. Generator supplies can result in death or injury to electric utility correct rated frequency and voltag
Inhaltszusammenfassung zur Seite Nr. 5
Briggs & Stratton Power Products Home Generator Operator’s Manual To arrange for proper installation, contact the store at SAVE THESE INSTRUCTIONS which you purchased your Briggs & Stratton Home Standby Generator, your dealer, a licensed electrician or your utility This manual contains important instructions that should be power provider. followed during installation and maintenance of the generator and battery. The HSG Warranty is VOID unless the system is installed by licensed electrical and p
Inhaltszusammenfassung zur Seite Nr. 6
Briggs & Stratton Power Products Home Generator Operator’s Manual Fuel Factors Generator Location The actual physical location of your HSG has a direct affect An important consideration affecting the entire installation on: is the type of fuel used by your Home Standby Generator. The system was factory tested and adjusted using natural 1. The amount of plumbing required to fuel your generator. gas as a fuel. Liquid propane (LP) may also be used as a fuel 2. The amount of wiring required to contr
Inhaltszusammenfassung zur Seite Nr. 7
Briggs & Stratton Power Products Home Generator Operator’s Manual Figure 1 — Home Standby Generator Clearances Figure 2 — Wattage Reference Guide Running Device Watts Air Conditioner (12,000 Btu)* 1700 Air Conditioner (24,000 Btu)* 3800 Air Conditioner (40,000 Btu)* 6000 Battery Charger (20 Amp) 500 Circular Saw (6-1/2") 800 to 1000 Clothes Dryer (Electric)* 5750 Exhaust Clothes Dryer (Gas)* 700 Port Clothes Washer* 1150 Coffee Maker 1750 Compressor (1 HP)* 2000
Inhaltszusammenfassung zur Seite Nr. 8
Briggs & Stratton Power Products Home Generator Operator’s Manual Essential Circuit Selection turn off any non essential loads. Failure to turn off non essential loads could overload the generator causing it to shut When selecting the essential circuits that will be switched to down. Some examples of non essential loads are as follows: “Standby Power,” it is important that the sum of the combined � Pool pump circuit loads does not exceed the wattage/amperage capacity of the generator.To help you
Inhaltszusammenfassung zur Seite Nr. 9
Briggs & Stratton Power Products Home Generator Operator’s Manual KNOW YOUR HOME STANDBY GENERATOR Read this Operator’s Manual and safety rules before operating your generator. Compare the illustrations with your generator to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Control Panel (see page 10) Exhaust Port 15 Amp Fuse Oil Drain Hose Oil Fill Cap Oil Dip Stick Fuel Inlet Air Cleaner Unit Battery Data Oil Decal Filter Engin
Inhaltszusammenfassung zur Seite Nr. 10
Briggs & Stratton Power Products Home Generator Operator’s Manual KNOW YOUR SYSTEM CONTROL PANEL Compare this Control Panel illustration with your generator to familiarize yourself with the location of these important controls: Set Exercise Switch Circuit Breaker Diagnostic LED Hour Meter AUTO/OFF/MANUAL 15 Amp Switch Fuse 15 Amp Fuse — Protects the Home Standby Generator Circuit Breaker — Protects the system from shorts and DC control circuits. If the fuse has ‘blown’ (melted open) other over-c
Inhaltszusammenfassung zur Seite Nr. 11
Air Intake Door Battery Door Briggs & Stratton Power Products Home Generator Operator’s Manual door channel.The door will come free of generator Access Doors enclosure. The Home Standby Generator is equipped with an The Battery door does not have a lock and the Air Intake enclosure that has four access doors (Figure 3).The doors door does not have a lock or lift handle.The Air Intake are named for a significant component located behind door is opened by lifting on the louvers instead of a lift t
Inhaltszusammenfassung zur Seite Nr. 12
Briggs & Stratton Power Products Home Generator Operator’s Manual Battery Connection BEFORE INITIAL START-UP The Home Standby Generator is supplied with a 12Volt DC 33 Amp-Hour, valve regulated battery. It is a sealed, Engine Oil lead-acid rechargeable battery. It is installed in the unit and This engine is shipped from the factory filled with the the battery cables are connected at the factory.The recommended oil. Before starting the engine, check oil level generator’s 15 Amp fuse has been remo
Inhaltszusammenfassung zur Seite Nr. 13
Briggs & Stratton Power Products Home Generator Operator’s Manual Servicing the System AUTOMATIC OPERATION To service system: To select automatic operation, do the following: 1. Set the AUTO/OFF/MANUAL switch to OFF. 1. Set the service disconnect or main distribution panel 2. Set the generator’s main circuit breaker to its OFF circuit breaker that sends utility voltage to the transfer switch to ON. position. 2. Set the generator’s main circuit breaker to its ON 3. Utility voltage is present. Dis
Inhaltszusammenfassung zur Seite Nr. 14
Briggs & Stratton Power Products Home Generator Operator’s Manual Low Battery Voltage FAULT DETECTION This fault is indicated by one blink.This condition occurs if the generator cannot start because the starting battery SYSTEM output power is below that needed to crank the engine. The generator may have to run for long periods of time Causes for this problem may be a faulty battery or trickle with no operator present. For that reason, the system is charger circuit. equipped with sensors that aut
Inhaltszusammenfassung zur Seite Nr. 15
Briggs & Stratton Power Products Home Generator Operator’s Manual Low Voltage (Generator) Engine Overspeed This fault is indicated by three blinks.This condition is This fault is indicated by 6 blinks.This feature protects caused by a restriction in the fuel flow, a broken or devices connected to the transfer switch by shutting the disconnected signal lead, a failed alternator winding, the generator down if the engine happens to run faster than control panel circuit breaker is open, or Home Stan
Inhaltszusammenfassung zur Seite Nr. 16
Briggs & Stratton Power Products Home Generator Operator’s Manual GENERATOR CAUTION Any attempt to crank or start the engine before it has MAINTENANCE been properly filled with the recommended oil will result in equipment failure. The generator warranty does not cover items that have � Refer to engine operator’s manual for oil fill information. been subjected to operator abuse or neglect.To receive full � Damage to equipment resulting from failure to follow this value from the warranty, the oper
Inhaltszusammenfassung zur Seite Nr. 17
Briggs & Stratton Power Products Home Generator Operator’s Manual TROUBLESHOOTING Problem Cause Correction 1. Circuit breaker open or defective. 1. Reset or replace circuit breaker. Engine is running, but no AC 2. Fault in generator. 2. Contact local service facility. output is available. 3. Poor wiring connections or 3. Check and repair. defective transfer switch. 1. Short circuit in a connected load. 1. Disconnect shorted electrical load. 2. Generator is overloaded. 2. See "Essential Circuits"
Inhaltszusammenfassung zur Seite Nr. 18
Briggs & Stratton Power Products Home Generator Operator’s Manual NOTES 18
Inhaltszusammenfassung zur Seite Nr. 19
BRIGGS & STRATTON POWER PRODUCTS GROUP, LLC EQUIPMENT OWNER WARRANTY POLICY Effective September 1, 2004 replaces all undated Warranties and all Warranties dated before September 1, 2004 LIMITED WARRANTY Briggs & Stratton Power Products Group, LLC will repair or replace, free of charge, any part(s) of the equipment that is defective in material or workmanship or both. Transportation charges on product submitted for repair or replacement under this warranty must be borne by purchaser. This warrant
Inhaltszusammenfassung zur Seite Nr. 20
Generador Doméstico de Briggs & Stratton Power Products Manual del Operario TABLA DE CONTENIDO TABLA DE CONTENIDO. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Conexión de la Batería . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 Sistema de Combustible Gaseoso . . . . . . . . . . . . . . . . . . . . 30 REGLAS DE SEGURIDAD . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-22 OPERACIÓN AUTOMÁTICA. . . . . . . . . . . . . . . . . . . . . . . . . . . 31 INTRODUCCIÓ
