Inhaltszusammenfassung zur Seite Nr. 1
OIL-LESS TURKEY FRYER
Product Manual
Model 07101366
FOR OUTDOOR USE ONLY
CAUTION: WARNING:
Read and follow all safety statements, assembly Failure to follow all manufacturer’s instructions could
instructions, and use and care directions before result in serious personal injury and/or property
attempting to assemble and cook. damage.
INSTALLER/ASSEMBLER: CAUTION:
Leave this manual with consumer. Some parts may contain sharp edges – especially as
noted in the manual! Wear protective gloves if
Inhaltszusammenfassung zur Seite Nr. 2
Installation Safety Precautions • Use Oil-Less Turkey Fryer, as purchased, only with LP DANGER (propane) gas and the regulator/valve assembly supplied. • Oil-Less Turkey Fryer installation must conform with local If you smell gas: codes, or in their absence of local codes, with either the 1. Shut off gas to the appliance. National Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas 2. Extinguish any open flame. and Propane Installation Code, CSA B149.1, and Propane Storage and Handling, CSA B
Inhaltszusammenfassung zur Seite Nr. 3
TABLE OF CONTENTS To insure your satisfaction For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 and for follow-up service, Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2 register your Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Oil-Less Turkey Fryer Product Record Information
Inhaltszusammenfassung zur Seite Nr. 4
LP Cylinder Valve • A disconnected LP cylinder in USE AND CARE storage or being transported must have a safety cap installed (as shown). Do not store an LP cylinder in enclosed spaces such as a carport, garage, porch, covered DANGER Safety patio or other building. Never leave an LP cylinder Cap inside a vehicle which may become overheated • NEVER store a spare LP cylinder under or near the Retainer Strap by the sun. appliance or in an enclosed area. • Do not store an LP cylinder in an area where
Inhaltszusammenfassung zur Seite Nr. 5
e s i w k LP Cylinder Exchange Connecting Regulator to the LP Cylinder • Many retailers that sell Oil-Less Turkey Fryer's offer you the 1. LP cylinder must be properly secured onto appliance. (Refer to option of replacing your empty LP cylinder through an assembly section.) exchange service. Use only those reputable exchange 2. Turn all control knobs to the OFF position. companies that inspect, precision fill, test and certify their cylinders. Exchange your cylinder only for an OPD safety 3.
Inhaltszusammenfassung zur Seite Nr. 6
Straight Leak Testing Valves, Hose and Regulator 1. Turn control knob to OFF. 2. Be sure regulator is tightly connected to LP cylinder. 3. Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding. 4. Brush soapy solution onto areas circled below. Hold coupling nut and regulator as shown for proper connection to LP cylinder valve. 6. Turn the coupling nut c
Inhaltszusammenfassung zur Seite Nr. 7
3 ft. • Apartment Dwellers: WARNING Check with management to learn the requirements and fire codes for using an LP gas appliance in your For Safe Use of Your Oil-Less Turkey Fryer and to apartment complex. If allowed, use outside on the ground Avoid Serious Injury: floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies. • The use of alcohol, prescription or non-prescription drugs may impair the consumer's ability to properly • NEVER attempt to light bu
Inhaltszusammenfassung zur Seite Nr. 8
Ignitor Lighting Burner Flame Check • Do not lean over appliance while lighting. • Light burner, rotate knob from HIGH to LOW. Looking through viewing hole on top of appliance, you should see the flame 1. Turn ON LP gas cylinder. height decrease when turning knob from HIGH to LOW. 2. Press and turn the control knob to HIGH. Always check flame prior to each use. If only low flame is seen 3. Turn ROTARY IGNITOR knob rapidly. refer to "Sudden drop or low flame" in the Troubleshooting 4. If
Inhaltszusammenfassung zur Seite Nr. 9
Cleaning the Burner Assembly (Continued) CAUTION 7. Clean inner burner as recommended below, shown E. We suggest three ways to clean the burner tube. Use the one easiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) SPIDER ALERT! into a small hook. Run hook through burner tube several times. SPIDER AND WEBS INSIDE BURNER TUBE (B) Use a narrow bottle brush with a flexible handle (do not use a brass wire brush), run the brush through burner tube several times. (C) Wear
Inhaltszusammenfassung zur Seite Nr. 10
Food Safety Storing Your Appliance • Clean cooking basket. Food safety is a very important part of enjoying the outdoor • Store in dry location. cooking experience. To keep food safe from harmful bacteria, • When LP cylinder is connected to appliance, store outdoors in follow these four basic steps: a well-ventilated space and out of reach of children. Clean: Wash hands, utensils, and surfaces with hot soapy water • If Regulator is disconnected from the LP cylinder, a hook is before and aft
Inhaltszusammenfassung zur Seite Nr. 11
PARTS DIAGRAM – Model No. 07101366 I T N K K J J C H B A S D L U F M E G R Q O P Key Qty Description Part # Key Qty Description Part # A 1 Outer Body . . . . . . . . . . . . . . . . . . . . . . 55710184 M 1 Control Knob . . . . . . . . . . . . . . . . . . . . 29101346 B 1 Inner Body . . . . . . . . . . . . . . . . . . . . . . 55710185 N 1 Storage Lid. . . . . . . . . . . . . . . . . . . . . . 29101333 C 1 Body Top Ring . . . . . . . . . . . . . . . . . . . 55710186 O 4 Leg Assemblies . . . . . .
Inhaltszusammenfassung zur Seite Nr. 12
ASSEMBLY – Model No. 07101366 • Remove lid, roaster basket and cooking pot. 1 • Turn fryer upside down. • Attach legs to body using two #10-24 x 1/2" screws for each leg. Screw on from outside. Assure leg with rating label is attached behind burner tube outlet as pictured. Leg Assembly with Rating Label Qty: 8 #10-24x1/2” #10-24x1/2" Screw Screw Burner • Attach grease tray rails to body with #10-24x3/8" screws and #10-24 keps nuts. 2 Qty: 4 Qty: 4 #10-24x3/8" Screw #10-24 Keps Nut Grease T
Inhaltszusammenfassung zur Seite Nr. 13
• Attach rotary ignitor to control panel using two #8x1/2" self-tap screws (A). 3 • Attach round end of ignitor wire to rotary ignitor (A). • Attach valve to control panel holding valve in correct position using two #6-32x3/8" threaded screws (A). • Make sure valve is inside burner tube. Secure control panel using one #10x3/8” self-tap screw through single tab side (B). • Slide heat shield between fryer body and louver side of control panel. Secure with two #10x3/8" self-tap screws assuring h
Inhaltszusammenfassung zur Seite Nr. 14
• Turn fryer upright on its legs. Push on control knob and 4 ignitor knob (A). B • If not already assembled, slide handle springs onto side handles (B). Qty: 4 • Attach side handles to fryer body using two #10-24x1/2" #10-24x1/2" Screw screws on each handle (C). C A Ignitor Knob Control Knob #10-24x1/2" Screw • Slide grease tray onto grease tray rails. 5 Grease tray rails Grease Tray 14 • 07101378
Inhaltszusammenfassung zur Seite Nr. 15
• Place cooking pot and roaster basket into fryer body and storage lid on top. 6 • When cooking hang storage lid on handle as shown. NOTE: Before cooking on your fryer for the first time, refer to the seasoning supplement on how to prepare the fryer for cooking. It is recommended that you season you fryer prior to cooking. • Once seasoning is complete, the fryer is now ready for use. We recommend cooking foods on the “Low” setting, until you get familiar with your fryer. Storage Lid Roaster
Inhaltszusammenfassung zur Seite Nr. 16
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Possible Cause Prevention/Solution Gas leaking from • Damaged hose. • Turn off gas at LP cylinder or at source on natural gas systems. If cracked/cut/burned hose is cut or cracked, replace valve/hose/regulator. See LP hose. Cylinder Leak Test and Connecting Regulator to the LP Cylinder. Gas leaking from LP • Mechanical failure due to rusting or • Replace LP cylinder. cylind
Inhaltszusammenfassung zur Seite Nr. 17
Troubleshooting (continued) Problem Possible Cause Prevention/Solution Burner will not light • Rotary knob rotates without clicking. • Replace knob. using ignitor. • Sparking between ignitor and electrode. • Inspect wire insulation and proper connection. Replace wire if insulation is broken. • See “GAS ISSUES:” on previous page. Burner will not match • Match will not reach. • Use long-stem match (fireplace match). light. • See “Match-Lighting” section of Use and Care. • Improper method of matc
Inhaltszusammenfassung zur Seite Nr. 18
LIMITED WARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and examination. 90 DAYS LIMITED warranty on all parts against manufactu
Inhaltszusammenfassung zur Seite Nr. 19
Page Intentionally Blank 07101366 • 19
Inhaltszusammenfassung zur Seite Nr. 20
STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Oil-Less Turkey Fryer Safety Checklist Read and understand owners manual. Never overfill LP cylinder. Overfilled cylinders may cause freeze-up of regulator. Check tubes for spider webs. Ensure valves are correctly installed in burner tubes. Always ensure cont
