Résumé du contenu de la page N° 1
Read this manual before cooking on grill. Failure to follow all
manufacturer's instructions could result in serious personal injury and/
or property damage.
L P Gas Grill
Use And Care
To installer or person assembling grill: Leave this manual
with grill for future reference.
To consumer: Keep this manual for future reference.
For Outdoor Use Only
®
Combustion by-products produced when using this product contain
chemicals known to the State of California to cause cancer, birth
defects, or other r
Résumé du contenu de la page N° 2
FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP Tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. Call Grill Service Center For Help And Parts • If you need help or
Résumé du contenu de la page N° 3
Installation Safety Precautions • Use grill only with LP (propane) gas and the regulator/valve assembly supplied. • Grill installation must conform with local codes, or in their absence with National Fuel Gas Code, NFPA 54 / ANSI Z223.1 or CAN/CGA-B149.2 Propane Installation Code. Handling and storage of LP cylinders must conform to LP Gas Code NFPA/ANSI 58. Grill is not for use in or on recreational vehicles and/or boats. • All electrical accessories (such as rotisserie) must be electrically gr
Résumé du contenu de la page N° 4
Table of Contents For Your Safety .................................................................................................. 2 Call Grill Service Center For Help And Parts ....................................................... 2 Warranty Information ........................................................................................... 2 Installation Safety Precautions ............................................................................. 3 Safety Symbols ....................
Résumé du contenu de la page N° 5
• The safety relief valve on the LP tank could activate releasing gas and cause an intense fire with risk of death or serious injury. • NEVER store a spare LP tank under or near grill or in enclosed areas. • Never fill the cylinder beyond 80% full. An overfilled spare LP tank is hazardous due to possible gas released from the safety relief valve. • If you see, smell or hear escaping gas, immediately get away from the LP tank/grill and call your fire department. • All spare LP tanks must have saf
Résumé du contenu de la page N° 6
LP Tank • The LP tank used with your grill must meet the following requirements: • Purchase LP tanks only with these required measurements: 12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity maximum. • Be constructed and marked in accordance with specifications for LP tank of the U.S. Department of Transportation (DOT) or for Canada, CAN/CSA-B339, cylinders, spheres and tubes for transportation of dangerous goods, Transport Canada (TC). See LP tank collar for marking. •
Résumé du contenu de la page N° 7
Clockwise LP Tank Exchange • Many retailers that sell grills offer you the option of replacing your empty LP tank through an exchange service. Use only those reputable exchange companies that inspect, precision fill, test and certify their cylinders. Exchange your tank only for an OPD safety feature-equipped tank as described in the "LP Tank" section of this manual. • Always keep new and exchanged LP tanks in upright position during use, transit or storage. • Leak test new and exchanged LP tank
Résumé du contenu de la page N° 8
Straight Do not use a POL transport plug (A) (plastic part with A A A external threads)! It will defeat the safety feature of A A the valve. 5. Hold regulator, insert nipple (B) into LP tank valve. Hand tighten coupling nut, holding regulator in a straight line (C) with LP tank valve so as not to cross thread the connection. B B B B B Nipple has to be centered C C C C C into the LP tank valve Hold coupling nut and regulator as shown for proper connection to LP tank valve. 6. Turn the coupling n
Résumé du contenu de la page N° 9
• Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, immediately close LP tank valve and call LP gas supplier or your fire department! Leak Testing Valves, Hoses and Regulator 1. Turn all grill control knob(s) to OFF. 2. Be sure regulator is tightly connected to LP tank. 3. Completely open LP tank valve by turning hand wheel counter clockwise. If you hear a rushing sound, turn gas off immediately. There is a
Résumé du contenu de la page N° 10
For Safe Use Of Your Grill And To Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in bottom or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under a surface that can catch fire. • Do not use charcoal in a gas grill. • Use grill at least 3 ft. from any wall or surface. Main
Résumé du contenu de la page N° 11
• Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops turn knobs and LP tank off. • Do not leave grill unattended while preheating or burning off food residue on high. If grill has not been regularly cleaned a grease fire can occur that may damage the product. Before Your First Cookout • Light burners, check to make sure they are lit, close the lid an
Résumé du contenu de la page N° 12
Ignitor Lighting Big Easy ▲▲▲ Do not lean over grill while lighting. ▲▲ 1. Open lid. Turn on gas at LP tank. Rotisserie grills only: Push in and turn Burner Selector Knob to ON MAIN BURNERS. 2. Turn LEFT knob to HI. 3. Push IGNITOR Button rapidly, or hold, turn Ignitor Knob (up to 5 times) to light. Be sure burner lights and stays lit. 4. If burner does not light turn knob(s) to OFF, wait 5 minutes, try again. Two Burners: 5. Turn RIGHT knob to HI to l
Résumé du contenu de la page N° 13
Sideburner Ignitor Lighting 1. Turn gas on at LP tank. 2. Push in and turn knob to HIGH. 3. Turn or push (up to 5 times to light burner). Be sure burner lights and stays lit. 4. If burner does not light turn knob(s) to OFF, wait 5 minutes, try again. Match Lighting 1. Turn gas on at LP tank. 2. Hold lit match to any port on the burner. Push in and turn sideburner knob to HIGH. Be sure burner lights and stays lit. • If burner does not light turn knob(s) to OFF, wait 5 minutes, try
Résumé du contenu de la page N° 14
General Grill Cleaning • Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush to insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/ oven cleaner to painted surfaces. • Plated wire grate(s): wash grate(s) and drip vaporiser bar with concentrated grill clea
Résumé du contenu de la page N° 15
NATURAL HAZARD • SPIDERS FACT: Sometimes spiders and other small insects climb into the burner tubes attached to the burner. The spiders spin webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong and can block the flow of gas. Clean burner(s) prior to use after storing, at the beginning of grilling season or after a period of one month not being used. Typical spider webs inside burner Spider Guards are on the air intakes in an effort to reduce this problem
Résumé du contenu de la page N° 16
Cleaning The Traditional Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP tank. 2. Remove cooking grate and drip vaporiser bar. 3. Discard used briquets before removing burner and briquet grate. 4. Under grill remove grease cup. Beneath console disconnect short ignitor wire from ignitor (A). 5. Remove screw holding collector box (B). Note which hole on collector box used for
Résumé du contenu de la page N° 17
D D D D D Screw Single Valve Burner B B B B B Collector Box Dual Valve Burner with Briquet Grate Burner Tube Valve C C C C C Spring(s) Electrode Wire A A A A A Ignitor 17
Résumé du contenu de la page N° 18
Cleaning The Quick Set Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP tank. 2. Remove cooking grate and drip vaporiser bar. 3. Discard used briquets before removing burner and briquet grate. 4. Under grill remove grease cup, (unscrew ignitor button and remove battery on electronic ignition models), disconnect short ignitor wire (A) and clips from burner (B). To remove clips
Résumé du contenu de la page N° 19
Briquet Grate D D D D D Burner Electrode Valve Burner Tube Clip B B B B B C C C C C A A A A A Short Ignitor Wire – + Remove button and battery on electronic ignition models 19
Résumé du contenu de la page N° 20
Cleaning The Big Easy Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP tank. 2. Remove cooking grates, burner tent and tent frame. 3. Under grill remove soup can from grease clip. 4. Beneath left side of grill bottom remove ignitor wire by pulling down on ceramic insulator (A). Electronic Ignition Grills: Disconnect battery and then ceramic insulator with ignitor wire. 5. Unde
