Résumé du contenu de la page N° 1
Owner’s Manual
Manual del Propietario
030209
(5500W)
Questions? Help is just a moment away!
Preguntas? La ayuda es justa un momento lejos!
Call: Generator Helpline - 1-800-743-4115 M-F 8-5 CT
Llamada: Generador Helpline - 1-800-743-4115 M-F 8-5 CT
BRIGGS & STRATTON POWER PRODUCTS GROUP, LLC
Manual No. 195447GS
JEFFERSON,WISCONSIN, U.S.A.
Revision 0 (07/29/2004)
Résumé du contenu de la page N° 2
5500W Portable Generator TABLE OF CONTENTS SAFETY RULES Safety Rules. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 This is the safety alert symbol. It is used to Know Your Generator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 alert you to potential personal injury hazards. Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Obey all safety messages that follow this Operation . . . . . . . . . . . . . . . . . . . . .
Résumé du contenu de la page N° 3
5500W Portable Generator DANGER WARNING Running generator gives off carbon monoxide, Fuel and its vapors are extremely flammable and an odorless, colorless, poison gas. explosive. Breathing carbon monoxide will cause nausea, Fire or explosion can cause severe burns or fainting or death. death. Operate generator ONLY outdoors. WHEN ADDING OR DRAINING FUEL DO NOT operate generator inside any building or enclosure, Turn generator OFF and let it cool at least 2 minutes before including the gen
Résumé du contenu de la page N° 4
5500W Portable Generator WARNING CAUTION Excessively high operating speeds increase risk of injury and damage to generator. Unintentional sparking can result in fire or Excessively low speeds impose a heavy load. electric shock. DO NOT tamper with governed speed. Generator supplies correct rated frequency and voltage when running at governed WHEN ADJUSTING OR MAKING REPAIRS TO YOUR speed. GENERATOR DO NOT modify generator in any way. Disconnect the spark plug wire from the spark plug and p
Résumé du contenu de la page N° 5
5500W Portable Generator KNOW YOUR GENERATOR Read this owner’s manual and safety rules before operating your generator. Compare this illustration with your generator to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Rocker Switch Fuel Tank Recoil Starter Oil Fill Cap/Dipstick Choke Lever 120 Volt AC, 20 Amp Duplex Receptacles Air Cleaner Circuit Breakers 120/240 Volt AC, 30 Amp Receptacle Grounding Fastener Data Tag 120 Volt AC
Résumé du contenu de la page N° 6
5500W Portable Generator Engine manual ASSEMBLY Wheel kit Your generator requires some assembly and is ready for If any parts are missing or damaged, call the generator use after it has been properly serviced with the helpline at 1-800-743-4115. recommended oil and fuel. If you have any problems with the assembly of your INSTALL WHEEL KIT generator, please call the generator helpline at NOTE: While the wheel kit is designed to greatly improve 1-800-743-4115. If calling for assistance, please
Résumé du contenu de la page N° 7
5500W Portable Generator 5. Place one end of the needle nose pliers on the bottom Add Fuel of the axle and the other end of the pliers on top of NOTE: This gasoline engine is certified to operate on the e-ring. Seat the e-ring by pressing the pliers closed. gasoline. Exhaust Emission Control System: EM (Engine 6. Repeat step 3 through 5 to secure second wheel. Modifications). 7. Remove the temporary blocks. WARNING 8. Attach support leg using two 1/2” or 13mm wrenches Fuel and its vapors are ext
Résumé du contenu de la page N° 8
5500W Portable Generator USING THE GENERATOR OPERATING THE GENERATOR System Ground CAUTION The generator has a system ground that connects the generator frame components to the ground terminals on Exceeding generators wattage/amperage capacity can damage generator and/or electrical devices connected the AC output receptacles.The system ground is connected to it. to the AC neutral wire (the neutral is bonded to the generator frame). See “Don’t Overload Generator”. Start generator and let engi
Résumé du contenu de la page N° 9
5500W Portable Generator NOTE: If engine starts after 3 pulls but fails to run, or if RECEPTACLES unit shuts down during operation, make sure unit is on a level surface and check for proper oil level in crankcase. CAUTION This unit may be equipped with a low oil protection device. Receptacles may be marked with rating value greater See engine manual. than generator output capacity. WARNING NEVER attempt to power a device requiring more amperage than generator or receptacle can supply. Running
Résumé du contenu de la page N° 10
5500W Portable Generator Build a structure that will enclose three sides and the top 120 Volt AC, 20 Amp, Duplex of the generator: Receptacles 1. Make sure entire muffler-side of generator is exposed. Each duplex receptacle (Figure 5) is protected against Note that your generator may appear different from overload by a push–to–reset circuit breaker. that shown in Figure 6. Figure 5 — 120 Volt, 20 Amp Duplex Receptacle Figure 6 — Permanent Cold Weather Shelter Wind Use each receptacle to operate
Résumé du contenu de la page N° 11
5500W Portable Generator 4. Plug in and turn on the next load. DON'T OVERLOAD 5. Again, permit the generator to stabilize. GENERATOR 6. Repeat steps 4 and 5 for each additional load. NEVER add more loads than the generator capacity.Take special care to consider surge loads in generator capacity, Capacity as described above. You must make sure your generator can supply enough Figure 7 - Wattage Reference Chart rated (running) and surge (starting) watts for the items you Additional will power at
Résumé du contenu de la page N° 12
5500W Portable Generator NOTE: DO NOT use a garden hose to clean generator. SPECIFICATIONS Water can enter engine fuel system and cause problems. In Maximum Surge Watts . . . . . . . . . . . . . . . . . .8,500 watts addition, if water enters generator through cooling air slots, Continuous Wattage Capacity . . . . . . . . . . . .5,500 watts some of the water will be retained in voids and cracks of Power Factor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.0 the rotor and stator
Résumé du contenu de la page N° 13
5500W Portable Generator Engine Storage STORAGE See engine owner’s manual for instructions. The generator should be started at least once every seven days and allowed to run at least 30 minutes. If this cannot Other Storage Tips be done and you must store the unit for more than To prevent gum from forming in fuel system or on 30 days, use the following guidelines to prepare it for essential carburetor parts, add fuel stabilizer into fuel storage. tank and fill with fresh fuel. Run the unit for
Résumé du contenu de la page N° 14
5500W Portable Generator TROUBLESHOOTING Problem Cause Correction 1. One of the circuit breakers is 1. Reset circuit breaker. open. 2. Fault in generator. 2. Contact Authorized service facility. No AC output is available, but 3. Poor connection or defective cord 3. Check and repair. generator is running. set. 4. Connected device is bad. 4. Connect another device that is in good condition. 1. Short circuit in a connected load. 1. Disconnect shorted electrical load. Generator runs good at no-load
Résumé du contenu de la page N° 15
5500W Portable Generator NOTES 15
Résumé du contenu de la page N° 16
5500W Portable Generator SCHEMATIC 16
Résumé du contenu de la page N° 17
5500W Portable Generator WIRING DIAGRAM 17
Résumé du contenu de la page N° 18
5500W Portable Generator EXPLODED VIEW - MAIN UNIT 18
Résumé du contenu de la page N° 19
5500W Portable Generator EXPLODED VIEW - PARTS LIST Item Part # Description 1 M195451GS CRADLE 2 194150GS KIT,Vibration Mount 45° 4 190220GS HOUSING, Engine Adapter 5 NSP ASSY,Alternator (see page 20) 6 194151GS KIT, Hardware Mounting Adpter 8 96796GS WASHER, M8 Flat 10 190274BGS SBHCS, 3/8-16 x 1.0 Lg. 11 187365FGS HHCS, 5/16-24 x 7-7/16 14 695400 TAB, Locking 15 697255 GASKET, Exhaust 16 695312 SCREW 17 697252 MUFFLER 18 695399 SCREW, Shoulder 19 392390 SPARK ARRESTER, with Screw 20 B4986GS DE
Résumé du contenu de la page N° 20
5500W Portable Generator EXPLODED VIEW AND PARTS LIST - ALTERNATOR Item Part # Description 1 186059GS ADAPTER, Mounting,Alternator 2 190032GS ROTOR 3 190079AGS STATOR 4 186060GS RBC, with O-Ring (p/n 189197GS) 5 86308HGS HHCS, M6 - 1.0 x 140 SEMS 6 91825GS ASSY, Holder, Rectifier/Brush 7 66849GS TAPTITE, M5 - 0.8 x 16 8 22694GS RECEPTACLE, 6 pin 9 81917GS PIN, Roll, 4mm x 10 10 193428AGS ASSY,Wire, Ground 13 190356GS HARNESS,Wire, Power 20
