Résumé du contenu de la page N° 1
PN: ISVR1000 Rev: M
Model VR1000
OWNERS MANUAL
OPERATION, & PARTS
THIS MANUAL CONTAINS IMPORTANT INFORMATION ON THE OPERATION,
AND SAFE USE OF THIS EQUIPMENT.
THIS MANUAL IS INTENDED FOR THE END USER OF THIS PRODUCT.
Basic safety precautions should always be followed, including the following: Failure to follow instructions can cause severe
injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for one of
Résumé du contenu de la page N° 2
Page 2 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS IN THIS OWNER’S MANUAL AND ON EQUIPMENT. Before installing or servicing this electrical equipment, turn power supply OFF. KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF MISSING OR DAMAGED. WARNING – To reduce risk of injury, do not permit children to use or climb on the pumps and filters. Closely supervise children a
Résumé du contenu de la page N° 3
Page 3 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M WARNING - To reduce the risk of entrapment hazards: o When suction outlets are less than a 18” x 23” equivalent, a minimum of two functioning suction outlets per pump must be installed. Suction outlets in the same plane (i.e. floor or wall), must be installed a minimum of three feet (3’) [1 meter] apart, as measured from near point to near point. o Dual suction outlets shall be placed in such locatio
Résumé du contenu de la page N° 4
Page 4 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M General Information: The VR1000 Vacuum Release System is designed as a pump controller. The system will protect pool and spa equipment from certain mechanical failures, such as clogged drains and pipe breakage; which can cause premature pump motor failure. The system monitors and recognizes a change in pressure and electrical power. When a change occurs, it will shut down the pump, and vent the su
Résumé du contenu de la page N° 5
Page 5 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M FIG 3 Internal Control External FIG 2 FIG 5 FIG 4 Internal Control FIG 7 FIG 6 THREE PHASE PUMP MOTOR SUGGESTED CONNECTION USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400 www.haywardpool.com
Résumé du contenu de la page N° 6
Page 6 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M CUSTOMER SCREENS ON VR1000 No Action Required HAYWARD POOL PRODUCTS No Action Required 02-02-07 12:00 P.M. No Action Required. However, setting the time and date can be done at this time. SET TIME AND (If the date and time is not maintained from the last time it was set, the battery DATE? Y/N needs to be replaced.) If “YES” follow screen instructions SET TIMER EVENTS is the
Résumé du contenu de la page N° 7
Page 7 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M Over Window Vacuum indicates a vacuum level detected that is above normal for VR1000 OVER the pool system. The system should restart. WINDOW VACUUM Under Vacuum Window indicates a problem with the inlet water flow to the VR1000 UNDER pump. Low volume flow can be caused by line breaks, or low water levels. The WINDOW VACUUM system should restart. High Vacuum Alert indicates the system has stop
Résumé du contenu de la page N° 8
Page 8 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M The timer events are used to control the ON and OFF times of the Filter Pump, SET TIMER Booster Pump and Low Speed on a two speed Pump. Dip switch #4 Must be on to EVENTS? Y/N allow the timers to be set. A “YES” will allow the following timer settings. “YES” 7-day all the week long the pumps will run at the same times. Y= 7 DAY MODE “NO” Each days timers must be set N= EACH DAY MODE The 7-da
Résumé du contenu de la page N° 9
Page 9 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M OPERATIONS Normal operational mode monitors pool conditions for proper operation. The system operates in four basic states during normal pool monitoring. STARTUP – PULSING The vacuum solenoid valve is opened and closed several times to ‘soft start’ the system at startup time to warn swimmers that the pump is running. A self-test then occurs to verify that the sensor / solenoid subsystem is
Résumé du contenu de la page N° 10
Page 10 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M 4 8 2 5 FIG 8 1 6 SPARE PARTS Item Part Number Description Qty 1 VRX100E Solenoid Valve 24 VAC 1.0 2 GLX-RELAY Contactor/Relay OMRON G7L-2A-BUB-JCB (24DC) 1.0 3 VRX100KIT2 Fitting Kit with saddle fitting (See Fig 6) 1.0 4 VRX100H 250ma Fuse 1.0 5 VRX100PAK Tubing Replacement Kit 1.0 6 VRX100F Vent Filter ¼” NPTM (Pack includes 8’ hose & fittings 1.0 to extend hose above water level) 7 C
Résumé du contenu de la page N° 11
Page 11 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M WARNING – Hazardous Pressure. Pumps, filters, and other equipment components of a swimming pool filtration systems operate under pressure. Incorrectly installed and/or improperly tested filtration equipment and/or components may fail resulting in injury and/or property damage. Plumbing Use Teflon tape to seal threaded connections on molded plastic components. All plastic fittings must be new or th
Résumé du contenu de la page N° 12
Page 12 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M Wiring WARNING – All electrical wiring MUST be in conformance with all applicable local codes, regulations, and the National Electrical Code (NEC). Pump MUST be permanently connected to circuit. If other lights or appliances are also on the same circuit, be sure to add their amp loads before figuring wire and circuit breaker sizes. Use the load circuit breaker as the Master On-Off switch. In
Résumé du contenu de la page N° 13
Page 13 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M Maintenance Clean strainer basket regularly. Do NOT strike basket to clean. Inspect strainer cover gasket regularly and replace as necessary. Keep motor clean. Insure air vents are free from obstruction to avoid damage. Do NOT use water to hose off motor. Storage/Winterization WARNING – Separation Hazard. Do not purge the system with compressed air. Purging the system with compressed ai
Résumé du contenu de la page N° 14
Page 14 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M ® HAYWARD LIMITED WARRANTY This equipment was inspected before shipment from our plant. To original purchasers of this equipment, Hayward Pool Products, 620 Division Street, Elizabeth, New Jersey, warrants its products free from defects in materials and workmanship for a period of ONE (1) year from the date of purchase. Parts which fail or become defective during the warranty period, except as a
Résumé du contenu de la page N° 15
Page 15 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M © Hayward Pool Products 2007 All rights reserved. PRODUCT REGISTRATION (Retain For Your Records) DATE OF INSTALLATION ____________________ INITIAL PRESSURE GAUGE READING (CLEAN FILTER) _______________________ PUMP MODEL ________________ HORSEPOWER _______________________ FILTER MODEL ________________ SERIAL NUMBER _______________________ MO
Résumé du contenu de la page N° 16
Page 16 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M THIS PAGE IS BLANK USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400 www.haywardpool.com
