ページ1に含まれる内容の要旨
OWNERS MANUAL FOR
Permanently Lubricated Twin Cylinder Air Compressor
Specification Chart
Model No. FTV560V
!"
#
$
%!&'(
))
# *(+)*),-)
) $+ *). /
0)
+.)'
0)
+.'
+ 1
)%
+ 12
)%
SAFETY GUIDELINES - DEFINITIONS
This manual contains information
DANGER indicates an imminently hazardous situat
ページ2に含まれる内容の要旨
TABLE OF CONTENTS
1
ページ3に含まれる内容の要旨
IMPORTANT SAFETY INSTRUCTIONS • SAVE THESE INSTRUCTIONS IMPROPER OPERATION OR MAINTENANCE OF THIS PRODUCT COULD RESULT IN SERIOUS INJURY AND PROPERTY DAMAGE. READ AND UNDERSTAND ALL WARNINGS AND OPERATING INSTRUC- TIONS BEFORE USING THIS EQUIPMENT. HAZARD HOW TO PREVENT IT WHAT CAN HAPPEN RISK OF BURSTING AIR TANK THE FOLLOWING CONDITIONS COULD LEAD TO A WEAKENING OF THE TANK, AND RESULT IN A VIOLENT TANK EXPLOSION: 1. FAILURE TO PROPERLY DRAIN DRAIN TANK DAILY OR AFTER EACH USE. CONDENSED WA
ページ4に含まれる内容の要旨
HAZARD WHAT CAN HAPPEN HOW TO PREVENT IT YOUR AIR COMPRESSOR IS POWERED BY NEVER OPERATE THE COMPRESSOR OUT- RISK OF ELECTRICITY. LIKE ANY OTHER ELECTRI- DOORS WHEN IT IS RAINING OR IN WET ELECTRICAL SHOCK CALLY POWERED DEVICE, IF IT IS NOT USED CONDITIONS. PROPERLY IT MAY CAUSE ELECTRIC SHOCK. NEVER OPERATE COMPRESSOR WITH COVER COMPONENTS REMOVED OR DAM- AGE. REPAIRS ATTEMPTED BY UNQUALIFIED ANY ELECTRICAL WIRING OR REPAIRS PERSONNEL CAN RESULT IN SERIOUS REQUIRED ON THIS PRODUCT SHOULD BE IN
ページ5に含まれる内容の要旨
GLOSSARY CFM: Cubic feet per minute. When the tank pressure drops to a certain low level the motor will restart automatically. The low pressure at which the motor SCFM: Standard cubic feet per minute; a unit of measure of automatically restarts is called “cut-in pressure.” air delivery. Cut-Out Pressure: When you turn on your air compressor PSIG: Pounds per square inch gauge; a unit of measure of and it begins to run, air pressure in the air tank begins to build. pressure. It builds to a ce
ページ6に含まれる内容の要旨
The drain valve is located at the base of the air automatically release compressed air from the compressor tank and is used to drain condensation at the end of each use. head and the outlet tube when the air compressor reaches “cut-out” pressure or is shut off. If the air is not released, the
ページ7に含まれる内容の要旨
Grounding Instructions Locate the air compressor in a clean, dry and well ventilated area. The air filter must be kept clear of ob
ページ8に含まれる内容の要旨
" " " " "
5. Open the globe valve by turning it counter clockwise. Open the regulator by turning it clockwise. Adjust the 1. Before attaching air hose or accessories, make sure the regulator to the correct pressure setting. Your ON/AUTO lever is set to “OFF” and
ページ9に含まれる内容の要旨
( (
( ( (
Motor The motor has an automatic reset thermal overload protec- Keep the air filter clean at all times. Do not operate the tor. If the motor overheats for any reason, the o
ページ10に含まれる内容の要旨
PERFORMING REPAIRS MAY EXPOSE VOLTAGE SOURCES, MOVING PARTS OR COMPRESSED AIR SOURCES. PERSONAL INJURY MAY OCCUR. PRIOR TO ATTEMPTING ANY REPAIRS, DISCONNECT POWER SOURCE FROM THE COMPRESSOR AND BLEED OFF TANK AIR PRESSURE. PROBLEM CAUSE CORRECTION Excessive tank pressure - safety Pressure switch does not shut off Move the pressure switch lever to the “OFF” po- valve pops off. m
ページ11に含まれる内容の要旨
PROBLEM CAUSE CORRECTION Motor will not run or restart. Motor overload protection switch has Let motor cool off and overload switch will auto- tripped. matically reset. Tank pressure exceeds pressure Motor will start automatically when tank pressure switch “cut-in” pressure. drops below “cut-in” pressure of pressure switch. Wrong gauge wire or length of exten- Check for proper gauge wire and cord length. sion cord. Check valve stuck open. Remove and clean, or replace. Loose electrical connection
ページ12に含まれる内容の要旨
< 9 ( = ( "(/
=
!"# / #; "+ $ %&' ( )"! )* 7(::"8 >4 )> ; +, -.//" ; +"+"!
(" 0" . (/"
123 4)
ページ13に含まれる内容の要旨
KEY NO. PART NUMBER DESCRIPTION 1 MO-9074 Motor * + 2 ----- Sleeve, Cylinder (2 used) * 3 ----- Connecting Rod (2 used) *+ 4 ----- Compression Ring (2 used) * 5 ACG-29 Connecting Rod Cap (2 used) *+ 6 SSF-3158-1 Screw, 10-24 x .75 (2 used) * 7 SSG-8156 O-ring (2 used) 8 AC-0032 Valve Plate Assembly (2 used) * 9 ACG-45 O-ring, Perm Lube Head (2 used) 10 AC-0037 Head, Right 11 AC-0038 Head, Left 12 SSF-927 Screw, THD Formi
ページ14に含まれる内容の要旨
OWNERS MANUAL FOR Permantly Lubricated Twin Cylinder Air Compressor Call our Toll Free Number 1-800-888-2468, Ext 2, then Ext 1, to obtain the location of the nearest Authorized Service Center for ordering repair parts and for warranty repairs. 24 hours a day, 7 days a week. When ordering repair parts from your local Authorized Service Center, always give the following information: Model number of your product Part number and description of the item you wish to purchase WARRANTY Attach Sales
