Summary of the content on the page No. 1
“Serving Those Who Serve The Very Best”®
SAFE & EASY™
FILTER
OWNERS MANUAL
This Owner’s Guide provides specific operating instructions for your model.
Use the Safe & Easy Filter only as instructed in this Service Guide.
Versión en español
Si desea obtener usa copia en español de estes Manual del Usuario,
sirvase escribir la dirección que se incluye a continuadión.
1-800-KEATING
www.keatingofchicago.com
037402
Summary of the content on the page No. 2
READ AND SAVE THIS MANUAL FOR FUTURE REFERENCE Record the Model No. and Serial No. (located on the back of the motor housing) of this Safe & Easy Filter in the space provided below. Serial No. ____________________________________________________________ Model No. ____________________________________________________________ Keep these numbers for future reference IMPORTANT: Keep a copy of your bill of sale. The date on the bill establishes the warranty period should service be required. If servic
Summary of the content on the page No. 3
SAFE & EASY FILTER O OP PE ER RA AT TI IN NG G I IN NS ST TR RU UC CT TI IO ON NS S A. PREPARING THE FILTER-DRAWER CRUMB CAUTION BASKET WATER IN ANY FORM & HOT OIL DON'T MIX! NOTE: Operator should be outfitted with proper SPRINKLE ACIDOX EVENLY ON PAPER protective attire: safety goggles, oil and heat resistant gloves, apron and footwear Filter assembly inside of cabinet: HOLD DOWN RING 1. Pull the handle marked “Pull to Release Filter” (top of filter panel). 2. Remove the entire assembly fro
Summary of the content on the page No. 4
9. Sprinkle Keating Acidox Powder evenly over the paper. 10. Replace crumb basket and push drawer fully into cabinet. Ensure the connection on top of the housing mates with the connection inside the cabinet. Pull the front of the filter system lightly to verify proper connection NOTE: Cabinet door should be closed during filtration. NOTE: For best results, new filter paper and Acidox Powder must be used for each fryer. B. PREPARING OIL FOR FILTRATION NOTE: Oil in fryer must be between 250° - 35
Summary of the content on the page No. 5
Failure to do so may cause the drain lines to clog up. NOTE: If the pump shuts down, turn it off and let the motor cool. Push the motor reset button located on the filter panel. Check filtering procedure or clean tub and paper if needed. 6. Let swirling action rinse down fryer. 7. Fully drain fryer. NOTE: Pump should be run for at least 30 seconds after FIGURE 6. crumbs are removed from fryer. This will help prevent blockage in the drain lines. 8. Close drain valve by pushing in the large black
Summary of the content on the page No. 6
4. Push the small black knob on the filter panel to the left (“Oil to Hose”). 5. Place the nozzle of the hose in an approved discard container. 6. Drain the oil. 7. Plug the filter into the receptacle. 8. Turn the motor switch ON (the green light will illuminate). CAUTION A KEATING FRYER OR FILTER SHOULD BE DRAINED Connect hose here to discard oil ONLY UNDER THE SUPERVISION OF PROPERLY TRAINED PERSONNEL. WHEN DISCARDING OIL, A COVERED RECEPTACLE APPROVED FOR USE WITH HOT OIL SHOULD BE USED. USE
Summary of the content on the page No. 7
SAFE & EASY FILTER PARTS LIST Description Part No. 1. Quick Connect Coupler 052573 Compression Fitting Straight 011087 2. Caster Swivel 2” 054919 3/8-16 Acorn Nut 011763 3/8 Split Lockwasher 009085 12 3. Quick Connect Nipple 052572 Rubber Grommet 053445 4. Motor & Pump 052982 5. Three way valve 009354 11 6. Knob Black 031532 7. Filter Tub Only 14” 053444 18” 053172 10 20” 053123 24” 054173 8. Sump Screen 14” 052631 9 18” 053195 20” 053128 24” 054331 4 9. Filter Paper SE 14” 052932 18” 053850 20”
Summary of the content on the page No. 8
Self-Help Guide PROBLEM PROBABLE SOLUTION CAUSE (Follow Sequentially) Tub not set up properly. Place components in tub per the following: Motor runs but will not pump oil. 1. Sump screen on the very bottom 2. Filter paper over sump screen (Lie it flat on the bottom, creasing the sides). 3. Hold down ring (ensure paper is not folded, lock hold down ring into place ensuring a tight seal). 4. Sprinkle acidox powder evenly over filter paper (1bag per 40 lbs. of oil). 5. Crumb basket for large d
Summary of the content on the page No. 9
Self-Help Guide (Continued) PROBLEM PROBABLE SOLUTION CAUSE (Follow Sequentially) Oil has not penetrated the filter 1. Let oil sit in the filter pan for Motor runs but will not paper approximately 2 minutes and try again pump oil. Not plugged in 1. Plug filter into the receptacle inside of Motor not making any cabinet noise 2. Turn ON/OFF switch to ‘ON’. Motor has overheated 1. Allow motor to cool for approximately 10 minutes. 2. Press the reset button near the ON/OFF switch on the filter co
Summary of the content on the page No. 10
WIRING DIAGRAM KEATING OF CHICAGO, INC. Tel. 708-544-6500 • Fax 708-544-6505 If you have any questions regarding filtering Toll Free 1-800-KEATING (In U.S. and Canada) procedures or need assistance, call: www.keatingofchicago.com 1-800-KEATING. manuals/domestic/filters/safeandeasy – 8 – 11/05
Summary of the content on the page No. 11
WARRANTY LIMITED WARRANTY Keating Of Chicago, Inc. ("Keating”) warrants to the original purchaser. ("Customer"), all new Keating Fryers, Filter Systems, Griddles, Keep Krisp®, Custom Pasta Systems, Top-Side™ Cookers, Computer Timers, Fryer & Pasta Vessels, and Keating replacement parts ("products") installed after June 1, 1994 to be free to defects in material or workmanship, subject to the following terms and conditions. LENGTH OF WARRANTY All products other than Fryer & Pasta Vessels and repla
Summary of the content on the page No. 12
SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. Phone: (708) 544-6500 FAX: (708) 544-6505 Toll Free 1-800-KEATING (In U.S. and Canada) www.keatingofchicago.com *As continuous product improvement occurs, specifications may be changed without notice. KEATING LIMITED WARRANTY CARD PLEASE C
