Summary of the content on the page No. 1
GAS GRILL
LP Gas Grill Owner’s Guide
ESNA
Guía del Propietario del Asador de Gas Propano Licuado - Pg. 23
Mode d’emploi du grill à gaz PL - Pg. 43
310
#56514
You Must reAd this owner’s Guide m wArninG: follow all leak-check
before oPerAtinG Your GAs GriLL.
procedures carefully in this manual prior
to barbecue operation. do this even if the
barbecue was dealer-assembled.
m dAnGer
if you smell gas:
notiCe to instALLer: these instructions
1. shut off gas to the appliance.
must be left with t
Summary of the content on the page No. 2
WARNINGS m dAnGer failure to follow the dangers, warnings and Cautions contained in this owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m wArninGs m do not attempt to disconnect any gas fitting while your m do not store a spare or disconnected liquid propane barbecue is in operation. cylinder under or near this barbecue. m improper assembly may be dangerous. Please follow the m use heat-resistant barbecue mitts or gloves w
Summary of the content on the page No. 3
TALE b oF coNTENTS WARNINGS.......................................... 2 TAbLE oF coNTENTS................................. 3 vEXPLoDED VIEW 310 ................................. 4 EXPLDED VIEW LIST 310 o ............................. 5 WARRANTY ......................................... 6 GENERAL INSTRUc TIoNS ............................. 7 CANADIAN INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 OPERATING . . . . . . . . . . . . .
Summary of the content on the page No. 4
vEXPLoDED VIEW 310 • DIAGRAmA DE DESPIE cE 310 • VUE E cLATEE 310 Genesis_310_LP_US_061110 1 2 3 23 4 5 6 7 8 24 9 10 25 26 11 27 12 28 29 13 30 14 31 15 32 16 33 17 34 35 18 19 36 37 20 38 21 39 40 22 41 42 43 4
Summary of the content on the page No. 5
EXPLoDED VIEW LIST 310 • LISTA DEL DIAGRAA DE DESPIE m cE 310 • LISTE DE LA VUE EcLATEE 310 1. thermometer 16. Catch Pan 31. w ind deflector Termómetro Plato recolector Deflector de viento Thermomètre Egouttoir Déflecteur de vent 2. thermometer bezel 17. Catch Pan holder 32. Control Knob Moldura decorativa del termómetro Soporte del plato recolector Perilla de control Collerette du thermomètre Support de l’égouttoir Bouton de commande 3. shroud 18. Left f rame Panel 33. Manifold hose Cubierta Pa
Summary of the content on the page No. 6
WARRANTY Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this ® Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum castings: 25-years (2 years on paint; excludes fading) Stainless steel shroud: 25-years Porcelain-enameled shroud: 25-years Stainless steel burner tubes: 10-years Stainless steel cooking grates: 5-years no rust through or burn through ® Stainless steel Flavorizer bars: 5-y
Summary of the content on the page No. 7
GENERAL INSTRUc TIoNS ® ® Your Weber gas barbecue is a portable outdoor cooking appliance . With the Weber stor AGe And/or nonuse gas barbecue you can grill, barbecue, roast and bake with results that are difficult to ® ® • The g as m ust be tur ned of f at the liquid pr opane c ylinder when the W eber gas duplicate with indoor kitchen appliances . The closed lid and Flavorizer bars produce barbecue is not in use . that “outdoor” flavor in the food . ® • W hen the W eber gas barbecue is
Summary of the content on the page No. 8
GAS INSTRUc TIoNS sAfe hAndLinG tiPs for LiQ uid ProPAne GA s CYLinders • Liquid P r opane (LP) g as is a petr oleum pr oduct as ar e g asoline and natur al g as . LP gas is a gas at regular temperatures and pressures . Under moderate pressure, inside a cylinder, LP gas is a liquid . As the pressure is released, the liquid readily vaporizes and becomes gas . • LP g as has an odor similar t o natur al g as . Y ou should be a w ar e of this odor . • LP g as is hea vier than air . Le
Summary of the content on the page No. 9
GAS INSTRUc TINS o iMPort Ant LP CYLinder inforMA tion 5 2 4 3 m dAnGer 1 ® neVer store a spare LP cylinder under or near weber gas appliances. neVer fill the tank beyond 80% full. failure to follow these statements exactly may result in a fire causing death or serious injury. 2 ® 4 Weber gas appliances are equipped for a cylinder supply system designed for vapor 5 3 withdrawal . 1 ® m wArninG: only use weber gas appliances outdoors in a well-ventilated area. do not use in a garage, buildin
Summary of the content on the page No. 10
GAS INSTRUc TIoNS A) Open base cabinet doors . Bring regulator and hose forward out of cabinet (1) . B) Locate hose retention clip (2) on regulator hose . Secure into slot (3) on underside of 1 tank scale . 3 2 m wArninG: the hose must be secured to the tank scale with the hose retention Clip. failure to do so could cause damage to the hose resulting in a fire or explosion which can cause serious bodily injury or death, and damage to property. Some LP tanks have differing top collar assemb
Summary of the content on the page No. 11
GAS INSTRUc TINS o r emove Control Knobs & Control Panel f or Leak t esting You will need: Phillips screwdriver . A) Remove control knobs, igniter button, retention nut, and battery (1) . B) Remove screws from wind deflector with a Phillips screwdriver (2) . ! C) Tilt end of wind deflector down and slide wind deflector away to remove (3) . D) Let igniter module dangle from wires . Do not disconnect (4) . E) Remove screws from underside of control panel with Phillips screwdriver (5) . F) Lift con
Summary of the content on the page No. 12
GAS INSTRUc TIoNS Check A) Regulator hose to bulkhead connection (1) . B) Main gas line to bulkhead connection (2) . C) Main gas line to manifold connections (3) . 7 m wArninG: if there is a leak at connections (1, 2, or 3), retighten the fitting with a wrench and recheck for leaks with soap and water solution. if a leak persists after retightening the fitting, turn off the gas. do not oPerAte the GriLL. Contact the Customer service representative in your area using the contact information
Summary of the content on the page No. 13
bEF RE USING THE GRILL o fueL LeVeL 1 2 3 Check the fuel level by viewing the color indicator level line, located on the side of the tank scale . A) Empty (1) B) Medium (2) C) Full (3) ◆ sLide-out GreA se tr AY And disPos AbLe driP PAn Your grill was built with a grease collection system . Check the slide-out grease tray and disposable drip pan for grease build-up each time you use your grill . Remove excess grease with a plastic spatula; see illustration . When necessary, wash the grease tra
Summary of the content on the page No. 14
mAIN URNER IGNITI b N & USA o GE MAin burner iGnition Summary lighting instructions are inside the left hand cabinet door . m dAnGer failure to open the lid while igniting the barbecue’s burners, off st Art/hi MediuM Low or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up which can cause serious bodily injury or death. electronic ignition s ystem Note: Each control knob operates an individual burner. The Electronic Ignition
Summary of the content on the page No. 15
AIN m bURNER IGNITIN & USA o GE MAin burner MAnu AL iGnition m dAnGer 1 failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up 6 which can cause serious bodily injury or death. 4 2 5 A) Open the lid (1) . 2 B) Make sure all burner control knobs are turned off (2) . (Push control knob in and turn clockwise to ensure that it is in the OFF position .) m wArninG: the
Summary of the content on the page No. 16
GRILLING TIPS & HELPFUL HINTS ® • Al w a y s pr eheat the g r ill bef or e cooking . Set all b ur ner s on HI heat and close lid; heat fLAV oriZer sYste M f or 1 0 min ut es , or until ther momet er r egist er s 500°-550° F (260°-288°C). ® When meat juices drip from the food onto the specially angled Flavorizer bars, • Sear meats and cook with the lid do wn f or perf ectl y g r illed f ood e v er y time . they create smoke that gives foods an irresistible barbecued flavor . Thanks to t
Summary of the content on the page No. 17
TRoULESH b oo TING PRLE ob m HE c cK SoLUTIoN burners burn with a yellow or orange flame, in Inspect Spider/Insect screens for possible obstructions . Clean Spider/Insect screens . Refer to “ANNUAL conjunction with the smell of gas. (Blockage of holes .) MAINTENANCE” . symptoms: The excess flow safety device, which is part of the To reset the excess flow safety device turn all burner barbecue to cylinder connection, may have activated . control knobs and the cylinder valve off . Disconnect bu
Summary of the content on the page No. 18
mAINTENANcE ® CLeAninG weber sPider/inseCt sCreens ® ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders m wArninG: turn your weber gas barbecue off and wait for and other insects . They can nest in the venturi section (1) of the burner tubes . This it to cool before cleaning. blocks the normal gas flow, and can cause the gas to flow back out of the combustion air ® m CAution: do not clean your flavorizer bars or cooking opening . This could result in a
Summary of the content on the page No. 19
AINTENAN m E c burner tubes CLeAninG or rePLACeMent You will need: Phillips screwdriver and flathead screwdriver . ® A) Your Weber gas barbecue must be OFF and cool . B) Turn gas OFF at source . ! ® C) Remove cookbox components - warming rack, grates and Flavorizer bars . (Heat deflectors do not need to be removed .) Control Panel r emoval To remove control panel: A) Remove control knobs, igniter button, igniter retention nut, and battery (1) . B) Remove screws from wind deflector (2) located u
Summary of the content on the page No. 20
mAINTENANcE burner t ube r emoval To remove burner tube(s): 7 A) Remove igniter wire(s) from igniter clip(s) (7) . 8 B) Remove screw that holds burner tube to the cookbox using a flathead screwdriver (8) . C) Pull burner tube assembly (this includes igniter) up and out of cookbox (9) . Note: 310/320 units will have an additional grounding wire attached to the center burner tube (10). burner t ube Cleaning To clean the burner tube(s): A) Look inside each burner with a flashlight (11) . B) Clean
