Summary of the content on the page No. 1
GS a GrILL
LP Gas Grill Owner’s Guide
ESNA
Guía del Propietario de la Barbacoa de Gas Propano Licuado - Pg. 25
Mode d’emploi du grill à gaz PL - Pg. 47
320
#89962
You Must read this owner’s Guide m warninG: follow all leak-check
Before oPeratinG Your Gas GriLL.
procedures carefully in this manual prior
to barbecue operation. do this even if the
barbecue was dealer-assembled.
m danGer
if you smell gas:
notiCe to instaLLer: these instructions
1. shut off gas to the appliance.
must be left wi
Summary of the content on the page No. 2
WarNINGS m danGer failure to follow the dangers, warnings and Cautions contained in this owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m warninGs m do not attempt to disconnect any gas fitting while your barbecue is in operation. m do not store a spare or disconnected liquid propane m use heat-resistant barbecue mitts or gloves when operating cylinder under or near this barbecue. barbecue. m improper assembly may be dang
Summary of the content on the page No. 3
TabLE oF NTENTS co WNINGS ar .......................................... 2 INTEN ma aNcE ..................................... 20 CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 ® TabLE oF NTENTS co ................................. 3 WEBER SPIDER/INSECT SCREENS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 BURNER TUBES CLEANING OR REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . 21 ® EXPLoDED VI
Summary of the content on the page No. 4
EXPLoDED VIEW 320 • DIa G DE DESPIE rama E 320 • VUE E c L c a TEE 320 Spirit_320_LP_US_042110 1 2 3 4 24 5 6 7 25 8 26 9 27 28 10 29 11 30 31 12 13 32 33 14 34 15 35 16 36 37 17 18 19 38 20 39 21 40 22 41 42 23 43 4
Summary of the content on the page No. 5
EXPLDED VIEW LIST 320 o • LIST DEL DI a a G DE DESPIE rama cE 320 • LISTE DE L VUE E a L c a TEE 320 1. shroud hardware 17. Catch Pan holder 33. Manifold Accesorios de la cubierta Soporte del plato recolector Múltiple Kit d’assemblage de boîtier Support de lèchefrite Collecteur 2. thermometer 18. disposable drip Pan 34. hose / r egulator Termómetro Bandeja de goteo desechable Manguera / Regulador Thermomètre Lèchefrite jetable Tuyau/ Régulateur 3. thermometer Bezel 19. Catch Pan 35. hose r etent
Summary of the content on the page No. 6
WarraNTY Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this ® Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum castings: 25-years (2 years on paint; excludes fading) Stainless steel shroud: 25-years Porcelain-enameled shroud: 25-years Stainless steel burner tubes: 10-years Stainless steel cooking grates: 5-years no rust through or burn through ® Stainless steel Flavorizer bars: 5-y
Summary of the content on the page No. 7
GENEraL INSTU r c TINS o ® ® Your Weber gas barbecue is a portable outdoor cooking appliance . With the Weber stora Ge and/or nonuse gas barbecue you can grill, barbecue, roast and bake with results that are difficult to ® ® • The g as m ust be tur ned of f at the liquid pr opane c ylinder when the W eber gas duplicate with indoor kitchen appliances . The closed lid and Flavorizer bars produce barbecue is not in use . that “outdoor” flavor in the food . ® • W hen the W eber gas barbecue
Summary of the content on the page No. 8
GaS INSTrUc TIoNS safe handLinG tiPs for LiQ uid ProP ane G as CYLinders • Liquid P r opane (LP) g as is a petr oleum pr oduct as ar e g asoline and natur al g as . LP gas is a gas at regular temperatures and pressures . Under moderate pressure, inside a cylinder, LP gas is a liquid . As the pressure is released, the liquid readily vaporizes and becomes gas . • LP g as has an odor similar t o natur al g as . Y ou should be a w ar e of this odor . • LP g as is hea vier than air . L
Summary of the content on the page No. 9
GaS INSTU r c TIoNS iMPortant LP CYLinder inforMation 5 2 4 3 m danGer 1 ® neVer store a spare LP cylinder under or near weber gas appliances. neVer fill the tank beyond 80% full. failure to follow these statements exactly may result in a fire causing death or serious injury. ® 2 4 Weber gas appliances are equipped for a cylinder supply system designed for vapor 5 3 withdrawal . 1 ® m warninG: only use weber gas appliances outdoors in a well-ventilated area. do not use in a garage, building
Summary of the content on the page No. 10
GaS INSTrUc TIoNS A) Open base cabinet doors . B) Pass the regulator hose through the side panel opening to the inside of the base cabinet . (1) C) Slide the hose retention bracket (2) along the hose and through the side panel opening to the inside of the base cabinet . D) Position the hose retention bracket on the right inside panel and secure with two hex/washer/bolts (3) . m warninG: the hose must be secured to the side panel with the hose retention Bracket. failure to do so could cause
Summary of the content on the page No. 11
GS INST a U r c TINS o r emove Control Knobs & Control Panel f or Leak t esting 1 2 You will need: Phillips screwdriver . A) Take off the burner control knobs (1) . B) Remove screw and washer from back of control panel with a Phillips screwdriver (2) . C) Remove machine screw from lower left and right side of control panel with a Phillips screwdriver (3) . 3 D) Tilt the back edge of the control panel up . Carefully lift control panel up and away from frame (4) . E) Disconnect the igniter wire
Summary of the content on the page No. 12
GS INST a U r c TINS o Check A) Hose-to-manifold connection (1) . B) Side burner hose-to-manifold connection and side burner hose-to-side burner gas line connection (2) . C) Side burner hose-to-side burner connection, side burner valve and orifice connections (3) . m warninG: if there is a leak at connection (1, 2, or 3), re- tighten the fitting with a wrench and recheck for leaks with soap and water solution. if a leak persists after re-tightening the fitting, turn off the gas. do not oPera
Summary of the content on the page No. 13
bEF E USING THE G or ILL r sLide-out Grease tra Y and disPosaBLe driP P an Your grill was built with a grease collection system . Check the slide-out grease tray and disposable drip pan for grease build-up each time you use your grill . Remove excess grease with a plastic spatula; see illustration . When necessary, wash the grease tray and drip pan with a soap and water solution, then rinse with clean water . Replace the disposable drip pan as needed . m warninG: Check the slide-out grease tr
Summary of the content on the page No. 14
IN ma U b rNEr IGNITIoN & USa GE Main B urner iGnition Summary lighting instructions are inside the left hand cabinet door . 2 2 OFF APAGADO OFF ARRETE APAGADO ARRETE 5 5 m danGer failure to open the lid while igniting the barbecue’s burners, 1 4 1 or not waiting five minutes to allow the gas to clear if the 4 barbecue does not light, may result in an explosive flare-up which can cause serious bodily injury or death. 1 ® Crossover ignition system Note: The Crossover® Ignition System ignites
Summary of the content on the page No. 15
maIN bUNE r IGNITI r N & US o a GE Main B urner ManuaL iGnition 2 m danGer OFF APAGADO ARRETE failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up 1 5 which can cause serious bodily injury or death. 1 A) Open the lid (1) . B) Make sure all burner control knobs are turned OFF (2) . (Push each knob down and turn clockwise to ensure they are in the OFF position .
Summary of the content on the page No. 16
SIDE bUNE r r IGNITIN & US o a GE side B urner iGnition the grill illustrated may Summary lighting instructions are inside the left hand cabinet door . have slight differences than the model purchased. m danGer failure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up which can cause serious bodily injury or death. 2 1 m warninG: Check hose before each use of barbecue f
Summary of the content on the page No. 17
SIDE U b NE r IGNITI r N & US o a GE side B urner ManuaL iGnition the grill illustrated may have slight differences m danGer than the model purchased. failure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death. 2 A) Open the side burner lid (1) . B) Check that the side burner valve is turned off (2) (Push control knob in and
Summary of the content on the page No. 18
GrILLING TIPS & HELPFUL HINTS • Al w a y s pr eheat the g r ill bef or e cooking . Set all b ur ner s on HI heat and close lid; heat f or 1 0 min ut es , or until ther momet er r egist er s 500°-550° F (260°-288°C). • Sear meats and cook with the lid do wn f or perf ectl y g r illed f ood e v er y time . • Gr illing times in r ecipes ar e based on 70°F (20°C) w eather and lit tle or no wind. Allo w more cooking time on cold or windy days, or at higher altitudes . Allow less cooking
Summary of the content on the page No. 19
TU ro LESH b oo TING PLE rob m HE c K c SL o UTIoN Burners burn with a yellow or orange flame, in Inspect Spider/Insect screens for possible obstructions . Clean Spider/Insect screens . Refer to “ANNUAL conjunction with the smell of gas. (Blockage of holes .) MAINTENANCE” . symptoms: The excess flow safety device, which is part of the To reset the excess flow safety device turn all burner barbecue to cylinder connection, may have activated . control knobs and the cylinder valve off . Disconnec
Summary of the content on the page No. 20
maINTENaNcE ® CLeaninG weBer sPider/inseCt sCreens ® ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders m warninG: turn your weber gas barbecue off and wait for and other insects . They can nest in the venturi section (1) of the burner tubes . This it to cool before cleaning. blocks the normal gas flow, and can cause the gas to flow back out of the combustion air ® m Caution: do not clean your flavorizer bars or cooking opening . This could result in a
