Summary of the content on the page No. 1
GAS GRILL
Natural Gas Grill Owner’s Guide
Guía del Propietario de la Barbacoa de Gas Natural - Pg 32
Guide de l’utilisateur du barbecue au gaz naturel - Pg 53
Assembly, Ensamblaje, Assemblage - Pg 9
E/S-420/450
#89561
YOU MUST READ THIS OWNER’S GUIDE WARNING: Follow all leak-check
BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructi
Summary of the content on the page No. 2
2 WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should b
Summary of the content on the page No. 3
3 WARRANTY, GARANTÍA, GARANTIE ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and routine maintenance, includ
Summary of the content on the page No. 4
4 PARTS LIST, LISTE DES PIÈCES, LISTA DE PIEZAS Catch Pan Holder Drip Tray 1 1 1 1 Sostenedor del plato recolector Bandeja de goteo Support de l’égouttoir Plateau de recueil des gouttes ® Flavorizer Bar Catch Pan 1 1 ® Barras Flavorizer 9 8 Plato recolector ® Barre Flavorizer Egouttoir Smoker Bar Cooking Grate 2 2 - 1 Barra del ahumador Parrilla de cocción Barre du fumoir Grille de cuisson Smoker Box - 1 Caja del ahumador Warming Rack 1 1 Boîtier du fumoir Rejilla para calentar Grille de mainti
Summary of the content on the page No. 5
5 EXPLODED VIEW E/S-420 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE E/S 420_NG_US 5 1 2 3 4 5 6 7 8 27 9 10 11 12 28 13 29 14 30 15 16 31 17 18 32 19 20 33 21 22 34 35 36 23 37 38 24 39 25 26 40 41 42 ® WWW.WEBER.COM
Summary of the content on the page No. 6
6 EXPLODED VIEW LIST E/S-420 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 16. Knob 31. Manifold Hose Accesorios de la cubierta Perilla Manguera del múltiple Structure de protection Bouton Tuyau du collecteur 17. Water Baffle / Heat Shield 2. Shroud 32. Side Burner Lid Cubierta Reflector de agua / Pantalla térmica Tapa del quemador lateral Tôle de protection Protection contre l’eau/Cloison anti-chaleur Couvercle du brûleur latéral 18. Disposable Drip Pan 3. Therm
Summary of the content on the page No. 7
7 EXPLODED VIEW E/S-450 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE E/S 450_NG_US 7 1 2 3 31 4 32 5 33 6 34 7 35 8 36 9 37 10 11 38 12 39 13 40 14 41 15 16 42 17 18 43 19 44 20 21 45 22 23 46 24 25 47 26 48 49 50 27 51 52 28 29 30 53 54 55 ® WWW.WEBER.COM
Summary of the content on the page No. 8
8 EXPLODED VIEW LIST E/S-450 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 20. Large Knob Bezel 38. Smoker Box Accesorios de la cubierta Moldura decorativa de la perilla grande Caja del ahumador Structure de protection Plaque indicatrice du grand bouton Boîtier du fumoir 2. Shroud 21. Water Baffle / Heat Shield 39. Smoker Bar Cubierta Reflector de agua / Pantalla térmica Barra del ahumador Tôle de protection Protection contre l’eau/Cloison anti-chaleur Barre du f
Summary of the content on the page No. 9
ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 9 • Adjust doors, if necessary 9 • Si fuese necesario, ajuste la puerta 1 • Ajustez la porte si nécessaire 4 2 3 E/S-450 4 - 4 - 5 ® WWW.WEBER.COM
Summary of the content on the page No. 10
10 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 6 3 - 3 - 7 8 ® WWW.WEBER.COM
Summary of the content on the page No. 11
11 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 11 9 E/S-450 10 2 - 2 - 11 ® WWW.WEBER.COM
Summary of the content on the page No. 12
+ + + 12 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE AAA 12 AAA 1 - 2 - AAA ™ The Weber Grill Out Handle Light has a “Tilt Sensor”: Lid up - ON / Lid Closed - OFF. The power button (a) activates or deactivates the “Tilt Sensor.” For daytime use, deactivate the sensor by pressing power button (a). ™ La Lámpara de Asa Weber Grill Out tiene un “sensor de inclinación”: tapa abierta - ENCENDIDA / tapa cerrada - APAGADA. El botón de encendido (a) activa o desactiva al “sensor de inclinación”. Par
Summary of the content on the page No. 13
GENERAL INSTRUCTIONS 13 ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber OPERATING gas barbecue you can grill, barbecue, roast and bake with results that are difficult to 13 ® WARNING: Only use this barbecue outdoors in a well- duplicate with indoor kitchen appliances. The closed lid and Flavorizer bars produce that “outdoor” flavor in the food. ventilated area. Do not use in a garage, building, breezeway ® The Weber gas barbecue is portable so you can ea
Summary of the content on the page No. 14
14 GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after then rinse. cleaning. ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As Preserve Your Stainless Steel - Your grill or its cabinet, lid, control panel and shelves needed, remove from grill and wash with warm soapy water, then rinse with water. may be made from stainless steel.
Summary of the content on the page No. 15
GAS INSTRUCTIONS 15 TYPE OF GAS 15 Your natural gas grill is factory built to operate using natural gas only. Never attempt to operate your grill on gases other than the type specified on the grill rating plates. Your grill operates at 4.5” of water column pressure. If replacement of the hose becomes necessary, factory specified parts are required. See your local dealer. ® For safety and design reasons, the conversion of a Weber grill from operation using Natural gas to operation using LP gas
Summary of the content on the page No. 16
16 GAS INSTRUCTIONS 3) Remove the control panel. Tilt panel forward and lift up and away from grill. Completely remove the control panel (3) from the cooking box assembly exposing the valves, burners, igniter, and manifold. CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION The natural gas hose has been attached during the manuafacturing process. We do recommend that the hose to gas manifold connnection be leak tested, following guidelines in this Owner’s Guide, prior to barbecue operation. CHE
Summary of the content on the page No. 17
GAS INSTRUCTIONS 17 CHECK: 17 1) Bulkhead and gas supply hose connection. E/S-420 2) Bulkhead to regulator connection. 3) Regulator to hose connection. 4) Main gas line to manifold connections. WARNING: If there is a leak at connection (1, 2, 3, or 4), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your are
Summary of the content on the page No. 18
18 GAS INSTRUCTIONS CHECK: 1) Main gas line to manifold connection. E/S-450 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Bulkhead to regulator connection. 5) Regulator to hose connection. WARNING: If there is a leak at connection (1, 2, 3, 4, or 5), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn off the 2 gas. DO NOT OPERATE THE GRILL. Conta
Summary of the content on the page No. 19
OPERATING INSTRUCTIONS 19 GRILLING METHODS 19 Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the individual burners as desired. The control settings are START/HI, MEDIUM, LOW, or OFF. If burners go out during cooking, turn off all burners and wait 5 minutes before relighting. WARNING: Check the bottom tray and catch pan for grease build-up before each use. Remove excess grease to avoid a grease fire in the bottom tray. PREHEATIN
Summary of the content on the page No. 20
20 OPERATING INSTRUCTIONS • Trim excess fat from steaks, chops and roasts, leaving no more than a scant ¼ GRILLING TIPS & HELPFUL HINTS inch (6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; against unwanted flare-ups. heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). • Foods placed on the cooking grate directly above burners may require turning or • Sear
