Summary of the content on the page No. 1
GAS GRILL
LP Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - Pg 17
Guide de l’utilisateur du grill à gaz PL - Pg 30
E/SP - 320
#89838
#00000
YOU MUST READ THIS OWNER’S GUIDE WARNING: Follow all leak-check
BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
m
Summary of the content on the page No. 2
2 DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should be checked
Summary of the content on the page No. 3
WARRANTY - GARANTÍA - GARANTIE 3 ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber or failure to perform normal and routine maintenance, including but not limited to damage caused by gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: insects within the burner tubes, as set out in this owner’s manual. Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes
Summary of the content on the page No. 4
4 EXPLODED VIEW - DIAGRAMA DE DESPIECE - VISION ÉCLATÉE ® SPIRIT E/SP -320 ® 373XX01 - Spirit Gas Grill LP US 081507 1 2 33 3 34 35 4 36 5 37 6 38 7 8 39 40 9 41 42 43 44 10 45 11 46 12 47 13 14 48 15 49 16 50 51 17 52 18 53 19 54 55 20 41 56 21 57 22 23 58 24 25 59 26 60 27 28 61 62 29 63 30 64 31 65 32 66 ® WWW.WEBER.COM
Summary of the content on the page No. 5
5 EXPLODED LIST - LISTA DEL DIAGRAMA - LISTE DE LA VISION ÉCLATÉE 1. Hinge Pin 18. 1/4 - 20 x 2 1/4 inch Bolt 36. Thermometer Assembly 53. Fuel Gauge Hardware Pasador de bisagra Pernos de 2 1/4” Termómetro Elementos de Medidor del gas Axe d’articulation (Pernos de 1/4” x 20 x 2 1/4”) Thermomètre Boulonnerie de Jauge Boulons de 2 1/4 po de combustible 2. Left Endcap (1/4 x 20 x 2 1/4 po) 37. Handle Hardware Capacete izquierdo Elementos de Asa 54. Front Panel Hardware 19. Condime
Summary of the content on the page No. 6
6 GENERAL INSTRUCTIONS ® ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber WARNING: Your Weber gas barbecue is not intended to be gas barbecue you can grill, barbecue, roast and bake with results that are diffi cult to installed in or on recreational vehicles and/or boats. ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce WARNING: Do not use the barbecue within 24 inches of that “outdoor” fl avor in the food. ® The Web
Summary of the content on the page No. 7
7 GENERAL INSTRUCTIONS ® Stainless steel surfaces - Preserve Your Stainless Steel - Your grill or its cabinet, CAUTION: Do not clean your Flavorizer bars or cooking lid, control panel and shelves may be made from stainless steel. In order to keep the grates in a self-cleaning oven. stainless steel looking its best is easy. Simply clean it with soap and water, rinse with ® For availability of replacement cooking grates and Flavorizer bars Contact the clean water and wipe dry. A non-metalli
Summary of the content on the page No. 8
8 GAS INSTRUCTIONS Weber recommends the use of cylinder manufacturer’s Manchester and Worthington, with a 47.6 lb water capacity. Other cylinders may be acceptable for use with the appliance provided they are compatible with the appliance retention means (see illustrations). 1) Turn the LP cylinder so the opening of the valve is either to the front, side or rear of ® the Weber gas barbecue. Lift and hook the cylinder onto the fuel gauge. 2) Loosen the cylinder lock wing nut. Swing the cylin
Summary of the content on the page No. 9
9 GAS INSTRUCTIONS Check: 1) Side burner hose to side burner valve connection SPIRIT 2) Hose-to-manifold connection. 3) Side burner hose to manifold connection E/SP-320 WARNING: If there is a leak at connection (1), (2) or (3) retighten the fi tting with a wrench and recheck for leaks with soap and water solution.If a leak persists after retightening (3) the fi tting, turn OFF the gas. DO NOT OPERATE THE GRILL. (1) (2) Contact the Customer Service Representative in your area using the conta
Summary of the content on the page No. 10
10 GAS INSTRUCTIONS � The cylinder should be constructed and marked in accordance with the CAUTION: Place dust cap on cylinder valve outlet whenever Specifi cations for LP - Gas Cylinders of the U.S. Department of Transportation the cylinder is not in use. Only install the type of dust cap (D.O.T.) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres on the cylinder valve outlet that is provided with the cylinder and Tubes or Transportation of Dangerous Goods; and Commiss
Summary of the content on the page No. 11
11 OPERATING INSTRUCTIONS 3) Turn the cylinder on by slowly turning the cylinder valve counter-clockwise. MAIN BURNER LIGHTING WARNING: Do not lean over the open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue. SPIRIT 1 4) Push Front burner control knob down and turn to START/HI. E/SP-320 ® 5) Push the Crossover ignition button several times, so it clicks each time. 6) Check that the burner is lit by looking through the matchli
Summary of the content on the page No. 12
12 OPERATING INSTRUCTIONS LIGHTING THE SIDE BURNER SIDE BURNER LIGHTING DANGER SPIRIT Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner E/SP-320 does not light, may result in an explosive fl ame-up which can cause serious bodily injury or death. WARNING: Check hose before each use of barbecue for nicks, 2 cracking, abrasions or cuts. If the hose is found to be damaged ® in any way, do not use the barbecue. Repl
Summary of the content on the page No. 13
13 TROUBLESHOOTING PROBLEM CHECK CURE Burners burn with a yellow or orange fl ame, in Inspect Spider / Insect Screens for possible obstructions. Clean Spider / Insect Screens. (See Section “Annual conjunction with the smell of gas. (Blockage of holes.) Maintenance”) Symptoms: The excess fl ow safety device, which is part of the To reset the excess fl ow safety device turn all burner control Burners do not light. -or- Burners have a small barbecue to cylinder connection, may have activated. knobs
Summary of the content on the page No. 14
14 SIDE BURNER TROUBLESHOOTING PROBLEM CHECK CURE Side Burner burns with a yellow or Inspect side burner orifi ce alignment Loosen orifi ce and re-align orifi ce parallel to the side burner tube (3) . orange fl ame, in conjunction with the (Position of orifi ce to side burner tube.) (See Section “Side Burner Maintenance”) smell of gas. Side Burner does not light. Is gas supply off? Turn supply on. The excess fl ow safety device, which is part To reset the excess fl ow safety device turn all burner co
Summary of the content on the page No. 15
15 MAINTENANCE ® WEBER SPIDER /INSECT SCREENS (1) ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section (1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the combustion air opening. This could result in a fi re in and around the combustion air openings, under the control panel, causing serious damage to your barbecue. The burner tube combustion air openi
Summary of the content on the page No. 16
16 MAINTENANCE REPLACING MAIN BURNERS ® 1) Your Weber gas barbecue must be off and cool. (1) 2) Turn gas off at source. 3) To remove control panel: take off the burner control knobs. Remove the screws holding the control panel in place. Lift off the control panel. 4) Unhook the manifold bracket (1) and unscrew the two wing nuts (2) that hold the manifold to the cooking box. Pull the manifold and valve assembly out of the burners and carefully set it down. 5) Slide the burner assembly out fro
Summary of the content on the page No. 17
BARBACOA DE GAS Guía del Propietario de la Barbacoa o Asador de Gas Propano Licuado E/SP - 320 #89838 #00000 DEBE LEER ESTA GUÍA DEL PROPIETARIO ADVERTENCIA: Antes de poner a funcionar ANTES DE PONER A FUNCIONAR LA la barbacoa, siga cuidadosamente todos BARBACOA DE GAS los procedimientos en este manual para verifi car que no existan fugas. Haga esto aun y cuando la barbacoa haya sido PELIGRO ensamblada por el distribuidor. Si usted huele gas: 1. Cierre el suministro de gas al artefacto
Summary of the content on the page No. 18
18 PELIGROS Y ADVERTENCIAS PELIGRO El hacer caso omiso de los avisos de peligros, advertencias y precauciones contenidos en este Manual del Propietario pudiera resultar en lesiones corporales serias o la muerte, o en un fuego o explosión que cause daños a la propiedad. ADVERTENCIAS No almacene un tanque de propano licuado desconectado o de repuesto debajo o cerca de este asador. El ensamblaje incorrecto puede ser peligroso. Por favor siga cuidadosamente las instrucciones de ensamblaje
Summary of the content on the page No. 19
19 INSTRUCCIONES GENERALES ® ® La barbacoa de gas Weber es un aparato transportable para cocinar al aire libre. Con ADVERTENCIA: La barbacoa de gas Weber no ha sido ® la barbacoa de gas Weber usted puede asar a la parilla, a la barbacoa, al horno y diseñada para instalarse en o sobre vehículos y/o botes hornear con unos resultados que son difíciles de duplicar con los aparatos de cocina de ® recreativos. casa. La tapa cerrada y las barras Flavorizer le dan a los alimentos ese sabor a “air
Summary of the content on the page No. 20
20 INSTRUCCIONES GENERALES ® Flavorizer y parrillas de cocción - Límpielas con un cepillo de cerda de latón adec- Superfi cies de acero inoxidable - Preserve su acero inoxidable - La barbacoa uado. Según se requiera, retírelas del barbacoa o asador y lávelas con agua jabonosa o asador o el gabinete, tapa, panel de control y estantes de ésta pudieran estar tibia y luego enjuáguelas con agua. hechos de acero inoxidable. Es muy fácil mantener impecable al acero inoxidable. Simplemente lávelo con
