Summary of the content on the page No. 1
D
E
I
F
I
S
INSTALLATION AND OPERATING INSTRUCTIONS
COUNTER TOP ELECTRIC
OVENS
INTENDED FOR OTHER THAN HOUSEHOLD USE
Models: PX-14, PX-16, P-18, BK-18, P-22S, P-22BL,
P-24S, P-44S, P-44BL, P-46S, P-48S, DP-2
RETAIN THIS MANUAL FOR FUTURE REFERENCE
OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
WARNING
Improper insta
Summary of the content on the page No. 2
INDEX INSTALLATION INSTRUCTIONS SECTION ITEM PAGE 1 Location 3 2 Electrical Connections 3 3 Requirements for Installation 3 4 Initial Start Up 4 OPERATING INSTRUCTIONS SECTION ITEM PAGE 1 General Baking 5 2 General Baking Tips 5 3 Special Features 6 4 Cleaning 6 5 Service and Trouble Shooting 7 6 Installation of Decks 7 7 Wiring Diagrams 8-12 2
Summary of the content on the page No. 3
INSTALLATION INSTRUCTIONS Minimum Clearance for Installation From combustible or non-combustible construction: Right side, Left side and Back: 3” (76mm) !LOCATION Due to the heat a counter-top oven may produce, it must be placed on a non-combustible surface. Do not store combustible materials on top of any oven. !ELECTRICAL CONNECTIONS Suitable means, which will disconnect all ungrounded conductors of the circuit simultaneously, must be provided by the installer. Make sure electrical supply co
Summary of the content on the page No. 4
d. After the front legs are tight, lift rear of unit approximately 5” (125mm) off the surface and block in position using wood or some other solid material. Now mount the two rear legs and tighten. !Using the proper lifting equipment, move the unit to its final location. !Adjust the bottom portion of legs to make level. !Slide baking decks into each shelf. (View on Page 7) 4. INITIAL START UP After the electrical connections have been made, the oven will need approximately 2 to 3 hours to bur
Summary of the content on the page No. 5
OPERATING INSTRUCTIONS Note: Only Pizza or Bread can have direct contact with ceramic decks. All other food products must be placed in a pan or container to avoid direct contact with ceramic decks. !GENERAL BAKING Models: P-18, BK-18, P-22S, P-22BL, P-24S, P-44S, P-44BL, P-46S, P-48S, PX-14 and PX-16 Preheat the oven by setting the thermostat to the desired temperature. When the thermostat light goes out and has cycled three times, the oven is ready for use. These ovens have been designed to b
Summary of the content on the page No. 6
!Placing a screen under pizza will allow the top to cook without overcooking the bottom. !Frequently scrape and brush off decks to remove burned residue which can cause an off flavor to the product. Residue build-up can slow bake times. A deck scraper/brush specifically designed for this is available from BAKERS PRIDE. !Clean heavily soiled pizza decks by scraping down, brushing off, removing from oven, turning over and putting back. This procedure will burn off the decks and should be repeat
Summary of the content on the page No. 7
Stainless steel surfaces should be cleaned with BAKERS PRIDE STAINLESS STEEL CLEANER. !SERVICE AND TROUBLE SHOOTING The ovens are designed to be as trouble free as possible. Keeping the oven clean is all that is normally required. All servicing should be performed by a factory authorized technician only. However, if your oven stops operating, please check the following: !Power supply cord is plugged into the supply receptacle. !Power supply fuse/circuit breaker has not tripped. If the oven sti
Summary of the content on the page No. 8
REV. DESCRIPTION OF CHANGE DATE BY APP'D L1 L2 L1 L2 L3 . 200V 1 OR 3 . . TERMINAL TERMINAL . BLOCK BLOCK 208V 1 OR 3 1 PHASE 3 PHASE 3 PHASE - 3 WIRE I PHASE - 2 WIRE 240V 1 OR 3 AMPERE PLUG & NO. AMP - NO LIGHT AMP - W. LIGHT VOLT A/C MODEL UNIT COILS NO L.W. L. USA CAN L1 L3 L2 L2 L1 L3 LOWER HEATING COILS UPPER HEATING COILS 200 200 25.3 25.7 12.6 12.6 25.3 13.0 13.0 25.3 LT UT DP2 208 208 24.3 24.7 12.1 12.1 24.3 12.5 12.5 24.3 LC UC 6-30P 6-30P 240 230 22.0 22.3
Summary of the content on the page No. 9
BL34,45,45 REV. DESCRIPTION OF CHANGE DATE BY APP'D BR54 L1 N N L1 L2 L3 . . . TERMINAL TERMINAL . (230V 1) BLOCK BLOCK 1 PHASE 3 PHASE 400V 3N VOLT A/C AMPERE - NO LIGHT AMPERE - W. LIGHT MODEL N UNIT COILS L1 L2 L3 N L1 L2 L3 LOWER HEATING COILS UPPER HEATING COILS LT UT DP2 230 230 22.0 - - - - - - 22.0 22.3 - - - - - - 22.3 BL52 BL52 LC UC 230/400 230 9.3 0.0 12.6 3.3 9.7 0.0 12.6 2.9 BL52 BL52 LB UB P48S 230 230 18.7 - - - - - - 18.7 19.0 - - - - - - 19.0 UPPER LOWER
Summary of the content on the page No. 10
BL31,32,34 REV. DATE BY APP'D DESCRIPTION OF CHANGE BR54 L1 N N L1 L2 L3 TERMINAL TERMINAL BLOCK BLOCK 1 PHASE 3 PHASE HEATING COILS VOLT A/C AMPERE - NO LIGHT AMPERE - W. LIGHT TE MODEL UNIT COILS L1 L2 L3 N L1 L2 L3 N BL52 CE 230 - - - - - - - - - - - - BL52 BK18 230 7.4 7.4 7.6 7.6 BE 230/400 230 3.7 0.0 3.7 0.0 3.7 0.2 3.7 0.2 BL32 P18S 230 - - - - - - - - - - - - 230 12.4 12.4 12.7 12.7 230/400 230 3.7 4.3 4.3 0.6 3.7 4.7 4.3 1.0 BK28 P24S 230 230 9.3 - - - - - - 9.3 9.5 - - -
Summary of the content on the page No. 11
REV. DESCRIPTION OF CHANGE DATE BY APP'D L1 L2 L3 L1 L2 (N) 3 PHASE - 3 WIRE PLUG CONFIGURATION & NUMBER TERMINAL TERMINAL 1 PH - 2 W BLOCK BLOCK AMP - NO LIGHT AMP - W. LIGHT AMPERE USA CAN JAPAN UK EUROPE VOLT A/C 3 PHASE 1 PHASE MODEL COILS UNIT L1 L2 L3 L1 L2 L3 NO L.W. L. 100 100 17.0 17.4 N/A N/A 120 5-15P 5-20P 5-20P 120 14.2 14.5 BK18 200 200 8.5 0.0 8.5 8.7 0.2 8.5 8.5 8.7 HEATING COILS 8.2 8.4 208 208 8.2 0.0 8.2 8.4 0.2 8.2 TE CEE 7-VII 240 230 8.1 0.0 8.1 8.2 0.1 8.
Summary of the content on the page No. 12
APP'D REV. DESCRIPTION OF CHANGE DATE BY . . 200V 3 . 200V 1 . 208V 3 208V 1 240V 3 400V 3 N L1 240V 1 L2 L1 L2 L3 N L1 L2 L3 P P UT UT P TH UC UT UC TH TH TH UC UB UB TH TH TH UB TH TH L L L LS LS LS LS LS L L L M M M B B B T T T CB CB CB CB CB CB L L L LS LS LS LS LS L L L M M M B B B T T T P P P LT LT TH LT LC TH LC LC TH TH TH LB LB LB TH TH TH TH LEGEND HEATER COILS N, L1, L2, L3 = FROM TERMINAL BLOCK BAKERS PRIDE UT = UPPER CHA
