Summary of the content on the page No. 1
Freestanding cooker
Installation instructions
OR90SDBGFX models
and User guide
NZ AU
Summary of the content on the page No. 2
Summary of the content on the page No. 3
1 Contents Safety and warnings 2 Installation instructions 6 Using your seven-function oven for the first time 18 Setting the clock 19 Using your oven 20 Cooking functions 21 Using the rotisserie 23 Using the electronic timer 24 Automatic cooking 25 Using your gas cooktop 26 Care and cleaning 30 Troubleshooting 44 Warranty and service 45 Important! SAVE THESE INSTRUCTIONS The models shown in this User Guide may not be available in all markets and are subject to change
Summary of the content on the page No. 4
2 Safety and warnings Installation WARNING! Electrical Shock Hazard Always disconnect the cooker from the mains electricity supply before carrying out any maintenance operations or repairs. Failure to follow this advice may result in death or electrical shock. WARNING! Cut Hazard Take care - panel edges are sharp. Failure to use caution could result in injury or cuts. Important safety instructions General To avoid hazard, follow these instructions carefully before installing or using this
Summary of the content on the page No. 5
3 Safety and warnings Electrical This cooker is to be installed and connected to the electricity supply only by an authorised person. If the installation requires alterations to the domestic electrical system, call a qualified electrician. The electrician should also check that the electrical system is suitable for the electricity drawn by the cooker. The appliance must be connected to the mains electricity supply, checking that the voltage corresponds to the value given in the rating
Summary of the content on the page No. 6
4 Safety and warnings Operation Your freestanding cooker has been carefully designed to operate safely during normal cooking procedures. Please keep the following guidelines in mind when you are using it: WARNING! Explosion Hazard Do not store flammable materials such as gasoline near the cooktop. Do not store flammable material in the oven or storage compartment. Do not spray aerosols near the cooktop during use. Failure to follow this advice may result in death or serious injury. WARNI
Summary of the content on the page No. 7
5 Safety and warnings Important safety instructions Never leave the appliance unattended when in use. Boilover causes smoking and greasy spillovers that may ignite. Isolating switch: make sure this cooker is connected to a circuit which incorporates an isolating switch providing full disconnection from the power supply. Household appliances are not intended to be played with by children. Children, or persons with a disability which limits their ability to use the appliance, should hav
Summary of the content on the page No. 8
6 I Installa nstallation instruc tion instructions tions Dimensions and clearances Installation clearances and protection of combustible surfaces shall comply with the current local regulations eg. AS/NZS5601.1:2010 Gas Installations code. Installation shall comply with the dimensions in Fig. 1, bearing in mind the following requirements: Overhead Clearances In no case shall the clearance above the highest part of the cooker be less than 600 mm or, for an overhead exhaust fan, 750 mm. AII oth
Summary of the content on the page No. 9
7 Installation instructions Dotted line showing the position of the Locating the area for gas and electrical connection cooker when installed Area for gas connection 70.5 mm 70.5 mm Area for electrical connection Fig. 2 Area for gas and electrical connections (*) Depending on feet adjustment Fitting the adjustable feet Important! It is possible to install the cooker above a plinth without fitting the adjustable feet. In that case the cooker will stand directly above the plinth; make sur
Summary of the content on the page No. 10
8 I Installa nstallation instruc tion instructions tions Moving the cooker Important! To prevent damaging the adjustable feet, ensure the cooker is always lifted by two people. Do not lift the cooker by the door handles. DO NOT DRAG the cooker. Lift the feet clear of the floor. Fig. 6 Correctly lifting the cooker Fig. 7 Incorrectly moving the cooker Fig. 8 Incorrectly lifting the cooker C B Fixing the backguard Before installing the cooker, assemble the backguard “C” . A The backguard “C” c
Summary of the content on the page No. 11
65 mm 833 mm 898 mm (product width) 9 Installation instructions Fitting the anti-tilt bracket Important! To restrain the appliance and prevent it tipping accidentally, fit a bracket to its rear to fix it securely to the wall. Make sure you also fit the supplied lock pin to the anti-tilt bracket. If installing the cooker above a plinth (without fitting the adjustable feet), revise the installation dimensions accordingly considering that the feet have the following min 210 mm max 235 mm meas
Summary of the content on the page No. 12
10 Installation instructions Connecting the cooker to the gas supply The gas connection must be carried out by an authorised person according to the relevant standards. Before connecting the appliance to the gas main, mount the brass conical adaptor onto the gas inlet pipe, upon which the washer has been placed (see Fig.s 11-12 following). Conical adaptor and washer are supplied with the appliance (packed with conversion kit for use with Natural gas or LPG). This appliance is suitable
Summary of the content on the page No. 13
11 Installation instructions Gas connection for Gas connection for LPG NATURAL GAS Gas inlet pipe Gas inlet pipe Nipple Nipple Washer Washer Brass conical adaptor Brass conical adaptor Test (Thread tight: use (Thread tight: use point suitable seal) suitable seal) Test point adaptor Gas pressure regulator Test point Fig. 11 LPG connection Fig. 12 Natural gas connection Chain security hole Left gas Right gas inlet pipe inlet pipe Cap Fitting the cap on the Fitting the brass conical adaptor inle
Summary of the content on the page No. 14
12 Installation instructions Leak-testing and flame-testing the cooker After installing the freestanding cooker and connecting the gas supply: 1 Using a suitable leak detection fluid solution, check each gas connection one at a time by brushing the solution over the connection. The presence of bubbles will indicate a leak. If there is a leak, tighten the fitting and then recheck for leaks. Important! Do not use a naked flame to test for leaks. 2 A djust the test point pressure or supply pre
Summary of the content on the page No. 15
13 Installation instructions Injector Injector J Fig. 14 Semi-rapid burner Fig. 15 Triple-ring wok burner J J Injectors for Injector for Injectors for Injector for outer crown inner crown inner crown outer crown Fig. 16 Dual burner
Summary of the content on the page No. 16
14 Installation instructions Adjusting the minimum burner setting Check whether the flame spreads to all burner ports when the burner is lit with the gas valve set to the minimum position. If some ports do not light, increase the minimum gas rate setting. Check whether the burner remains lit even when the gas valve is turned quickly from the maximum to the minimum position. If the burner does not remain lit, increase the minimum gas rate setting. To adjust the minimum gas rate setting: Semi
Summary of the content on the page No. 17
15 Installation instructions Natural gas LPG Test Point Pressure [kPa] 1.0 2.75 Injector Gas Injector Gas Orifice Dia. Consumption Orifice Dia. Consumption BURNER [mm] [MJ/h] [mm] [MJ/h] Semi-rapid 1.17 6.50 0.70 6.30 Triple-ring wok 1.54 11.88 0.98 12.00 0.76 0.50 16.20 16.20 (inner crown) (inner crown) (inner and (inner and Dual outer crowns outer crowns 1.23 - no.2 0.73 - no.2 operating) operating) (outer crown) (outer crown)
Summary of the content on the page No. 18
16 Installation instructions Wiring diagram S2 S1 TM TMS F1 F2 PR 1a 1 2a 2 P1 1 1 3a 3 N/7 P2 2 1a 4a 4 L/8 5a 5 6a 6 7a 7 8a 8 9a 9 GIR 10a 10 11a 11 LF A PA LF C G CIR V S CF TL M T
Summary of the content on the page No. 19
17 Installation instructions Wiring diagram key F1 Oven function selector (switch) TM Oven thermostat TMS Safety thermostat TL Thermal overload (n.o.) S1 Oven temperature indicator light S2 Oven ON indicator light PR Oven programmer F2 Rotisserie selector (switch) GIR Rotisserie motor LF Oven lamps S Oven bottom heating element C Oven top heating element G Oven grill heating element CIR Oven fan (circular) heating element V Oven fan motor CF Cooling fan motor PA Ignition switches harness A Ign
Summary of the content on the page No. 20
18 Using your seven-function oven for the fi rst time 2 11 12 1 34 5 6 7 8 9 10 Fig. 19 Control panel 1 Control buttons 7 Central (dual) burner dial 2 Clock display 8 Rear right (semi-rapid) burner dial 3 Function dial 9 Front right (triple-ring) burner dial 4 Temperature dial 10 Rotisserie dial 5 Front left (triple-ring wok) burner dial 11 Function indicator light 6 Rear left (semi-rapid) burner dial 12 Temperature indicator light Before using your new oven, please: 1 Read this user guide, taki
