Summary of the content on the page No. 1
Owners Manual
table Of cOntents
Safety instructions pg. 2
Grounding Instructions pg. 3-4
Operating Your Vacuum pg. 4
Tips on the Care of Your Central Vacuum pg. 4-5
Maintenance
- Inverted Bag Units pg. 5
Troubleshooting Guide pg. 6-8
Serial Number Location pg. 8
Warranty pg. 9
Explosion pg. 10-11
IMpOrT aNT: CarEfULLY rEad aNd rET aIN ThIS BOOkLET .
Summary of the content on the page No. 2
ThIS appLIaNCE IS fOr rESIdENTIaL Or COMMErCIaL USE. IMPOrtant safet Y Instruct IOns When using an electrical appliance, basic precautions should always be followed, including the following: * rEad aLL INSTrUCTIONS before using this appliance. WarNING: To reduce the risk of fire, electric shock or injury: Always follow these safety instructions: 1. Do not leave room when hose is plugged in to the inlet. Disconnect power before servicing. 2. Electric shock could occur if used on wet
Summary of the content on the page No. 3
saVe tHese InstructIOns 25. For electric vacuum hose, connect to a properly wired 2-pole polarized outlet. 26. Electric vacuum hose, use only with the electric power brush for use with the c entral vacuum system. 27. The extension cord provided may only be used with the electric power brush for use with the central vacuum system. 28. dO NOT USE the electric vacuum hose or extension cord with any appliance other than the central vacuum electric power brush for which it is intended. CaU
Summary of the content on the page No. 4
GrOun DIn G Instruct IOns fOr PerManentl Y cOnnecte D a PPl Iance : This appliance must be connected to a grounded metal, permanent wiring system; or an equipment grounding conductor must be run with the circuit conductors and connected to the equipment grounding terminal or lead on the appliance. OpTIONaL EQUIpMENT: For Electric hose or vacuum hose used with extension cord. This appliance must be connected to a polarized (2-pole receptacle), permanent wiring system. OPerat In G YOur centr
Summary of the content on the page No. 5
www.airkinglimited.com Ma Intenance InVerteD baG sYsteMs: Inverted bag units provide a permanent filter and require occasional cleaning. To clean the inverted bag units, follow these steps: 1. Remove the dirt canister by supporting the bottom canister with your knee*. fIG. 1 Then, unsnap the two dirt canister latches by grasping the lower end of each latch and pulling straight away from the canister (see figure 1c). 2. Carefully lower the dirt canister , dump the contents into trash c
Summary of the content on the page No. 6
tr Oubles HOOtIn G GuIDe Please read the Warranty certificate before attempting any service on your power unit. The motor in your power unit d OES NOT require oiling. The bearings have been lubricated and sealed at the fac- tory. Tampering in any way with the motor blower will invalidate your warranty. Your central vacuum system has been engineered to provide many years of carefree service. Should your system for some reason fail to function properly, the following chart and instructions shou
Summary of the content on the page No. 7
customer service: 800.465.7300 3. Circuit Breaker in house panel - Check your house breaker panel - If the circuit breaker if off, you may have too many appliances utilizing that circuit. For best results, your power unit should be on a separate circuit. Try to remove some of the extra circuit load by unplugging other devices. If the breaker continues to cut off - call your service technician. 4. Internal Thermal Switch in Unit - If your unit comes equipped with an internal thermal swit
Summary of the content on the page No. 8
13. filter Bag - Clogged (some models) - Read the Operations section of this manual for information on how to remove and clean your filter bag. 14. dirt Canister Lid - Off - On those models with lift off dirt canister lids, (check the Operations section of this manual) the lid must be replaced squarely on top of the canister or it will allow a vacuum leak. 15. dirt Canister Gasket - Loose - If the dirt canister gasket has been pulled loose, it will allow a vacuum leak. The gasket may be re
Summary of the content on the page No. 9
a Ir KInG a MerIca l IMIteD warrant Y: WHAT THIS WARRANTY COVERS: This product is warranted against defects in workmanship and/or materials. HOW LONG THIS WARRANTY LASTS: This warranty extends only to the original purchaser of the product and lasts for one (1) year from the date of original purchase or until the original purchaser of the product sells or transfers the product, whichever first occurs. WHAT AIR KING WILL DO: During the warranty period, Air King will, at its sole option, repai
Summary of the content on the page No. 10
10
Summary of the content on the page No. 11
customer service: 800.465.7300 VS80 Build- Configura up tion VS80 ower p unit Build- Sheet up ITEM NO. PART NUMBER DESCRIPTION Default/QTY 1 57587 Main Canister Assembly 1 2 57598 5.7” CupStyle Motor Gasket 1 3 57609 High Air Watt Ultra 2-Stage 5.7” Flow-Thru Motor 1 4 57620 Motor Mount Bracket with Strap 1 5 57631 1/4” x 20 x3-1/4” Long Motor Bolt 3 7 57653 Strain Relief Plug 1 8 57664 10-24x 3/4” Phillips RoundHead 2
Summary of the content on the page No. 12
cOntact Location Information Corporate headquarters for United States division: 820 Lincoln avenue West Chester, pa 19380 ph. 800.465.7300 #f51067
