Summary of the content on the page No. 1
Assembly Guide
CW-119
Summary of the content on the page No. 2
Summary of the content on the page No. 3
CW-119 Assembly Guide Obtaining Service Important Safety Instructions For information about product operation or service, When using exercise equipment, basic precautions refer to the Precor web site at www.precor.com where should always be taken, including the following: you can also find customer support numbers or a list of • Read all instructions before assembling the Precor authorized service centers. CW-119. These instructions are written for your If you contact Customer Support, have the
Summary of the content on the page No. 4
CW-119 Assembly Guide Table of Contents Important Safety Instructions .................................................................................. 3 Obtaining Service ..................................................................................................................................... 3 Preparations............................................................................................................... 5 Unpacking the Equipment..........................................
Summary of the content on the page No. 5
CW-119 Assembly Guide Required Tools Tools that you need to obtain before assembling the unit include: ❏ Wire cutter or utility knife ❏ SAE hex key set 1 Preparations Installation Requirements The CW-119 parts are inspected before shipment. Each unit contains several pieces that require Follow these installation requirements when assembly. You must obtain adult assistance during the assembling the unit: assembly process. • Review the Important Safety Instructions. • Assemble the unit where it wi
Summary of the content on the page No. 6
CW-119 Assembly Guide Hardware Kit Fastener Qty ³⁄₈-inch x ¾-inch buttonhead screw (A) 4 ³⁄₈-inch split washer (B) 4 ⁵⁄₁₆-inch x 1¼-inch buttonhead screw (C) 7 ⁵⁄₁₆-inch split washer (D) 7 ⁵⁄₁₆-inch washer (E) 7 Preparations, continued page 6
Summary of the content on the page No. 7
CW-119 Assembly Guide Assembly 2 Instructions Assembly of the CW-119 takes about 45 minutes to complete. If this is the first time you have assembled this type of equipment, plan on allowing more time. Be careful to open boxes and assemble components in the sequence presented in this manual. Note: With so many assembled parts, proper alignment Back Pad and adjustment is critical. While tightening the fasteners, be sure to leave room for adjustments. Do not fully Seat Pad tighten fasteners until
Summary of the content on the page No. 8
CW-119 Assembly Guide Assemble the Unit Attach the Main Frame to the Stabilizer using four ³⁄₈-inch X ¾-inch buttonhead screws (A) four ³⁄₈-inch split washers (B) Wrench tighten. Note: Make sure the wheels on the Stabilizer are positioned as shown in the illustration. 4 - ¾" buttonhead screws 4 - split washers Assemble the Unit page 8
Summary of the content on the page No. 9
CW-119 Assembly Guide Assemble the Pads 1. Attach the Seat Pad to the Seat Adjustment using three 1¼-inch buttonhead screws (C) three ⁵⁄₁₆-inch split washers (D) three ⁵⁄₁₆-inch washers (E) Wrench tighten. 2. Attach the Back Pad to the Back Adjustment using four 1¼-inch buttonhead screws (C) four ⁵⁄₁₆-inch split washers (D) four ⁵⁄₁₆-inch washers (E) Wrench tighten. This completes the assembly of the CW-119. 3 - 1¼" buttonhead screws 3 - split washers 3 - washers 4 - 1¼" buttonhead screws 4 - sp
Summary of the content on the page No. 10
CW-119 Assembly Guide Clean the Pads and Assembly To clean the pads, moisten a clean, soft cloth in a mild solution of soap and water and wipe all the parts thoroughly. Dry the pad with a clean, dry cloth. Use the same procedure to clean the Main Frame and plastic parts. Frequently vacuum the floor underneath the CW-119 to prevent the accumulation of dust and dirt. If necessary, use the Seat Pad to lift the front end and tip the CW-119 onto its wheels to roll it to a different location. Clean th
Summary of the content on the page No. 11
Limited Warranty Precor, Incorporated (PRECOR) will repair or replace any of the following components which An individual purchasing PRECOR equipment in California for personal, family or household are defective as to materials or workmanship for products manufactured and sold after June 1, purposes has the right to have defective equipment serviced or repaired during the warranty 1990: period. The warranty period will be extended for the number of whole days that the equipment is out of the buy
Summary of the content on the page No. 12
CW-119 Assembly Guide Notes: page 12
Summary of the content on the page No. 13
Summary of the content on the page No. 14
CW-119 Specifications Length: 48 inches (122 cm) Height: 39 inches (99 cm) Width: 30 inches (76 cm) Shipping weight: 84 lb (38 kg) Precor Incorporated 20031 142nd Avenue NE P.O. Box 7202 Woodinville, WA USA 98072-4002 1-800-347-4404 Precor, Icarian, and Move Beyond are registered trademarks of Precor Incorporated. Copyright 2008 Precor Incorporated. Specifications subject to change without notice. www.precor.com NOTICE: Precor is widely recognized for its innovative, award winning designs of exe
