Summary of the content on the page No. 1
Product Guide
Model 4651330
IMPORTANT: Fill out the product record information below.
Serial Number
See rating label on grill for serial number.
Date Purchased
For support and to register your
grill, please visit us at
www.charbroil.com
If you have questions or need
assistance during assembly,
please call 1-800-241-7548.
Estimated assembly time: 35-40 minutes
The following are trademarks registered by W.C. Bradley Co. in the U.S. Patent and Trademark Office: Char-Broil®; America's Legendary Barb
Summary of the content on the page No. 2
TABLE OF CONTENTS DANGER Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 If you smell gas: For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 1. Shut off gas to the appliance. Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3 2. Extinguish any open flame. 3. Open lid. Food Safety . . . . . .
Summary of the content on the page No. 3
WARNING WARNING CALIFORNIA PROPOSITION 65 Do not attempt to repair or alter the regulator/valve 1. Combustion by-products produced when using for any “assumed” defect. Any modification to this this product contain chemicals known to the State of assembly will void your warranty and create the risk California to cause cancer, birth defects, and other of a gas leak and fire. Use only authorized reproductive harm. replacement parts supplied by manufacturer. 2. This product contains chemicals, inclu
Summary of the content on the page No. 4
USE AND CARE Propane Gas Cylinders Regulator/Valve Cylinder Leak Test (Cont’d.) - Your grill is designed to operate with one 16.4 oz. disposable If you cannot stop a leak, remove cylinder from regulator and check for damaged threads, dirt and debris on regulator and cylinder (Dot 39 Cylinder) that is 7 3/8” high (not included). Do not attempt to refill any 16.4 oz. disposable fuel cylinder. If threads are damaged on either regulator or cylinder, replace. Check to see if anything is obstructing t
Summary of the content on the page No. 5
Safety Tips 1. Before opening LP cylinder valve, check the coupling nut for WARNING tightness. 2. When grill is not in use, turn off all control knobs and LP cylinder valve. For Safe Use of Your Grill and to Avoid Serious Injury: 3. Never move grill while in operation or still hot. 4. Use long-handled barbecue utensils and oven mitts to avoid Do not let children operate or play near grill. burns and splatters. 5. Clean grill often, preferably after each cookout. If a bristle Keep grill
Summary of the content on the page No. 6
Grill Maintenance CAUTION - Allow grill to cool before cleaning. Frequency of cleaning is determined by how often grill is used. SPIDER ALERT! - DO NOT use self-cleaning oven to clean any grill part. Extreme heat would remove any chrome plating and cause premature rusting. - Meat drippings will solidify in bottom of grill after a few uses. This residue should be removed regularly. Failure to do so could cause overflow at bottom vent openings and increase the chance of a grease fire. - When cle
Summary of the content on the page No. 7
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of manufacture*. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid by the consumer for revi
Summary of the content on the page No. 8
Parts List Key Qty Description Part # A 1 Lid Handle . . . . . . . . . . . . . . . . . . . . . G102-0001-9031 B 1 Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . G102-0002-0031 C 2 Hinge Brackets . . . . . . . .. . . . . . . . . . G102-0003-0031 D 1 Cooking Grate . . . . . . . . . . . . . . . . . . G102-0004-9181 E 1 Heat Distribution Plate . . . . . . . . . . . G102-0005-0000 F 1 Burner . . . . . . . . . . . . . . . . . . . . . . . . G102-0100-0000 G 1 Heat Resistant Shield . . . . .
Summary of the content on the page No. 9
Assembly 1 BURNER (F) - Position Heat Shield (G) as shown at right below and place into Bottom (H). HEAT RESISTANT SHIELD (G) - Insert narrow end of Burner (F) through large hole in side of Bottom (H) and rest burner bracket on Shield (G). - Insert one 1/4-20 x 3/8” Screw (M) through Bottom (H), Shield (G) and into burner bracket. BOTTOM (H) CAUTION Some parts may contain sharp edges! Wear protective gloves if necessary. 1/4-20 x 3/8” SCREW (M) 2 - Position Legs (K) as shown at right. - Spread
Summary of the content on the page No. 10
Assembly (Con’t.) 3 #10-24 x 3/4” SCREW (O) HEAT DISTRIBUTION PLATE (E) - Assemble Side Handles (I) to Bottom (H) using two each #10-24 x 3/4” Screws (O), Fiber Washers (L) and #10-24 Flange Nuts (N) SIDE HANDLE (I) per Handle (I). - Rest the notches on ends of Heat Distribution Plate (E) on Side Handles Screws (O) inside Bottom (H). PLEASE NOTE: This table top propane gas grill has been designed to work effectively without the use of lava rocks. The reflective heat FIBER WASHER (L) distributio
Summary of the content on the page No. 11
Assembly (Con’t.) 5 - Before assembly, inspect Regulator (J) for damage, dirt or debris accumulation. Clean out if present. - With knob pointing down, insert Regulator/Valve (J) into end of Burner (F). Notch in Regulator/Valve (J) MUST engage dimple in end of Rotate clockwise to lock Burner (F). - Once Regulator/Valve (J) has completely engaged Burner (F), turn Regulator/Valve (J) clockwise to lock in position with knob pointing up. Regulator/Valve (J) Regulator/Valve (J) Locked in position 6
Summary of the content on the page No. 12
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Troubleshooting Prevention/Solution is turned on. Problem Possible Cause • Replace Cylinder. Burner will not Light. • Out of Propane • Retighten cylinder. • Regulator not fully tightened to cylinder. • Inspect burner for obstructions. • See ‘Care and Use’ for burner cleaning instructions. • See ‘Care and Use’ section “Before Cooking For The First Time’. Flames burns out on • Grill not suf
Summary of the content on the page No. 13
13
Summary of the content on the page No. 14
14
Summary of the content on the page No. 15
NOTES 15
Summary of the content on the page No. 16
Char-Broil© , LLC P.O. Box 1240 Columbus, GA31902–1240 Printed in China
