Summary of the content on the page No. 1
®
SunLite LTC
Small Underwater Pool Lights
O W N E R’ S M A N U A L
INSTALLATION, OPERATION & PARTS
3051 0997 ASB
This manual should be furnished to
the end user of this light; its use will
reduce service calls and chance of
injury and will lengthen light life.
Pentair Water Pool and Spa, Inc.
1620 Hawkins Ave., Sanford, NC 27330 • (800) 831-7133 or (919) 566-8000
10951 West Los Angeles Ave., Moorpark, CA 93021 • (800) 831-7133 or (805) 553-5000
Visit us on the Internet at: www.pentairpool.com o
Summary of the content on the page No. 2
Attention Installer: This manual contains important information about the installation, operation and safe use of this product. This information should be given to the owner and/or operator of this equipment after installation. WARNING — Before installing this product, read and follow all warning notices and instructions which are included. Failure to follow safety warnings and instructions can result in severe injury, death, or property damage. Call (800) 831-7133 for additional free copies o
Summary of the content on the page No. 3
READ AND FOLLOW Burn hazard. Never operate this light fix- SAFETY INSTRUCTIONS! ture for more than 10 seconds unless it is completely submerged in water. This fixture requires total submer- This is the safety alert symbol. When you see this sion for cooling. symbol in this manual, look for one of the follow- ing signal words and be alert to the potential for personal Breakage hazard. Install fixture in a vertical injury. pool or spa wall – not in floor. Failure to install the fix- ture properly
Summary of the content on the page No. 4
SPECIFICATIONS ® Table I SunLite LTC Small Underwater Pool Lights with Stainless Steel Face Ring Allowance of Watts/Sq. Foot Type of Pool of Pool Area Model No. Cord Length in Feet (m) Small Residential Pools 12V - 75 Watts (Less than 800 sq. ft.) 1/2 to 1* 05603-2030 30 (9.1) 1 Large Public Pools 1 to 1 ⁄2 05603-2050 50 (15.2) Diving Pools 1 05603-2100 100 (30.5) (Less than 12 ft. deep) 1 ⁄2 to 2 Diving Pools 120V - 100 Watts (12 to 20 ft. deep) 2 to 3 05605-2030 30 (9.1) Competition Pools 2 to
Summary of the content on the page No. 5
3. Make connections in the conduit box (be sure to fol- INSTALLATION low code requirements!). Connect the supply circuit ® grounding wire (green, green and yellow, or bare SunLite LTC Lamp Housing Installation copper) to the green ground conductor from the light (Refer to Figure 1, below) fixture. Connect the line supply wire (the black or ’hot’ wire) to the black wire from the light fixture. Burn hazard. This light should never be Connect the neutral (white) supply wire to the neutral energize
Summary of the content on the page No. 6
6. To close the fixture, make sure the clamp ring is open Lamp Installation Instructions (Re-lamping) to about 4 inches and that the nut is at the end of the See Figure 2, Page 7, for Key numbers. leader screw. 1. Be sure that the power is off. Allow the lamp to cool 7. Lay the face ring face down on a flat surface. before relamping. Carefully align the clear lens (Key No. 4) and lens 2. Remove the leader screw (Key No. 1) from the face gasket (Key No. 5) over the flanged hole in the face ring a
Summary of the content on the page No. 7
7 6 5 4 3 2 Note gasket orientation. 4405 0903 1 ® Figure 2 – SunLite LTC Lamp Exploded View ® REPAIR PARTS LIST – SUNLITE LTC LAMPS 3051 0997 Key 05603 Series 05605 Series 05607 Series No. Part Description Qty. 12V, 75W 120V, 100W 120V, 250W 1 Leader Screw* 1 - - - 2 Face Ring, SS, Assy Kit 1 05601-0001 05601-0001 05601-0001 3 Rubber Retainer for Leader Screw* 1 05601-0005 05601-0005 05601-0005 4 Clear Lens, Kit 1 34620-0002 34620-0002 34620-0002 5 Gasket, Lens 1 05601-0014 05601-0014 05601-001
Summary of the content on the page No. 8
© 2007 Pentair Water Pool and Spa, Inc. All rights reserved. 1620 Hawkins Ave., Sanford, NC 27330 • (800) 831-7133 or (919) 566-8000 10951 W. Los Angeles Ave., Moorpark, CA 93021 • (800) 831-7133 or (805) 553-5000 This document is subject to change without notice. S715 (Rev. A 10/29/07) 8
