Summary of the content on the page No. 1
INSTASTART™ Electronic Ignition
Propane Deep Fryer
Instructions for use
© 2007 The Coleman Company, Inc.
®
www.coleman.com
ANSI Z21.58-2007/CSA 1.6-2007
Outdoor Cooking Gas Appliances
9994 Series
This unit is an accessory for Coleman® Propane Grill
Models 9993 and 9998. Additional distances to
combustibles listed in this manual take precedence
over statements in the grill manuals. Also read the
additional instructions and warnings that are provided
in the manual that came with your Coleman® Gril
Summary of the content on the page No. 2
DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death. DANGER 1. Never operate this appliance unattended. 2. Never operate this appliance within 10 feet (3.05 m) of any structure, combustible material or ot
Summary of the content on the page No. 3
Only persons who can understand and follow DANGER the instructions should use or service this DANGER indicates an imminently hazardous outdoor fryer. situation which, if not avoided, will result in death or serious injury. If you need assistance or outdoor fryer information such as an instruction manual or labels, contact The Coleman Company, Inc. WARNING WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. DANGER CAUTION CAUTION ind
Summary of the content on the page No. 4
DANGER DANGER � EXPLOSION - FIRE HAZARD � CARBON MONOXIDE HAZARD � Never store propane near high heat, open � This fryer is a combustion appliance. All com- flames, pilot lights, direct sunlight, other igni- bustion appliances produce carbon monoxide tion sources or where temperatures exceed (CO) during the combustion process. This 120 degrees F (49°C). product is designed to produce extremely � Propane gas is heavier than air and leaking minute, non-hazardous amounts of CO if used propane will
Summary of the content on the page No. 5
WARNING CAUTION � SERVICE SAFETY � Keep all connections and fittings clean. Inspect propane cylinder and fryer propane � BURN HAZARD connections for damage before attaching. � Never leave fryer unattended when hot or � During set up, check all connections and in use. fittings for leaks using soapy water. Never use � Keep out of reach of children. a flame. Bubbles indicate a leak. Check that � Introduction of water or ice from any source the connection is not cross-threaded and that into the oil/
Summary of the content on the page No. 6
Fryer Assembly 3. Engage the locks by firmly pushing the tabs Attach the Fryer to the into the slots (Fig. 4). Be sure to engage two left side of the Grill locks on the side fryer. NOTE: This Side Solution™ Fryer attachment is designed for use only when properly attached to Coleman® grill models 9993 and 9998. Attach to the left side of the grill only. Attempted use or setup in a manner not described in this manual is prohibited and will void the warranty. ■ Remove the components from the carton
Summary of the content on the page No. 7
2. Place the oil reservoir in the Side Fryer. Locate the thermometer bracket on the right Fryer Assembly (cont.) side (Fig. 10). 6. Push the fuel hose connection through the Thermometer Bracket opening in the side grill panel (Fig. 7). Fig. 10 3. Fill the oil reservoir with 2.67 qts (2.53 liters) Fig. 7 maximum of cooking oil, indicated by the marks on the oil reservoir (Fig. 11). 7. Open the door to reveal the Quick Coupler in the upper corner. Retract the Collar on the Quick Coupler before att
Summary of the content on the page No. 8
CAUTION Setup (cont.) Inspect the gas supply hose before each use. Look underneath the grill to inspect 5. Place the basket in the fryer (Fig. 13). This the hose assembly below the grill. If illustration shows the basket in the upper there are cuts, damage, excessive position for draining the food after frying. abrasion or wear, replace the hose prior to operating the appliance. During assembly of the grill and when attaching or replacing the L.P. gas cylinder, insure that the gas supply hose is
Summary of the content on the page No. 9
I IN NS ST TA AS ST TA AR RT T™ ™ E El le ec ct tr ro on ni ic c Operation I Ig gn ni it ti io on n F Fr ry ye er r: : 1. Open the lid. DANGER 2. Make sure all valves are OFF. 3. Turn on the cylinder valve. 4. Push in and turn on the Fryer Control Knob counterclockwise to HIGH. (Fig. 17). 5. Continue to depress and hold the Fryer � CARBON MONOXIDE HAZARD Control Knob. � For outdoor use only. 6. Repeatedly press the igniter switch until � Never use inside house, camper, tent, vehicle the flame
Summary of the content on the page No. 10
8. Adjust flame with the control knob (Fig. 21). Fryer Burner Lighting (cont.) 12. Adjust flame with the control knob (Fig. 19). Fig. 21 ■ A good flame should be blue with minimal yellow tip. Some yellow tips on flames are acceptable as long as no carbon or soot deposits appear (Fig. 22). Fig. 19 GOOD BAD M Ma at tc ch h L Li ig gh ht ti in ng g: : Blue CAUTION Yellow Use a LONG wooden match or a butane lighter with an extension. Make sure all Blue Yellow burner controls are off except for the
Summary of the content on the page No. 11
Cooking Tips In Case of Grease Fire CAUTION Follow These Steps: � Open Lid during lighting and cooking. 1. Shut off the gas at the burner valve(s) and � Hot Steam is produced during cooking. Do stay away! not close the lid because it would force steam 2. Allow the fire to burn itself out. out the fryer near the handle. Keep your face 3. Once the fire is out and the appliance has and hands away from the escaping hot steam. cooled, shut off the L.P. cylinder valve. � Hot Oil will tend to splatter
Summary of the content on the page No. 12
Cleaning the Burner: Care, Maintenance and Cleaning WARNING Spider’s nests or wasp’s mud inside the burner tube may cause fire at the valve. If a CAUTION fire occurs, immediately turn off the gas supply at the L.P. cylinder valve (see All cleaning and maintenance should be representative illustration in Fig. 25). done only when the fryer and grill are cool and with the fuel supply turned off at the cylinder. Suggested Cleaning Materials: � Mild dishwashing liquid detergent � Hot water � Wire bru
Summary of the content on the page No. 13
Parts List No. Part Number Description No. Part Number Description 5 9994-1521 Grease Tray 1 9994-5571 Lid Assembly 6 9994-4401 Electrode/Wire Asm. 2 9994-5111 Basket Assembly 7 please call Igniter Assembly 3 9994-5451 Reservoir Assembly 8 9986-5181 Knob Assembly 4 9994-5371 Thermometer 1 2 3 8 4 7 6 5 English-12
Summary of the content on the page No. 14
Warranty How to Obtain Warranty Service Limited One Year Warranty Take the product to an authorized Coleman The Coleman Company, Inc. (“Coleman”) service center.You can find the nearest warrants that for a period of one year from the authorized Coleman service center by visiting date of original retail purchase, this product will www.coleman.com or calling 1-800-835-3278 or be free from defects in material and TDD 316-832-8707 in the United States or 1 800 workmanship. Coleman, at its option, w
Summary of the content on the page No. 15
Troubleshooting Problem: Fryer burner does not stay lit. Possible Causes and Solutions: 1. Automatic Valve was not pushed in and held during start-up. Problem: Fryer burner shuts off. Possible Causes and Solutions: 1. Over-temperature system detected that the unit became too hot (over 475 deg. F). Allow unit to cool down and use at safe temperatures. Notes: English-14
Summary of the content on the page No. 16
The Coleman Company, Inc. • 3600 North Hydraulic � Wichita, KS 67219 U.S.A. 1-800-835-3278 � TDD: 316-832-8707 © 2007 The Coleman Company, Inc. All rights reserved. Coleman® and are registered trademarks and INSTASTART™ is a trademark of The Coleman Company, Inc. www.coleman.com 4010001332 (20070615)
