Summary of the content on the page No. 1
Nokia Customer Care
Service Manual
RM-233 (Nokia 8800Arte; L1&2)
Mobile Terminal
Part No: (Issue 1)
COMPANY CONFIDENTIAL
Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 2
RM-233 Amendment Record Sheet Amendment Record Sheet Status Version Date Comments Draft 0.1 9.11.2007 Initial draft Approved 1.0 14.11.2007 Approval The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g. Service Bulletins) for service suppli
Summary of the content on the page No. 3
RM-233 Copyright Copyright Copyright © 2007 Nokia. All rights reserved. Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited. Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their respective owners. Nokia operates a policy of continuous
Summary of the content on the page No. 4
RM-233 Warnings and cautions Warnings and cautions Warnings • IF THE DEVICE CAN BE INSTALLED IN A VEHICLE, CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/ MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY. • THE PRODUCT MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN P
Summary of the content on the page No. 5
RM-233 ESD protection ESD protection Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use. To replace the covers ESD protection must be applied. All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity
Summary of the content on the page No. 6
RM-233 Care and maintenance Care and maintenance This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years. • Keep the phone and all its parts and accessories out of the reach of small children. • Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits. • Do not use or store
Summary of the content on the page No. 7
RM-233 Battery information Battery information Note: A new battery's full performance is achieved only after two or three complete charge and discharge cycles! The battery can be charged and discharged hundreds of times but it will eventually wear out. When the operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery. Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufact
Summary of the content on the page No. 8
RM-233 Battery information (This page left intentionally blank.) Page viii COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 9
RM-233 Nokia 8800Arte; L1&2 Service Manual Structure Nokia 8800Arte; L1&2 Service Manual Structure 1 General information 2 Service Devices and SW Update 3 Disassembly and Assembly Instructions Issue 1 COMPANY CONFIDENTIAL Page ix Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 10
RM-233 Nokia 8800Arte; L1&2 Service Manual Structure (This page left intentionally blank.) Page x COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 11
Nokia Customer Care 1 — General information Issue 1 COMPANY CONFIDENTIAL Page 1 –1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 12
RM-233 General information (This page left intentionally blank.) Page 1 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 13
RM-233 General information Table of Contents Nokia 8800 Arte, RM-233 .......................................................................................................................................1–5 RM-233 Exploded view...........................................................................................................................................1–6 RM-233 Level 2 solder components.................................................................................................
Summary of the content on the page No. 14
RM-233 General information (This page left intentionally blank.) Page 1 –4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 15
RM-233 General information Nokia 8800 Arte, RM-233 Figure 1 RM-233 (Nokia 8800Arte) product picture Table 1 Transceiver features Band GSM: quad band EGSM: EGSM/900/1800/1900 WCDMA: WCDMA2100 Display OLED: QVGA 2” 240x320 pixel, 16M true colour display Camera Camera: 3.2-megapixel auto focus camera with 8x digital zoom Operating System Series 40 Connections Wireless: Bluetooth Connector: Micro USB Memory 1 GB internal Table 2 Transceiver with BL-4U Li-ion battery pack Talk time Standby time Note
Summary of the content on the page No. 16
RM-233 General information RM-233 Exploded view See corresponding ITEM/CIRCUIT REF in the Spare Parts Service Bulletins on NOL Page 1 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 17
RM-233 General information RM-233 Level 2 solder components Issue 1 COMPANY CONFIDENTIAL Page 1 –7 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 18
RM-233 General information RM-233 PCI overview Page 1 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 19
Nokia Customer Care 2 — Service Devices and SW Update Issue 1 COMPANY CONFIDENTIAL Page 2 –1 Copyright © 2007 Nokia. All rights reserved.
Summary of the content on the page No. 20
RM-233 Service Devices and SW Update (This page left intentionally blank.) Page 2 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2007 Nokia. All rights reserved.
