Summary of the content on the page No. 1
ISSUED: OCT. 11, 2005
REVISED: JAN. 1, 2007
HOSHIZAKI
REFRIGERATED GLASS
MERCHANDISER
MODEL KD-90D
INSTRUCTION MANUAL
Summary of the content on the page No. 2
I M P O R T A N T 1. This booklet is an integral and essential part of the product and should be handed over to the user. Read the warnings contained in this booklet carefully as they give important indications regarding the safety of the installation, use and maintenance. Please preserve this booklet for any further consultation that may be necessary. 2. This is a refrigerated glass merchandiser and should be destined only to the use for which it has been expressly conceived. Any other use s
Summary of the content on the page No. 3
I. GENERAL INFORMATION 1. CONSTRUCTION Angle Fastener Glass Shelf Front Glass Left Side Glass Right Side Glass Fluorescent Lamp Evaporator Air Filter Drip Pan Sheet Bracket Thermometer Drain Hose Rear Cover Fluorescent Lamp Switch Ground Fault Circuit Interrupter (GFCI) Thermostat Pilaster Sliding Door Power Cord 3-Prong Plug 1
Summary of the content on the page No. 4
2. FOR SAFETY AND BEST OPERATING RESULTS IMPORTANT Hoshizaki refrigerated glass merchandiser is not designed as a refrigerator. Use this merchandiser only as a display case. The following are recommendations for proper use. * Select a proper installation site (see “II. INSTALLATION AND OPERATING INSTRUCTIONS”). * Do not store foods in the merchandiser for a long period. * Pre-cooling is required for canned or warm foods. * Do not store raw foods when ambient temperature is above 79°F (26°C) to
Summary of the content on the page No. 5
II. INSTALLATION AND OPERATING INSTRUCTIONS 1. UNPACKING WARNING This merchandiser contains fragile glass parts. Handle with care. Visually inspect the exterior of the shipping container and the merchandiser. Any severe damage noted should be reported to the carrier. * Unpack the merchandiser carefully. * Carry the merchandiser by holding its bottom. * Remove shipping tapes on the Sliding Doors. * Remove shipping tapes, and take out the package of Glass Shelves and accessories. * Attach the S
Summary of the content on the page No. 6
* Allow at least 6” (15 cm) clearance around the merchandiser for proper air circulation and ease of maintenance and/or service should they be required. 2) Level the merchandiser in both the left-to-right and front-to-rear directions. Metal shims should be added under the feet to level the system. 3. ELECTRICAL CONNECTIONS WARNING This refrigerated merchandiser requires a ground that meets the national and local electrical code requirements. To prevent possible severe electrical shock to indiv
Summary of the content on the page No. 7
5. FINAL CHECK LIST 1) Is the merchandiser level? 2) Is the merchandiser in a site where the ambient temperature is within 50°F (10°C) to 86°F (30°C) all year around? 3) Is there at least 6” (15 cm) clearance around the merchandiser? 4) Have all shipping carton, tape(s) and packing been removed from the merchandiser? 5) Have all electrical connections been made? 6) Has the Drain Tank been installed on the bottom of the merchandiser? 7) Has the power supply voltage been tested or checked against
Summary of the content on the page No. 8
2) Always start storing foods only after the inside temperature has been pulled down. 3) Move the Rocker ON-OFF Switch, located next to the GFCI, to the “ON” position to turn on the Fluorescent Light, if desired. [b] TEMPERATURE CONTROL Turn the Dial on the Temperature Control Thermostat, if necessary. To prevent freeze-up, do not turn the Dial up to more than 5. The Thermostat is factory-adjusted so that the inside temperature will be around 50°F (10°C) when the ambient temperature is 77°F (2
Summary of the content on the page No. 9
III. MAINTENANCE AND CLEANING INSTRUCTIONS IMPORTANT 1. This refrigerated merchandiser must be maintained individually, referring to the Instruction Manual. 2. Before carrying out any cleaning or maintenance operations, unplug the merchandiser. 3. This merchandiser is made of fragile glass. Handle with care. 4. To prevent injury to individuals and damage to the equipment, do not use ammonia type cleaners. 5. Do not use a water jet to clean the merchandiser. 1. INTERIOR/EXTERIOR Wipe off both in
Summary of the content on the page No. 10
the location. Use warm water and a neutral cleaner especially to remove oily dirt. Rinse and dry the Air Filter thoroughly, and place it in position. 8
Summary of the content on the page No. 11
Summary of the content on the page No. 12
HOSHIZAKI AMERICA, INC. 618 HIGHWAY 74 SOUTH PEACHTREE CITY, GA 30269 U.S.A. PHONE: 770-487-2331 www.hoshizakiamerica.com HOSHIZAKI ELECTRIC CO., LTD. 3-16 MINAMIYAKATA, SAKAE, TOYOAKE, AICHI 470-1194 JAPAN PHONE: 0562-97-2111 9 1 7 4 G E 1 0 B
