Streszczenie treści zawartej na stronie nr. 1
Owner's Manual
i T
®
Liquid Propane Gas Grill
Model141.16681
Natural Gas Grill
Model141.17681
A WARNING: Note to Installer: Leave this Owner's Manual
with the consumer after delivery and/or installation.
Read this Owner's Manual carefully and be sure
your gas grill is properly assembled, installed and
Note to Consumer: Leave this Owner's Manual
maintained. Failure to follow these instructions
in a convenient place for future reference.
could result in serious bodily injury and/or property
damage
Streszczenie treści zawartej na stronie nr. 2
Z_WARNING Warranty ..................................................... 2 Combustion byproducts produced when using Safety Instructions ...................................... 2 this product contain chemicals known to the State of California to cause cancer, birth Hardware .................................................... 6 defects, or other reproductive harm. Parts Diagram and Lists ........................ 7 Z_WARNING Assembly Instructions .............................. 10 Failure to comply
Streszczenie treści zawartej na stronie nr. 3
Correct LP Gas Tank Use • LP gas tanks must be stored outdoors in a LP gas grill models are designed for use with a well-ventilated area and out of the reach of standard 20 lb. Liquid Propane Gas (LP gas) tank, children. Disconnected LP gas tanks must not not included in grill box. Never connect your gas be stored in a building, garage or any other grill to an LP gas tank that exceeds this capacity. enclosed area. A tank of approximately 12 inches in diameter by 18-1/2 inches high is the maximum
Streszczenie treści zawartej na stronie nr. 4
Figure 1 (Naturalgas model only) IMPORTANT: your Kenmore Natural Gas Grill cannot GAS SUPPLY be converted to use LP Gas. Attempting to do so INSIDE is extremely hazardous and will also void the grill WALL warranty. OUTSIDE WALL Your natural gas grill is designed to operate on TO GRILL natural gas only, at a pressure of 7" water column SHUT OFF (W.C.) (1/4 psi or 1.75 kpa), regulated at the LOCKING SHUT OFF residential meter. Check with your gas utility \ \ company for local gas pressure and with
Streszczenie treści zawartej na stronie nr. 5
CAUTION:Spidersand smallinsectsocca- To reduce the chance of "FLASHBACK" (see sionallyspin websor makenestsin the grill CAUTION at left) clean the Burner Tubes and BurnerTubesduringtransitandwarehousing. Burners before fully assembling your grill. Remove the Cotter Pin from the rear underside Thesewebscan leadto a gasflowobstruc- tionwhichcouldresultin a fire in andaround of each Burner using a pair of long nose pliers. the BurnerTubes.This typeof fire is known Carefully lift each Burner up and
Streszczenie treści zawartej na stronie nr. 6
The following table illustrates a breakdown of the hardware pack. It highlights what components are used in the various stages of assembly. Ref. Component Qty. PurposeofComponents Attaches Side Shelf To Grill Head $122G04121 Phillips Head Screw 1/4"x3/4" 4 $142G04121 Countersink Flat Head Screw 1/4"x3/4" 4 Attaches Cart Side Handle To Grill Head Powers The Electric Ignitor P05301001A AA Battery 1 P05301003A 9V Battery 1 Powers The Fuel Gauge Display (LPG model only) Size and Quantity of each Har
Streszczenie treści zawartej na stronie nr. 7
LPG = Liquid Propane Gas 29b\ NG = Natural Gas 15 /(LPG only)43 3o 31 NG only)44 \57 (LPG only)39 (NG only)40 42 52 69 (LPG only) (LPG only) \57 (NG only) (NG only) 7
Streszczenie treści zawartej na stronie nr. 8
REF# DESCRIPTION PART# QTY 1 Lid P0011901AA 1 2 Lid Trim Plate P0011434EA 1 3 Temperature Gauge P00601171A 1 4 Lid Handle P00205031B 1 5 Name Plate P00410038C 1 6 Cooking Rack/Secondary P01515002B 1 7 Cooking Grid/Large P01606032B 2 8 Cooking Grid/Small P01606033B 1 9 Flame Tamer/Large P01708031B 2 10 Flame Tamer/Small P01708032B 1 11 Burner/Main P02001004E 4 1 la Burner Air Shutter/Main (NG only) P05524004A 4 12 Burner Bracket P02204261B 1 13 Gas Collector Box with Electrode P02608050C 2 14 Ele
Streszczenie treści zawartej na stronie nr. 9
I_F# DESCRIPTION PART# QTY 46 PO4302012A 1 Door, Left 47 PO4303012A 1 Door, Right 48 Door Trim Plate, Left PO7506OO7A 1 49 P07507007A 1 Door Trim Plate, Right (LPG) 50 P07507008A 1 Door Trim Plate, Right (NG) 51 P03314018C 1 Door Hinge Bracket, Top/Left 52 P03314019C 1 Door Hinge Bracket, Bottom/Left 53 P03314020C 1 Door Hinge Bracket, Top/Right 54 P03314021C 1 Door Hinge Bracket, Bottom/Right 55 PO5523002K 4 Door Magnet 56 Door Handle PO0205036B 2 57 PO5204010E 1 Cart Spice Basket (LPG) PO52040
Streszczenie treści zawartej na stronie nr. 10
Figure 1 LEFT SIDE SHELF CAUTION : While it is possible for one person to \ assemble this grill, obtain assistance from another person when handling some of the larger, heavier pieces. 1. Open the parts boxes. Use the parts list to check that all parts have been included. li 2. Inspect the grill for damage as you assemble it. Do LEFT OUTSIDE'_ not assemble or operate the grill if it appears damaged. If there are damaged or missing parts BOWL PANEL when you unpack the shipping box, or you have qu
Streszczenie treści zawartej na stronie nr. 11
Electrode Check - Requires an Assistant Installing Cooking Components Before placing the cooking components into your Important: Before cooking on your grill the first grill, ensure that the Spark Electrode Tip is properly time, wash the Cooking Grids and Cooking Rack positioned within each Gas Collector Box ( a 4" with warm, soapy water. Rinse and dry thoroughly. wide stainless mechanism found at the front be- After cooking is completed, turn grill to HIGH tween each set of Burners.) The easies
Streszczenie treści zawartej na stronie nr. 12
Figure 6a FOR LP GRILLS ONLY Battery Replacement: FUEL GAUGE 1. Remove the Grease Tray from the grill. DISPLAY COVER DISPLAY BOX 2. Stretch your hand behind Control Panet and unscrew the Battery Cover behind the Display Box. WIRE PLUG "A "j 3. Pull out the Battery with electric wire from the Battery 9V BATTERY ELECTRIC WIRE j Compartment. j 4. Replace the used Battery with the new one. J BATTERY CONNECTOR 5. Replace the new Battery with etectric wire back into IMPORTANT: When the gas tank is rem
Streszczenie treści zawartej na stronie nr. 13
Connecting A Liquid Propane Gas (LP gas) Figure 7a (LP gas model only) Tank To Your Grill 1. Remove the Pull-out Grease Draining Tray with the Heat Shield from Grill. 2. Locate hose and regulator assembly packed for shi pping purposes on front underside of grill head. Remove fastening band. Push assembly to back of grill and pull down to connect to tank valve. Before connecting, check valve and assembly threads to be sure they match. (Type 1 connection per ANSI Z21.58b-2002) See Figure 7b. FRONT
Streszczenie treści zawartej na stronie nr. 14
Connecting Natural Gas To Your Grill For Natural Gas grills: The 12 foot Natural Gas Hose has alseady been connected to the Gas Manifold as shown in Figure 7c. Thread the 12 foot Natural Gas Hose through the hole of Rear Panel to outside. Also read the natural gas safety instructions.(on page 4) Figure 7c (Natural gas model only) GAS MANIFOLD _REAR PANEL 12' NATURAL GAS HOSE HOLE FOR _12' NATURAL GAS HOSE Install Pull-out Grease Tray Place Heat Shield into Pull-out Grease Draining Tray. The Heat
Streszczenie treści zawartej na stronie nr. 15
LP Tank Exchange WARNING • Many retailers that sell grills offer you the op- tion of replacing your empty LP tank through an If you smell gas: exchange service. Use only those reputable exchange companies that inspect, precision fill, test and certify their cylinders. Exchange • Shut off gas supply to the gas grill. your tank only for an OPD safety feature-equipped • Turn the Control Knobs to OFF position. tank as described in the LP Tank section of • Extinguish any open flame such as candle, ci
Streszczenie treści zawartej na stronie nr. 16
. if the burner does not light, turn the Control Knob to OFF, wait 5 minutes for gas to clear, then retry. BasicLighting Procedures 9. Once the left grill burner is ignited, the adjacent Machine oils used in the manufacturing process of burner can be lit by simply turning its Control Knob stainless steel can cause stainless steel to turn a tan toHIGH. color. Before initial grill use, remove protective PVC 10. film from Control Panel and inside and outside of Grill Adjust Control Knobs to your de
Streszczenie treści zawartej na stronie nr. 17
Manually Lighting Your Grill by Match Misalignment of Ignitor on Burner Correction: Check for proper position of the To light your main burners by match, Follow steps 1 Electrode Tip as shown in Figure 4 The gap through 6 of the Gas Lighting Instructions. Then, light between the Spark Electrode Tip and Burner or the match and place it over the top oppening of the Spark Receiver should be approximately 3/16", Lighting Tube. Push and turn the nearest Control Knob Adjust if necessary. With the gas
Streszczenie treści zawartej na stronie nr. 18
. Cover each GasValveOrificewith aluminum foil. 6. Brush the inside and bottom of the grill with a fiber CAUTION: pad or nylon brush, and wash with a mild soap and BesureyourgrillisOFFandcoolbefore cleaning. warm water solution. Rinse thoroughly and let dry. Takecarenottochiporscratch thepainted surfaces 7. Remove aluminum foil from Orificesand check because itwillvoidyourwarranty against rusting. each Orifice for obstruction. Aswithallappliances, proper careandmaintenance 8. Check each Spark El
Streszczenie treści zawartej na stronie nr. 19
Cleaning The Burner Tubes and Burner Ports Regardtessof which Burner cteaning procedure you use, we recommend you also complete the following To reduce the chance of FLASHBACK the procedure steps to help prolong Burner life. below should be followed at least once a month in late 1. Use a fiber pad or nylon brush to clean the entire summer or early fall when spiders are most active or outer surface of each Burner until free of food when your grill has not been used for a period of time. residue a
Streszczenie treści zawartej na stronie nr. 20
Question: What is the best way to protect my new Kenmore gas grill from the weather? Answer: A good quality grill cover should be used to Question: Can I convert my Kenmore gas grill from protect your grill when not inuse. Sears offers a cover one fuel type to another? that is made to fit this particular grill model. Also, follow Answer: Your Kenmore gas grill is manufactured to the cleaning and maintenance instructions in this exact specifications and is approved by the Canadian Owner's Manual
