Streszczenie treści zawartej na stronie nr. 1
®
VACUFLUSH
SANITATION SYSTEM
OWNER’S MANUAL
500 Plus Series, 1000 Series, Model 706 Toilets
WARNING
!
This manual must be read and understood
before adjustment, maintenance, or service is
performed. Modification of this product can
result in property damage.
Dometic Corporation • Sanitation Systems
13128 State Rt. 226, P.O. Box 38
Big Prairie, OH 44611-0038 USA
SeaLand Product Hotline 1-800-321-9886
(8:00 a.m. - 5:00 p.m
Streszczenie treści zawartej na stronie nr. 2
TABLE OF CONTENTS Page Page Product Features . . . . . . . . . . . . . . . . . . . . . . 2 Toilet Model Identification . . . . . . . . . . . . . . . . 7 Marine Sanitation Regulations . . . . . . . . . . . . 3 Pedestal and Pedal Cover Installation . . . . . . 7 Important Information Before Operation . . . . . 3 Deodorants and Special Tissue . . . . . . . . . . . 8 Key System Components . . . . . . . . . . . . . . . . 4 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . 9 S
Streszczenie treści zawartej na stronie nr. 3
MARINE SANITATION REGULATIONS All boats with fixed toilets in U.S. waters and in the waters of some other countries are required to be equipped with an operable marine sanitation device (MSD). The VacuFlush system is a holding tank or Type III system as defined by the U.S. Coast Guard. Type III systems are designed to permit operation of the toilet without the direct discharge of untreated waste after every flush. This means onboard toilet facilities can be used when the boat is near swimme
Streszczenie treści zawartej na stronie nr. 4
KEY SYSTEM COMPONENTS Vacuum Toilet: The VacuFlush toilet operates in a way different from other marine toilets. VacuFlush systems use a small amount of water (a little more than a pint or .5 liter) per flush in addition to a simple vacuum. The toilet is connected to a pressurized freshwater system. Fresh water is the key to an odor-free bathroom compartment. VacuFlush toilets are equipped with an integral vacuum breaker which prevents the possible contamination of the potable water sup
Streszczenie treści zawartej na stronie nr. 5
SYSTEM START-UP 1. Turn on inlet water supply. 2. Turn on electrical power to system. 3. Flush water into system by depressing flush lever until water starts flowing to the vacuum pump, approxi- mately 15 seconds. The vacuum pump will run for approximately 60 to 90 seconds until system reaches operating vacuum level and then will shut off. PROPER CLEANING The SeaLand toilet should be cleaned regularly for maximum sanitation and operational efficiency. You can clean it just as you would a house
Streszczenie treści zawartej na stronie nr. 6
CLEARING DISCHARGE LINES Sanitation hoses should be cleared if toilet will not be needed for an extended period of time (more than two weeks). 1. Fill toilet bowl with water and add 4 oz. (120 ml) of biodegradable laundry detergent (should NOT contain bleach). 2. Flush toilet, holding pedal down for about two minutes. Close flush ball. 3. Turn off water supply to toilet. 4. Flush the toilet without water, allowing the vacuum pump to shut off after the flush. Repeat three times. (This proced
Streszczenie treści zawartej na stronie nr. 7
VACUFLUSH MAINTENANCE KIT The VacuFlush Maintenance Kit contains re- VacuFlush placement parts used in routine maintenance of Maintenance Kit VacuFlush toilets. A “must” for those who cruise (item number 310228) to remote locations. The kit includes vacuum tester, water valve, seal kit, duckbill valves (4) and an owner’s manual in a convenient storage container. ORDERING PARTS Dometic is ready to assist you in the event service is required. Before calling, please have the following
Streszczenie treści zawartej na stronie nr. 8
DEODORANTS AND SPECIAL TISSUE Your VacuFlush sanitation system requires the regular addition of a deodorant product to reduce malodors and to help break down holding tank contents. Several factors should be considered in selecting a deodorant product. Liquid or Granulated: Liquid products obviously work more quickly by readily going into solution. Granulated powder formulations, on the other hand, have the advantage of requiring less storage space and are less likely to leak if the pack
Streszczenie treści zawartej na stronie nr. 9
ACCESSORIES TM NozAll Pumpout Adapter: The NozAll pumpout adapter NozAll™ Adapter provides an airtight seal between your boat’s deck waste fitting and the pumpout station nozzle. Just screw your personal NozAll adapter into your deck fitting, and be as- *Nozzle sured of an airtight connection for pumping out holding tank contents. Each item contains a glass-filled nylon NozAll adapter, gasket and vinyl cap. Item number 343502 (1-1/2"- 11.5 tpi), 343503 (1-1/4"-11.5tpi), or 343504 (1-1/4"-
Streszczenie treści zawartej na stronie nr. 10
TROUBLESHOOTING GUIDE BASE ASSEMBLY VACUUM BREAKER WHITE CAP REAR VIEW, VACUUM TOILET HOSE CONNECTION VACUUM BREAKER/BOWL CONNECTION Problem Possible Cause Service Instructions 1. Water will not stay in bowl. a. Loose clamp ring. a. Tighten clamp ring adjusting nut. b. Improper seal around flush ball due b. Inspect flush ball and underside of to dirt or debris on underside of ball seal for foreign objects. Clean under seal. seal if needed (cleaning tool avail- able – p/n 600344236). c. Wo
Streszczenie treści zawartej na stronie nr. 11
TROUBLESHOOTING GUIDE Problem Possible Cause Service Instructions 6. Lifting foot pedal does not a. Too much clearance between the a. Adjust cam strap so clearance is add water to the bowl. cam strap and water valve. .06 inches (1.5mm) maximum. 7. Water leaking from water a. Water valve body cracked due to a. Replace water valve. valve. freeze damage. b. Water line connection is loose or not b. Insure that threads are not cross- seated properly. threaded and tighten. c. Defective water valve
Streszczenie treści zawartej na stronie nr. 12
TROUBLESHOOTING GUIDE Problem Possible Cause Service Instructions 13. Vacuum pump is running too a. Gear motor is worn or defective. a. Check motor and replace if slow, overheating, blowing necessary. fuses or circuit breaker. b. Plugged vent line or vent filter. b. Disassemble and clean out vent line. Replace vent filter if necessary. c. Blockage in discharge line. c. Disassemble and clean discharge line. Be certain that in-line valves (duckbill valves) and seacock are in proper positio
Streszczenie treści zawartej na stronie nr. 13
DIMENSIONAL SPECIFICATIONS * * * * Width measurement includes flush pedal. Toilet dimensions may vary ± 3/8-inch (10mm). 13
Streszczenie treści zawartej na stronie nr. 14
WIRING DIAGRAMS VACUUM GENERATOR VACUUM PUMP 14
Streszczenie treści zawartej na stronie nr. 15
PARTS DISTRIBUTORS There is a strong, worldwide network to assist in servicing and You may also contact or have your local dealer contact the maintaining your sanitation system. For the Authorized Service Parts Distributor nearest you for quick response to your Center near you, please call from 8:00 a.m. to 5:00 p.m. (ET) replacement parts needs. They carry a complete inventory Monday through Friday. You may also write us at Dometic for the SeaLand product line. Corp., P.O. Box 38, Big Prai
Streszczenie treści zawartej na stronie nr. 16
MANUFACTURER’S ONE-YEAR LIMITED WARRANTY Dometic Corporation warrants, to the original purchaser only, that this product, if used for personal, family or household-like purposes, and if installed according to Dometic’s recommended procedures, is free from defects in material and workman- ship for a period of one year from the date of purchase. If this Dometic product is placed in commercial or business use, it will be warranted, to the original purchaser only, to be free of defects in materi
