Resumo do conteúdo contido na página número 1
Installation and Operating Manual
Magnafire Series Coal Stoves - Mark I, II, and III
SAFETY NOTICE
PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL OR USE YOUR NEW ROOM HEATER. FAILURE
TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY, OR EVEN DEATH.
APPROVED FOR USE IN THE U.S. AND CANADA
IF THIS HARMAN STOVE IS NOT INSTALLED CORRECTLY, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY,
FOLLOW INSTALLATION DIRECTIONS PRECISELY.
CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT RE
Resumo do conteúdo contido na página número 2
3-90-70746R8_11/12
Resumo do conteúdo contido na página número 3
Introduction Thank you for purchasing a Harman Magnafire coal stove. The Magnafire series has been designed and built to last. Whether you’re heating a room or heating your whole house, you’ve made the right choice. Please read this entire instruction manual before attempting to install or operate your new stove. If you have further questions regarding your new stove, contact your Harman dealer. Follow these instructions and you will have many years of warmth and comfort enjoying your new co
Resumo do conteúdo contido na página número 4
Index 1. SaFeTy CoNSIdera TIoNS - Warnings to operator of possible dangers, fire hazards and cautions. 1.1 Keep children away -- may cause serious burns 1.2 Fuel/Firing Warnings 1.3 Curing Paint 1.4 Mobile Homes 2. aSSeMbly & INST alla TIoN 2.1 Unpacking and Inspection of Parts 2.2 locating The Stove 2.3 assembly 2.4 General Information 3. VeNTING 3.1 Types of Chimneys 3.2 Common Chimney Problems 3.3 What To do If you Have a Problem 3.4 Chimney details 4. Gra TeS 4.1 Grate System
Resumo do conteúdo contido na página número 5
48" Floor Protector Installation 1. Safety Considerations: 2. Assembly & Installation: 2.1 UNPACKING AND INSPECTION OF PARTS. 1.1 KEEP CHILDREN AWAY - MAY CAUSE SERIOUS Inspect the stove for any visible damage. The blower BURNS. and the shaker handle are packaged inside the stove. CaUTIoN: all surfaces of the stove are hot while in operation. do not touch. Keep Children away. Wear 2.2 LOCATING THE STOVE. locate the stove as close to the chimney or flue gloves while tending stove. Seriou
Resumo do conteúdo contido na página número 6
Installation 2.3 ASSEMBLY. 2.4 GENERAL INFORMATION. Installation Checklist: Slide the blower into the slotted bracket on the rear of the stove. The blower will rest at the bottom of the slot. a. Have your stove installed by a trained installer. Preferably one who is certified by the National Fireplace Institute or similar certification agency. b. before starting Installation, check for proper clearance to combustibles where the stove is going to be located. C. Never vent a solid fuel burnin
Resumo do conteúdo contido na página número 7
Venting Where an existing chimney is used, it must be large 3.2 COMMON CHIMNEY PROBLEMS enough to provide a draft adequate for removing the In order to have a properly operating heating system, gaseous products of combustion. The cross-sectional the chimney needs to be capable of providing sufficient area of the chimney must be at least 25 percent greater draft. The minimum required draft is .06 inches of than that of the connector. as a general rule, common water column (WC). To measure
Resumo do conteúdo contido na página número 8
Venting & Grates e) Improperly sized flue - Too small of a chimney is 4. Grates incapable of moving the volume of air necessary. Too 4.1 GRATE SYSTEM AND CONTROLS. large of a flue could have trouble warming up to create The Grates are made of heavy-duty cast iron. The the necessary upward flow. function of the grate system is to support the coal F) Chimney offsets - offset chimneys should be while allowing air flow through the fire. The grate avoided if possible. Not only can the offset
Resumo do conteúdo contido na página número 9
Operation 5.3 INCREASING HEAT FROM A LOW FIRE 5. Operating Instructions every effort should be made to not let a coal fire burn 5.1 STARTING A FIRE so long that it begins to die. This causes the reloading Place seven or eight sheets of crumpled newspaper process to be much longer, and there is a good onto the top of the grates. Next, lay in some small possibility of losing the fire all together. do not shake kindling wood (approximately 3/4” or less) on top of the or stir a low fire. open
Resumo do conteúdo contido na página número 10
Maintenance 5.6 SAFETY To clean the chimney, use a stiff brush with an extendable handle. Start the brush from the top of the Whenever a loading door is opened, it should always chimney and run it down through the flue. Continue be cracked slightly to allow oxygen to enter and burn brushing until the entire length of the chimney is any gasses that may be present. Failure to do this cleaned. The debris will collect at the bottom of the may result in a sudden ignition of the gasses, leadin
Resumo do conteúdo contido na página número 11
Optional Water Coil 7. Optional Hot Water Coil: Plumbing Diagrams- Washer Inside Nut Outside Nut Packing Stove Body 3-90-70746R8_11/12 Magnafire Series Coal Stoves 11
Resumo do conteúdo contido na página número 12
Optional Water Coil To install the optional hot water coil, Two holes will need to be drilled or cut into the side of the stove. There is a template for the hole location(s) that is included with the coil. Keep the holes above the firebricks and toward the back of the firebox. This location is best to not interfere with loading. Thermo- Siphon Method This is the simple and most economical method, however, the hot water tank must be no more than ten feet from the stove. The water inlet, where
Resumo do conteúdo contido na página número 13
8. Warranty Information: Hearth & Home Technologies Inc. LIMITED LIFETIME WARRANTY Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer. WARRANTY COVERAGE: HHT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership of the appliance at the site of installation within two
Resumo do conteúdo contido na página número 14
WARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. • Contact your installing dealer for warranty service. If the installing dealer is unable to provide necessary parts, contact the nearest HHT authorized dealer or supplier. Additional service
Resumo do conteúdo contido na página número 15
9. Service Parts Service Parts Mark I Beginning Manufacturing Date: N/A Magnafi re Freestanding Coal Stove Ending Manufacturing Date: Active 1-90-03224-1 (Black w/Door) Retired Units 1-70-03224-1 (Black), Ending Manufacturing Date: June 2011 1-70-03224-4 (Metallic Blue) Ending Manufacturing Date: Jan 2010 1-70-03224-2 (Charcoal) Ending Manufacturing Date: June 2011 1-70-03224-10 (Mojave Red) Ending Manufacturing Date: Jan 2010, 1-70-03224-3 (Goldenfi re) Ending Manufacturing Date: June 201
Resumo do conteúdo contido na página número 16
Service Parts Mark I Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPorTaNT: THIS IS daTed INForMaTIoN. When requesting service or replacement parts for your appliance please provide model number and serial number. all parts listed Stocked in this manual may be ordered from an authorized dealer. at Depot ITEM DESCRIPTION COMMENTS PART NUMBER ash Pan 1-10-65127 Y baffl e 2-00-00503b blower - 75cfm, 7ft Cord 3-21-07584 Y Pkg of 7 1-00-900450125 Y brick 9” X 4-1/2” x 1-1/4
Resumo do conteúdo contido na página número 17
Service Parts Mark II Mark II Beginning Manufacturing Date: N/A Beginning Manufacturing Date: N/A Magnafi re Freestanding Coal Stove Ending Manufacturing Date: Ending Manufacturing Date: Active Active 1-90-03225-1 (Black w/fDoor) Retired Units 1-70-03225-1 (Black) Ending Manufacturing Date: June 2011 1-70-03225-4 (Metallic Blue) Ending Manufacturing Date: Jan 2010 1-70-03225-2 (Charcoal) Ending Manufacturing Date: June 2011 1-70-03225-10 (Mojave Red) Ending Manufacturing Date: Jan 2010 1-70-03
Resumo do conteúdo contido na página número 18
Service Parts Mark II Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPorTaNT: THIS IS daTed INForMaTIoN. When requesting service or replacement parts for your appliance please provide model number and serial number. all parts listed in this manual may Stocked be ordered from an authorized dealer. at Depot ITEM DESCRIPTION COMMENTS PART NUMBER ash door, roped 1-10-08142a ash Pan 1-10-00722 Y baffl e 2-00-00360b blower - 75cfm, 7ft Cord 3-21-07584 Y Pkg of 7 1-00-90045012
Resumo do conteúdo contido na página número 19
Service Parts Mark III Magnafi re Freestanding Coal Stove Beginning Manufacturing Date: N/A 1-90-03227-1 (Black w/Door) Ending Manufacturing Date: Active Retired Units 1-70-03227-1 (Black) Ending Manufacturing Date: June 2011 1-70-03228-1 (Black) Ending Manufacturing Date: June 2011 1-70-03227-2 (Charcoal) Ending Manufacturing Date: June 2011 1-70-03228-2 (Charcoal) Ending Manufacturing Date: June 2011 1-70-03227-3 (Goldenfi re) Ending Manufacturing Date: June 2011 1-70-03228-3 (Gold, Ending
Resumo do conteúdo contido na página número 20
Service Parts Mark III Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPorTaNT: THIS IS daTed INForMaTIoN. When requesting service or replacement parts for your appliance please provide model number and serial number. all parts listed Stocked in this manual may be ordered from an authorized dealer. at Depot ITEM DESCRIPTION COMMENTS PART NUMBER ash door, roped 1-10-08142a ash Pan 1-10-00723 Y baffl e 2-00-00378b blower - 135cfm, 7ft Cord 3-21-13584 Y bolt, 1/4-20 x 1/2”
