Краткое содержание страницы № 1
Operator’s Manual
18” and 20”
Mulching Push
Mowers
Models
LC-106 and LC-40
IMPORTANT: Read safety rules and instructions carefully before operating equipment.
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-
covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting
applicable local or state laws (if any). If a spark arrester is used, it should be
Краткое содержание страницы № 2
TABLE OF CONTENTS Content Page Important Safe Operation Practices................................................................... 3-5 Slope Gauge...................................................................................................... 6 Unpacking..........................................................................................................7 Assembling Your Lawn Mower........................................................................... 7 Know Your Lawn Mower .....
Краткое содержание страницы № 3
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate your lawn mower. Failure to comply with these instructions may result in personal injury. When you see this symbol, heed its warning. DANGER: Your lawn mower was built to be operated according to the rules for safe operat
Краткое содержание страницы № 4
The blade control handle is a safety device. Never Always be sure of your footing. A slip and fall can attempt to bypass its operation. Doing so makes cause serious personal injury. If you feel you are the safety device inoperative and may result in losing your balance release the blade control personal injury through contact with the rotating handle immediately and the blade will stop in less blade. The blade control handle must operate than 3 seconds. easily in both directions and auto
Краткое содержание страницы № 5
To reduce fire hazard, keep mower free of grass, Never tamper with safety devices. Check their leaves, or other debris build-up. Clean up oil or proper operation regularly. fuel spillage. Allow mower to cool at least 5 After striking a foreign object, stop the engine, minutes before storing. remove the wire from the spark plug, and Before cleaning, repairing, or inspecting, make thoroughly inspect the mower for any damage. certain the blade and all moving parts have Repair the damage
Краткое содержание страницы № 6
SECTION 2: SLOPE GAUGE Use this page as a guide to determine slopes where you may not operate the lawn mower safely. 6 USE THIS PAGE AS A GUIDE TO DETERMINE SLOPES WHERE YOU MAY NOT OPERATE SAFELY. SIGHT AND HOLD THIS LEVEL WITH A VERTICAL TREE A POWER POLE A CORNER OF A BUILDING OR A FENCE POST 15° WARNING Do not mow on inclines with a slope in excess of 15 degrees (a rise of approximately 2-1/2 feet every 10 feet). A riding mower could overturn and cause serious injury. If operating a wal
Краткое содержание страницы № 7
SECTION 3: UNPACKING Remove loose parts if included with unit (i.e., Removing Unit From Carton operator’s manual, etc.). Remove staples, break glue on top flaps, or cut Cut corners and lay carton down flat. tape at carton end and peel along top flap to open Remove packing material. carton. Roll or slide unit out of carton. Check carton thoroughly for loose parts. SECTION 4: ASSEMBLING YOUR LAWN MOWER IMPORTANT: This unit is shipped WITHOUT GASOLINE or OIL. Be certain to service
Краткое содержание страницы № 8
Insert post on cable ties into holes provided on the With the spark plug wire disconnected and lower handle. Pull the cable tie tight and trim the grounded, hold the blade control handle against the excess. See Figure 4. upper handle, and pull the starter rope out of the engine. Release the blade control handle. Slip the Cable Tie starter rope into the rope guide. Tighten the wing nut. See Figure 5. Post Make certain all nuts and bolts are tightened securely. Your mower has been sh
Краткое содержание страницы № 9
Recoil Starter Blade Control Handle The recoil starter handle is attached to the handle. See Figure 7. Stand behind the unit in the operating position to start the unit. Cutting Height Recoil Adjustment Lever Starter Handle Mulching Plug Spark Plug Wire Figure 7 SECTION 6: OPERATING YOUR LAWN MOWER Keep hands and feet away from the chute area on the Prime engine as instructed in the engine manual. cutting deck. See safety labels on page 5. Standing behind the unit, depress the blade con
Краткое содержание страницы № 10
For best results, do not cut wet grass because it For a healthier lawn, always cut off one-third or less tends to stick to the underside of the mower, of the total length of the grass. Lawn should be cut preventing proper discharge of grass clippings, and in the fall as long as there is growth. could cause you to slip and fall. New grass, thick This mower is designed to be operated at full grass or wet grass may require a narrower cut. throttle to give you the best cut and do the most
Краткое содержание страницы № 11
SECTION 8: SERVICE WARNING: Always stop engine and Lubrication Chart: disconnect spark plug wire before cleaning, lubricating or doing any kind of work on lawn mower. Lubricate Blade Control Lubricate the pivot points on the blade control handle and the brake cable at least once a season with light oil. See Figure 10. The blade control must operate freely in both directions. Wheels Lubricate the wheel bearings (if so equipped) at least once a season with light oil (or engine oil). Also, if
Краткое содержание страницы № 12
Before reinstalling the blade and the blade adapter We do not recommend the use of pressure to the unit, lubricate the engine crankshaft and the washers or garden hose to clean your unit. They inner surface of the blade adapter with light oil (or may cause damage to electric components, engine oil). Lubricating the bolt holes, bolts and spindles, pulleys, bearings or the engine. The use inner surface of the nuts is also recommended. of water will result in shortened life and reduce serv
Краткое содержание страницы № 13
SECTION 11: TROUBLE SHOOTING GUIDE Trouble Possible Cause(s) Corrective Actions Engine fails to 1. Control handle disengaged. 1. Engage blade control handle. start 2. Spark plug wire disconnected. 2. Connect wire to spark plug. 3. Dirty air cleaner. 3. Refer to the engine manual packed with your unit. 4. Primer button not depressed. 4. Refer to the engine manual. 5. Throttle control lever not in 5. Move throttle lever to FAST or START position. correct starting position . 6. Fuel tank empty or
Краткое содержание страницы № 14
SECTION 12: PARTS LIST FOR MODELS LC-106 AND LC-40 2 1 3 8 28 4 19 14 22 21 26 7 13 15 6 25 5 17 23 15 16 16 20 18 6 5 27 17 9 14 24 12 19 22 29 10 7 11 Ref. Ref. Part No. Description Part No. Description No. No. 1 17098 Hinge Clip 15 738-0507B Shoulder Bolt 2 731-0872A Rear Flap† 16 14832 Spring Lever Ass’y w/Knob 731-1028 Rear Flap†† 17 15262B Pivot Bar 3 682-3025 Handle Bracket Ass’y LH† 18 15261A Height Adj. Plate 682-3001A Handle Bracket Ass’y LH †† 19 734-1978 Wheel Assembly 4 682-3024
Краткое содержание страницы № 15
Models LC-106 and LC-40 NOTE: For painted parts, please refer to 1 the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part, numbered 700-xxxx, is painted Oyster Gray, the part number to order would be 700-xxxx-0662. 7 Oyster Gray: 0662 Powder Black: 0637 Red Metallic: 0650 6 2 5 8 11 20 17 15 10 9 21 10 18 11 12 13 19 14 Ref. No. Part No. Description Ref. No. Part No. Description 1 647-0004 Co
Краткое содержание страницы № 16
MANUFACTURER’S LIMITED WARRANTY FOR: c. Log splitter pumps, valves and cylinders have a sepa- The limited warranty set forth below is given by White Out- rate one year warranty. door Products Co. with respect to new merchandise pur- d.White Outdoor Co. does not extend any warranty for chased and used in the United States, its possessions and products sold or exported outside of the United States territories. of America, its possessions and territories, except those sold through White Outdoor Co.
