Краткое содержание страницы № 1
Clarendon & Ashdon
Log Effect Stove Range
Conventional Flue
With upgradeable control valve
Instructions for Use,
Installation and Servicing
For use in GB, IE (Great Britain and Eire)
This appliance has been certified for use in countries other than those stated. To install this appliance in these countries, it is essential to obtain the
translated instructions and in some cases the appliance will require modification. Contact Gazco for further information.
IMPORTANT
Do not attempt to burn rubbis
Краткое содержание страницы № 2
CONTENTS COVERING THE FOLLOWING MODELS CLARENDON – 8611LUC – P8611LUC / 8612LUC – P8612LUC ASHDON – 8613LUC – P8613LUC / 8614LUC – P 8614LUC PAGE APPLIANCE COMMISIONING CHECKLIST 3 USER INSTRUCTIONS 4 INSTALLATION INSTRUCTIONS 8 Technical Specifications 8 Site Requirements 9 Installation 10 Commissioning 14 SERVICING INSTRUCTIONS 15 Servicing Requirements 15 Fault Finding 15 How to replace parts 17 Basic spare parts list 21 Service Record 22 2
Краткое содержание страницы № 3
APPLIANCE COMMISSIONING CHECKLIST IMPORTANT NOTICE Explain the operation of the appliance to the end user, hand the completed instructions to them for safe keeping, as the information will be required when making any guaranteed claims. FLUE CHECK PASS FAIL 1. Flue is correct for appliance 2. Flue flow test 3. Spillage test GAS CHECK 1. Gas soundness & let by test 2. Standing pressure test mb 3. Appliance working pressure (on High Setting) mb NB All other gas appliances must be operating on full
Краткое содержание страницы № 4
USER INSTRUCTIONS 1.12 In all correspondence, please quote the appliance type and 1. GENERAL Serial Number which can be found on the databadge at the rear of the stove. 1.13 This product is guaranteed for 2 years from the date of 1.1 Installation and servicing must be carried out by a installation, as set out in the terms and conditions of sale competent person in accordance with Gas Safety (Installation between Gazco and your local Gazco dealer. Please consult and Use) Regulations 1998, the rel
Краткое содержание страницы № 5
USER INSTRUCTIONS 3. TURNING OFF THE STOVE 6. CLEANING THE FIRE 3.1 To turn the stove off, locate the control valve, turn the left- WARNING: DO NOT ATTEMPT TO CLEAN THE STOVE hand control knob until it points to off ( ). The main burner UNTIL IN A COLD CONDITION. THE STOVE RETAINS will go out leaving the pilot burning. ITS HEAT FOR A CONSIDERABLE TIME AFTER SHUTDOWN. 3.2 To turn the pilot off, locate the control valve, turn the right- hand control knob until it points to off ( ), the pilot will
Краткое содержание страницы № 6
USER INSTRUCTIONS 7.2 Place log B on the left-hand side of the burner with the 7 location bar on the underside of the log fully located in the long slot of the burner. Make sure the log is as far to the left as possible. See diagram 4. 4 AR1614 7.6 Place the second ash panel to the right of the first, with the pointed end of the panel fitting into the V shape. This panel AR1611 should locate on the screw holes of the burner skin. Ensure that both logs are horizontal to the burner ports. 7.3 Plac
Краткое содержание страницы № 7
USER INSTRUCTIONS 7.8 Carefully insert the front coal retainer into the front panel of 10. ‘RUNNING IN’ the firebox. Take care not the scrape/damage the logs. This coal retainer sits in two brackets. Ensure it is fully inserted, leaving approximately a 4 mm gap between the firebox 10.1 The surface coating on your GAZCO fires will "burn off" ledge and the bottom of the coal retainer. during the first 24 hours of use, producing a harmless and temporary odour. This will disappear after the short pe
Краткое содержание страницы № 8
INSTALLATION INSTRUCTIONS TECHNICAL SPECIFICATION COVERING THE FOLLOWING MODELS: CLARENDON – 8611LUC – P8611LUC / 8612LUC – P8612LUC ASHDON – 8613LUC – P8613LUC / 8614LUC – P 8614LUC Model Gas Gas Working NOX Aeration Injector Gas Rate Input kW (Gross) Country 3 CAT. Type Pressure Class m /h High Low 8611LUC I Natural 20 mbar 3 Ø 14.5 375 0.623 6.6 3.6 GB, IE 2H 8612LUC (G20) Gross Gross P8611LUC I Propane 37 mbar 3 Ø 11.5 x 2 165 0.232 6.4 3.6 GB, IE 3P P8612LUC (G31) Gross Gross 8613LUC I Natu
Краткое содержание страницы № 9
INSTALLATION INSTRUCTIONS SITE REQUIREMENTS 1. FLUE AND CHIMNEY REQUIREMENTS 4. APPLIANCE LOCATION 1.1 The chimney or flue system must comply with the rules in 4.1 This fire must stand on a non-combustible hearth that is at force and must be a minimum of 127mm in diameter. (5"). least 12mm thick and projects 50mm minimum from the base of the fire in all directions. 1.2 The minimum effect height of the flue or chimney must be 3 metres (10ft). Any horizontal flue run from the rear outlet 4.2 Do no
Краткое содержание страницы № 10
INSTALLATION INSTRUCTIONS INSTALLATION allowed before trying to relight. Continued operation of this IMPORTANT: ENSURE THAT THE APPLIANCE IS safety device means that there may be a serious problem CORRECTLY ADJUSTED FOR THE GAS TYPE AND with the flue system; a qualified gas engineer should inspect CATEGORY APPLICABLE IN THE COUNTRY OF USE. this. DO NOT USE THE STOVE UNTIL AN ENGINEER SAYS REFER TO DATABADGE AND TECHNICAL IT IS SAFE TO DO SO. SPECIFICATIONS OF THIS BOOKLET. FOR DETAILS OF CHANGIN
Краткое содержание страницы № 11
INSTALLATION INSTRUCTIONS INSTALLATION 3.6 The flue system may now be connected to the stove. Ensure 3 that all joints are sealed with a suitable fire resistant sealant. It is also recommended that a physical retention method be used at the flue spigot joint, self-tapping screws being favoured. 3.7 Connect a suitable pressure gauge to the test point located on the inlet fitting, and turn the gas supply on. Light the appliance and check all gas joints for gas soundness. Turn the appliance to maxi
Краткое содержание страницы № 12
INSTALLATION INSTRUCTIONS INSTALLATION 5.4 Place log D across from the rear log A to log B on the left- 9 hand side. There are cut-outs in both logs for location. See diagram 6. 6 AR1616 5.8 Carefully insert the front coal retainer into the front panel of AR1613 the firebox. Take care not the scrape/damage the logs. This coal retainer sits in two brackets. Ensure it is fully inserted, leaving approximately a 4 mm gap between the firebox 5.5 There are two ash panels which lay across the front of
Краткое содержание страницы № 13
INSTALLATION INSTRUCTIONS INSTALLATION 6. LIGHTING 6.1 Full instructions are given in the User section under Lighting the Stove. 13
Краткое содержание страницы № 14
INSTALLATION INSTRUCTIONS COMMISSIONING 1. COMMISSIONING 1.1 Close all openable doors and windows in the room, ignite the stove and operate on maximum for 10 minutes. Position a lighted smoke match just inside the draught diverter opening and check that all smoke is drawn into the opening by viewing through the sight hole. See diagram 1. If there is any doubt, run the stove for a further 10 minutes and repeat the test. 1 AR1493 1.2 If there are any extractor fans in adjacent rooms, the test must
Краткое содержание страницы № 15
SERVICING INSTRUCTIONS SERVICING / FAULT FINDING CHARTS and tighten if they are loose. 1. SERVICING REQUIREMENTS 1.4 Correct any faults found during the initial tests and then recommission the appliance conducting the usual safety checks. This appliance must be serviced at least once a year by a competent person. 1.5 Advise the customer of any remedial action taken. All tests must be serviced by best practice as described by 1 the current CORGI recommendations. 1.1 Before any tests are undertake
Краткое содержание страницы № 16
SERVICING INSTRUCTIONS SERVICING / FAULT FINDING CHARTS 16 FLAME FAILURE FUNCTIONAL CHECK 3 IGNITION FUNCTIONAL CHECK 2 PILOT WILL NOT STAY LIT OR FIRE GOES OUT IN USE NO SPARK Ensure there is no debris around the pilot assembly, (e.g. coal, soot Ensure there is no debris around the pilot assembly, (e.g. coal, soot etc.) which could short the spark, clear the area. etc.) which could short the spark, clear the area. From Ignition Fault Finding Consult the Users Instructions, Light the pilot and k
Краткое содержание страницы № 17
SERVICING INSTRUCTIONS REPLACING PARTS ceramic fuelbed components. 1. GENERAL 3.3 Remove the main burner. See Section 2 above. 3.4 Remove the two fixing screws from the pilot bracket. See 1.1 All principal components can be replaced without removing Diagram 2. Gently draw the assembly away from the firebox the stove from its installation, although it is essential that the to give access to the nuts and ignition lead. gas supply to the appliance is turned off at the isolation 2 device before proc
Краткое содержание страницы № 18
SERVICING INSTRUCTIONS REPLACING PARTS 3.7 To remove the thermocouple, undo the retaining nut and 4.3 To release the right-hand side of the control cover insert the withdraw the thermocouple. Undo the thermocouple from narrow blade screwdriver into the slot shown in diagram 8. the back of the gas valve. See Diagrams 5 and 6. Reassemble Lever it gently and pull from the right-hand side at the same in reverse order. Do not overtighten. time. The cover will now come off. There is a small cylindrica
Краткое содержание страницы № 19
SERVICING INSTRUCTIONS REPLACING PARTS 6.6 Check all joints for gas leaks. Check the operation of the 12 thermocouple and ignition lead. 10 AR0618 AR0943b 8.4 Holding the injector with a spanner, undo the feed pipe. NOTE: THE ORIENTATION OF THE INJECTOR. 8.5 Reassemble in reverse order. Turn on the gas supply and check for any leaks. 7. MAGNETIC SAFETY VALVE 9. GAZCO FLUE SURE SYSTEM 7.1 Turn the gas supply off at the isolation device. Undo the thermocouple connection from the back of the gas v
Краткое содержание страницы № 20
SERVICING INSTRUCTIONS REPLACING PARTS 9.3 Undo the two screws at the back of the firebox and carefully 18 withdraw the bracket. 15 AR1448 AR1447 AR1607 9.6 Feed the cable back through the hole as you replace the bracket. When the bracket is located correctly it will sit flush with the back panel without force required. If not 9.4 Disconnect the two slender wires. Undo the two taptite positioned correctly the bracket will sit at an angle. See screws and remove the sensor and the two plastic spac
