ملخص المحتوى في الصفحة رقم 1
595
WELLSBLOOMFIELD,LLC
2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439
telephone: 775-689-5703
fax: 775-689-5976
www.wellsbloomfield.com
OWNERS MANUAL
for
HEATED DISPENSER
MODEL:
HD8799 2½-Gallon
HD8802 5-Gallon
Includes:
Installation
Operation
Use & Care
Servicing Instructions
Model HD8799
Heated Dispenser
IMPORTANT: DO NOT DISCARD THIS MANUAL
This manual is considered to be part of the appliance and is to be given to the OWNER or
MANAGER of the restaurant, o
ملخص المحتوى في الصفحة رقم 2
595 p/n 75982 OpM Heated Dispenser LIMITED WARRANTY STATEMENT Unless otherwise specified, all commercial cooking based upon the limitations in this warranty. Seller’s equipment manufactured by WELLS BLOOMFIELD, LLC is obligation under this warranty is limited to the repair of warranted against defects in materials and workmanship for defects without charge by a Wells Bloomfield factory a period of one year from the date of original installation or authorized
ملخص المحتوى في الصفحة رقم 3
TABLE OF CONTENTS Thank You for purchasing this WARRANTY xi Wells Bloomfield appliance. SPECIFICATIONS 1 FEATURES & OPERATING CONTROLS 2 Proper installation, professional operation PRECAUTIONS & GENERAL INFORMATION 3 and consistent maintenance of this appliance AGENCY LISTING INFORMATION 3 will ensure that it gives you the very best INSTALLATION 4 performance and a long, economical service OPERATION 5 life. CLEANING INSTRUCTIONS 6 TROUBLES
ملخص المحتوى في الصفحة رقم 4
595 p/n 75982 OpM Heated Dispenser FEATURES & OPERATING CONTROLS Fig. 1 Features & Operating Controls 2
ملخص المحتوى في الصفحة رقم 5
PRECAUTIONS AND GENERAL INFORMATION WARNING: Electric Shock Hazard All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock. WARNING Electric Shock Hazard Warmer must be properly grounded to prevent possible shock hazard. Electrical shock will cause death or serious Injury. This appliance is intended for commer
ملخص المحتوى في الصفحة رقم 6
595 p/n 75982 OpM Heated Dispenser INSTALLATION READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION CAUTION: Equipment REFER TO EXPLODED VIEWS PAGE 9 FOR COMPONENT Electrical Damage NAMES/NUMBERS Unpack the unit. Inspect all components for completeness and DO NOT plug in or energize this condition. Ensure that all packing materials have been removed appliance until all Installation from the unit. Instructions are read and followed. Damage to the LEVELING THE UNI
ملخص المحتوى في الصفحة رقم 7
OPERATION PREPARATION CAUTION: Burn Hazard Prior to first use, thoroughly clean warmer (see page 6). Be sure faucet handle is "up" and that drip tray is in place under Exposed surfaces of the faucet. appliance may be HOT to the touch and can cause burns. USE Pour product into warming tank. Using pre-heated product will reduce heat-up time. Model HD8799 utilizes a fixed thermostat to hold product at 140ºF (60ºC). NOTE: Product may continue Mo
ملخص المحتوى في الصفحة رقم 8
595 p/n 75982 OpM Heated Dispenser CLEANING INSTRUCTIONS PROCEDURE: Clean Heated Dispenser CAUTION: Electric Shock PRECAUTIONS: Disconnect dispenser from electric power. Hazard Drain product and allow dispenser to cool. Do not submerge or immerse FREQUENCY: Daily or after draining product from dispenser in water. dispenser CAUTION: TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Burn Hazard Long Handle Bristle Brush This procedure requ
ملخص المحتوى في الصفحة رقم 9
TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Appliance will not heat Not plugged in or circuit breaker Restore electric power to warmer off or tripped Power switch not ON Turn power switch to ON Internal wiring damage Inspect wiring for burnt wires and proper connections . Repair as needed Power cord damaged Replace power cord Thermostat damaged Replace thermostat Power switch damaged Replace power switch "Ready" light does not glow Light or wiring damaged
ملخص المحتوى في الصفحة رقم 10
595 p/n 75982 OpM Heated Dispenser EXPLODED VIEW & PARTS LIST MODEL HD8799 2½-GALLON DISPENSER ITEM PART # DESCRIPTION QTY ITEM PART # DESCRIPTION QTY 1 85865 FAUCET ASSEMBLY 1 6 85853 HEATING ELEMENT 120V 200W 1 1.1* BODY FAUCET 7 85863 THERMOSTAT 140ºF 120V 1 1.2* 8700-25L SEAT CUP 8 50169 SWITCH 250V DPST 1 1.3* ASSEMBLY, HANDLE & PLUNGER 9 65174 GUARD, SWITCH 1 1.4* 8600-27 NUT RETAINING WINGED 10 80017 POWER CORD, 120V NEMA5-15P, 6' 1 1.5* SH
ملخص المحتوى في الصفحة رقم 11
EXPLODED VIEW & PARTS LIST MODEL HD8802 5-GALLON DISPENSER ITEM PART # DESCRIPTION QTY ITEM PART # DESCRIPTION QTY 1 85865 FAUCET ASSEMBLY 1 6 85853 HEATING ELEMENT 120V 200W 1 1.1* BODY FAUCET 7 504682 THERMOSTAT ADJUST 170ºF 120V 1 1.2* 8700-25L SEAT CUP 8 50330 SWITCH 250V DPST 1 1.3* ASSEMBLY, HANDLE & PLUNGER 9 65174 GUARD, SWITCH 1 1.4* 8600-27 NUT RETAINING WINGED 10 80017 POWER CORD, 120V NEMA5-15P, 6' 1 1.5* SHANK, FAUCET W/O SIGHT GLASS 1
ملخص المحتوى في الصفحة رقم 12
595 p/n 75982 OpM Heated Dispenser SERVICING INSTRUCTIONS CAUTION ACCESS - BOTTOM PANEL Electric Shock All internal components are accessible by removing the bottom Hazard panel. Opening the bottom panel will Remove four screws around the bottom of the warmer tank to expose uninsulated electrical free bottom panel from tank assembly. components. Disconnect dispenser from FAUCET electrical power before removing bottom panel.
ملخص المحتوى في الصفحة رقم 13
PARTS & SERVICE IMPORTANT: Use only DESCRIPTION PART NO. factory authorized service parts and replacement DRIP TRAY ASSEMBLY (pk 6) 8855-1 filters. For factory authorized service, or to order factory authorized replacement parts, contact your Wells authorized service agency, or call: Wells Bloomfield, LLC 2 Erik Circle P. O. Box 280 Verdi, NV 89439 Service Parts Dept. phone: (775) 689-5707 fax: (775) 689-5976 Service Parts Department ca
ملخص المحتوى في الصفحة رقم 14
Commercial Food Equipment Service Association Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association SER SERVICE VICE TRAINING TRAINING - - QUALITY QUALITY SER SERVICE VICE Genuine Parts Protect - YOU - All - Ways CUST CUSTOMER OMER SA SATISF TISFACTION ACTION WELLSBLOOMFIELD,LLC 2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439 telephone: 775-689-5703 fax: 775-689-5976 www.wellsbloomfield.com PRINTED IN UNITED STATES OF AMERICA
