ページ1に含まれる内容の要旨
Promaster 310
Owner/Operator Manual
Models
990018
25 HP Kohler
990020
23 HP Kawasaki
ENGLISH
FRANÇAIS
ESPAÑOL
08495100A 1/02
Supercedes 08495100
Printed in USA
ページ2に含まれる内容の要旨
ページ3に含まれる内容の要旨
TABLE OF CONTENTS Controls and Features . . . . . . . . . . . . . . . . . . . . . . . . 2 Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Attachments . . . . . . . . . . . . . . . . . . . . . . . .
ページ4に含まれる内容の要旨
ページ5に含まれる内容の要旨
1 & 2. DANGER ASSEMBLY SAFETY RULES Read the operator’s manual. Read, understand, and follow all safety practices in Owner/Operator Manual before beginning assembly. Failure to follow instructions could result in personal injury and/or damage to unit. OL1801 ALWAYS remove key and/or wire from spark plug before Keep children and others away from unit while assembly. Unintentional engine start up can cause death operating. or serious injury. OL4140 OPERATIONAL SAFETY RULE
ページ6に含まれる内容の要旨
ページ7に含まれる内容の要旨
Replace fuel cap securely and clean up spilled fuel. MAINTENANCE AND SERVICE SAFETY Never fill containers inside a vehicle or on a truck or RULES trailer bed with a plastic liner. Always place containers on ALWAYS block wheels and know all jack stands are the ground away from your vehicle before filling. strong and secure and will hold weight of unit during When practical, remove gas-powered equipment from maintenance. the truck or trailer and refuel it on the ground. If this is
ページ8に含まれる内容の要旨
ASSEMBLY Fill Engine Crankcase WARNING: AVOID INJURY. Read and The unit is shipped without oil in engine crankcase. Refer to engine manual for proper oil type and crankcase understand Assembly, Fuel and Battery Safety capacity. Rules before proceeding. Check Hydraulic Oil Tools required: See Maintenance. • socket wrench, 15/16" Fill Engine Fuel Tank • tire gauge See Filling Fuel Tank in Operation. Unpack Unit Charge Battery Remov
ページ9に含まれる内容の要旨
Throttle Lever Oil Pressure Warning Light Move lever to FAST (1) position to increase If light turns on during operation: 1 engine speed. Move lever to SLOW (2) 1. Stop unit and engine. position to decrease engine speed. 2. Wait five minutes. 2 3. Check engine oil level and fill if OG0601 necessary. OE0340 4. Check for external damage to engine. Choke To test oil pressure warning light, turn ignition key to the Pull choke control out to start a cold engine. run position. Light should turn on.
ページ10に含まれる内容の要旨
5. Fill fuel tank to within 1/2" (1.3 cm) below bottom of MOVING UNIT MANUALLY filler neck. IMPORTANT: Never tow unit. NOTE: Fuel tank capacity is 7.5 gal. (28.4L). 1. Stop engine. 6. Replace fuel cap and tighten. 2. Turn transmission bypass valve counterclockwise 7. Clean up any spilled fuel. 1/4 turn. 3. Disengage parking brake. TO STOP IN AN EMERGENCY 4. Push unit to desired location. Turn ignition key to OFF. 5. Engage parking brake. STARTING THE ENGINE 6. Turn transmission bypass valve clo
ページ11に含まれる内容の要旨
MAINTENANCE Gravely Dealers will provide any service or adjustments CHECKING SAFETY INTERLOCK SYSTEM which may be required to keep your unit operating at Test the safety interlock system before each use. If the peak efficiency. Should engine service be required, system does not function properly, do not operate the unit contact an Gravely dealer or an authorized engine until repairs are made. manufacturer's service center. CAUTION: Safety interlock system failure and WARNING: AVOID INJURY.
ページ12に含まれる内容の要旨
ページ13に含まれる内容の要旨
CHECK ENGINE OIL COOLER CHANGE OIL Check engine oil cooler every 25 hours. Check more Change engine oil every 100 hours. See engine manual often when operating in dirty or dusty conditions. See for detailed instructions. engine manual for detailed instructions. CLEAN COOLING AREAS CLEAN HYDRAULIC OIL COOLER Remove shrouds and clean cooling areas every 100 Blow out hydraulic oil cooler with compressed air every hours. Clean more often in dirty or dusty conditions. See 25 hours of operation to
ページ14に含まれる内容の要旨
ADJUSTING PARKING BRAKE To test parking brake: 4 1 1. Engage parking brake, shut off engine and remove key. 2. Disengage transmission. See Moving Unit Manually 3 5 in Operation. 3. Push unit. If unit can be moved, adjust parking brake. To adjust parking brake: 1. Loosen jam nuts. 2 1. Adjusting Bolt 2. Plate Bolt 3. Notch 4. Neutral Switch 5. Neutral Bracket OF3350 Figure 7 ADJUSTING DIRECTION CONTROL PEDAL 2. Tighten adjustment nuts 1. Remove jam nut from stop bolt and remove stop to elimi
ページ15に含まれる内容の要旨
ページ16に含まれる内容の要旨
STORAGE ACCESSORIES See your authorized Gravely Dealer to add these optional accessories. WARNING: AVOID INJURY. Read and understand Storage Safety Rules in Safety Part No. Description section before proceeding. 78900300 Steering Wheel Kit SHORT TERM 79200300 Mulching Kit - 60" Mower IMPORTANT: NEVER spray unit with water or store unit 79200400 60" Mower Discharge Cover Kit outdoors. 79200500 Mulching Kit - 50" Mower Inspect unit for visible signs of wear, breakage or 79200600 50" Mower Dis
ページ17に含まれる内容の要旨
SERVICE PARTS SPECIFICATIONS Part No. Description Model Number 990018 990020 03621100 Battery Description Name PM 310 PM 310 25 HP 23 HP 21416800 Air Filter - Kohler 21535900 Air Filter - Kawasaki Length 70" (177.8 cm) 21410800 Fuel Filter Height 50.8" (129 cm) 21397200 Engine Oil Filter - Kohler Width 50.3" (127.8 cm) 21535800 Engine Oil Filter - Kawasaki Weight lbs. (kg.) 929 (422) 913 (415) 09246900 Hydraulic Filter Battery 12 Volt 21525900 Spark Plug - Kohler (Qty. 2) Brakes Dynamic Disc -
ページ18に含まれる内容の要旨
2 Year Limited Warranty Ariens Company hereby warrants to the original consumer purchaser that all Gravely Two-Wheel, Professional G, Pro, and ProMaster products Gravely Division of Ariens Company will be free from defects in material and workmanship for a period of 655 West Ryan Street two (2) years from the date of purchase or 1000 hours, whichever P.O. Box 157 comes first. Brillion, WI 54110-0157 Protection Plan 920-756-2141 Ariens Company will repair or replace any part found upon examinatio
ページ19に含まれる内容の要旨
GRAVELY A Division of Ariens Company 655 West Ryan Street P.O. Box 157 Brillion, WI 54110-0157 920-756-2141 Fax 920-756-2407 www.gravely.com
