Summary of the content on the page No. 1
Lenovo IdeaPad P580/
P585/N580/N581/
N585/N586
Hardware
Maintenance
Manual
Summary of the content on the page No. 2
Note: Before using this information and the product it supports, be sure to read the general information under “Notices” on page 98. First Edition (April 2012) © Copyright Lenovo 2012. All rights reserved. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No. GS-35F-05925. © 2012 Lenovo
Summary of the content on the page No. 3
Contents About this manual........................................iv FRU replacement notices.................................. 31 Screw notices ................................................ 31 Safety information.........................................1 Removing and replacing an FRU .................... 32 General safety ...................................................... 2 1010 Battery pack......................................... 33 Electrical safety .....................................
Summary of the content on the page No. 4
About this manual This manual contains service and reference information for the following Lenovo product: Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Use this manual to troubleshoot problems. The manual is divided into the following sections: � The common sections provide general information, guidelines, and safety information required for servicing computers. � The product-specific section includes service, reference, and product-specific parts information. Important: This manual is intend
Summary of the content on the page No. 5
Safety information Safety information This chapter presents the following safety information that you need to get familiar with before you service a Lenovo IdeaPad computer: � “General safety” on page 2 � “Electrical safety” on page 3 � “Safety inspection guide” on page 5 � “Handling devices that are sensitive to electrostatic discharge” on page 6 � “Grounding requirements” on page 6 � “Safety notices: multilingual translations” on page 7 � “Laser compliance statement” on page 14 1
Summary of the content on the page No. 6
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual General safety Follow these rules below to ensure general safety: � Observe a good housekeeping in the area where the machines are put during and after the maintenance. � When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenly or twist when you attempt to lift it. 4. Lift it b
Summary of the content on the page No. 7
Safety information Electrical safety Observe the following rules when working on electrical equipments. Important: Use only approved tools and test equipments. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have rubber floor mats near their machines that contain small conductive fibers to decrease electrostatic discharges. Do not use such kind of mat to protect yourself from electrical shock. � F
Summary of the content on the page No. 8
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual � Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors, nongrounded power extension cables, power surges, and missing safety grounds. � Do not touch live electrical circuits with the reflective surface of a plastic dental mirror. The surface is conductive; such touching can cause personal injury and machine damage. � Do not service the following parts with the power o
Summary of the content on the page No. 9
Safety information Safety inspection guide The purpose of this inspection guide is to assist you in identifying potential unsafe conditions. As each machine was designed and built, required safety items were installed to protect users and service personnel from injury. This guide addresses only those items. You should use good judgment to identify potential safety hazards due to attachment of non-Lenovo features or options not covered by this inspection guide. If any unsafe conditions are p
Summary of the content on the page No. 10
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same
Summary of the content on the page No. 11
Safety information Safety notices: multilingual translations The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer. Verify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. Avant
Summary of the content on the page No. 12
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery. Certaines batteries de
Summary of the content on the page No. 13
Safety information Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. La batterie contient du nickel. Ne la démontez pas, ne l’exposez ni au feu ni à l’eau.
Summary of the content on the page No. 14
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition o
Summary of the content on the page No. 15
Safety information Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide, rincez-les abondamment pendant au moins quinze minutes. Consultez un médecin si des sympt
Summary of the content on the page No. 16
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt, nicht entfernen. Per evitare scosse elettriche, non r
Summary of the content on the page No. 17
Safety information Safety notice 8 DANGER Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface. Die Stromzufuhr muß abgeschaltet, alle Stromkabel aus der St
Summary of the content on the page No. 18
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Laser compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations (DHHS 21 CFR) Subchapter J for Class
Summary of the content on the page No. 19
Safety information A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio laser ao abrir. Não olhe fixo no feixe de luz, não olhe diretamente por meio de instrumentos óticos e evite exposição direta com o fe
Summary of the content on the page No. 20
Lenovo IdeaPad P580/P585/N580/N581/N585/N586 Hardware Maintenance Manual Important service information This chapter presents the following important service information: � “Strategy for replacing FRUs” on page 16 – “Strategy for replacing a hard disk drive” on page 17 – “Important notice for replacing a system board” on page 17 � “Important information about replacing RoHS compliant FRUs” on page 18 Important: BIOS and device driver fixes are customer-installable. The BIOS and device drivers a
