Summary of the content on the page No. 1
Summary of the content on the page No. 2
WARNING THE PROCEDURES IN THIS MANUAL SHOULD ONLY BE PERFORMED BY QUALIFIED TECHNICIAN. DO NOT SERVICE OR OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL AND THE OWNERS MANUAL SUPPLIED WITH THE WHEELCHAIR. IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS, AND INSTRUCTIONS, CONTACT INVACARE TECHNICAL SUPPORT BEFORE ATTEMPTING TO SERVICE OR OPERATE THIS EQUIPMENT - OTHERWISE INJURY OR DAMAGE MAY RESULT. SPECIAL NOTES WARNING/CAUTION notices
Summary of the content on the page No. 3
TABLE OF CONTENTS
! "#$ %&$"'
('
' %) *
'%
+,+-.
%
/ %%
/ %
%
/'
&*
' %)
Summary of the content on the page No. 4
TABLE OF CONTENTS (Continued)
$
* " "
Summary of the content on the page No. 5
TABLE OF CONTENTS (Continued)
"$
"*!
'
* '
Summary of the content on the page No. 6
SPECIFICATIONS
✪ &,- (!./
&,- (!./
!" # $
%%%
Summary of the content on the page No. 7
SPECIFICATIONS (Continued)
s
Summary of the content on the page No. 8
REPAIR OR SERVICE INFORMATION Set-up of the Electronic Control Unit is to be performed ONLY by individuals certified by Invacare. The final tuning adjustments of the controller may affect other activities of the wheelchair. Damage to the equipment could occur under these circumstances. If non-certified individuals perform any work on these units, the warranty
Summary of the content on the page No. 9
WARNING/CAUTION LABEL LOCATION - RWD MODELS
"
# SUSPENSION ARM " $ %
& USED WITH CONVENTIONAL GROUP 24 BATTERIES GROUP 22 BATTERIES MOTOR/GEARBOX ASSEMBLY SUSPENSION ARM USED ONE (1) CONNECTOR BATTERY WITH GEARLESS/BRUSHLESS BOX WIRING HARNESS MOTOR 12 ( $ 66
67
88 12
Summary of the content on the page No. 10
WARNING/CAUTION LABEL LOCATION MWD MODELS
* ! %
+,-&..&//01
! "#!
! '
() FWD MODELS BATTERY BOX WIRING HARNESS
Summary of the content on the page No. 11
7 !
* ! ! ! # , ' '( )" ( *! % + $88$960 $ . 8 : !#$%! #;"< %
Summary of the content on the page No. 12
WARNING When reading a hydrometer, DO NOT al- low any liquid to come in contact with your eyes or skin. It is a form of acid and
can cause serious burns, and in some
cases, blindness. If you do get battery acid !!
"
on you, flush the exposed areas with cool water IMMEDIATELY. If the acid comes into contact with eyes or causes serious burns, get medical help IMMEDIATELY. FIGURE 2 - US
Summary of the content on the page No. 13
"# 3
23
"!
FIGURE 4 - MOTOR BRUSH INSPECTION ELECTRO-MECHANICAL PARKING
BRAKE TESTING (FIGURE 5) #
!
#
3
"!
3
"!
$ !
$ !%
& * .
#1)*
0**0
>/0 )5 FIGURE 3 - MOTOR TESTING )50**0
)* / 0< .)*9 & 5)9) /./ )
5 Ω MOT
Summary of the content on the page No. 14
HARDWARE TORQUE SPECIFICATIONS STANDARD SEAT FRAME 4
5 6.
47!
5 47! 8+
5 8+
5 *+6 44
5 *+6 44
5 *+6 44
5 *+6 44
5 *+6 4
5 #!! ## 9
44
5 #!! ## !# % 9
Summary of the content on the page No. 15
HARDWARE TORQUE SPECIFICATIONS *CAPTAINS VAN SEAT *ADJUSTABLE SEAT FRAME
5
5 *+6' *+6'
5
8+' 7!
5 8+
5 *+6'
5 *+6
5 *+6'
5 *+6 4
5 #!! (
5 #!!
$
Summary of the content on the page No. 16
REAR WHEEL DRIVE BASE FRAME HARDWARE TORQUE SPECIFICATIONS
5 *6. 7!
5 *6.
5 *.:. REAR OF WHEELCHAIR 7!
5 8+
5 *6. 7! FRONT OF
5 WHEELCHAIR 8+
5*:.
'
5
58+
Summary of the content on the page No. 17
MID-WHEEL DRIVE BASE FRAME HARDWARE TORQUE SPECIFICATIONS
FRONT OF
WHEELCHAIR
REAR OF WHEELCHAIR
Summary of the content on the page No. 18
FRONT-WHEEL DRIVE BASE FRAME HARDWARE TORQUE SPECIFICATIONS REAR OF WHEELCHAIR
Summary of the content on the page No. 19
REPLACING CAPTAINS VAN SEAT
ARMREST PLATE (FIGURE 2)
!" !"
" #$
% &
% WARNING
'% After ANY adjustments, repair or service () *+",-*. and BEFORE use, make sure that all attach- (/0)*1/ +*)0*",/2
Summary of the content on the page No. 20
REPLACING BACK UPHOLSTERY
(FIGURE 2) "
" ! " #$
#$% & ",/0* ",-6(.72",-3 ")8*+9*.(/0/
)7+(14( : ;<5 WARNING "
' #$
After ANY adjustments, repair or service and BE- % '
