Summary of the content on the page No. 1
OWNER’S MANUAL
™
P.O. Box 108
Northumberland, PA 17857
1-800-STRONG-9
1-800-787-6649
2/15/06
CAUTION:
More than one GFCI
used on the electrical
circuit will render this
spa inoperable.
This spa must be on a
dedicated circuit.
Summary of the content on the page No. 2
Table of Contents Introduction ................................................................................................................................. 1 Safety Instructions...................................................................................................................... 2 Installation Instructions............................................................................................................... 3 Electrical - General......................................
Summary of the content on the page No. 3
Introduction Congratulations on your purchase of the finest, Rotational Molded resin whirlpool spa on the market today. We at Strong Pools & Spas are excited to assist your family in "Creating a Lifestyle that Lasts a Lifetime". With proper care, operation and maintenance, your spa will provide your family many years of comfort and pleasure. Please take time to read all the instructions before you install your Strong Pools & Spa, "Rio" spa. This manual explains safety precautions, installatio
Summary of the content on the page No. 4
Important Safety Instructions WARNING People with infectious diseases should not use a spa. The use of alcohol, drugs or medication before or during spa use may lead to uncon- sciousness with the possibility of drowning. Do Not use the spa immediately following strenuous exercise. Persons suffering from heart disease, diabetes, high or low blood pressure or any other serious illness and pregnant women should consult with their physician before using the spa. Excessive water temperature can be da
Summary of the content on the page No. 5
Installation Instructions Spa Location: Improper installation may result in equipment damage and will void the warranty. Your spa must be placed on a flat, level surface. The space you choose to install your spa is a very important decision, you should consider all of the listed suggestions. Check your local code office for understanding of building, fencing, gates, electrical, plumbing and enclosure required codes. A location should be selected to compliment your lifestyle, the view from your
Summary of the content on the page No. 6
Electrical - General Instructions It is recommended that a licensed electrician install the power to your spa, in accordance with the National Electric Code or any local electrical codes in effect at the time of installation. The circuit breaker must be dedicated and cannot be shared with any other appliances. It should be labeled and easily accessible to users. DO NOT USE EXTENSION OR PLUG- TYPE CORDS OF ANY KIND. The use of a shut-off box near the spa is recommended. Metal surfaces within 5
Summary of the content on the page No. 7
Control Panel Identification JETS 1 Press the Jets1 key to activate the pump. The system will run for 30 minutes, at which time the system will automatically shut off, unless done so manually prior to 30 minute period. AUX The auxiliary key will activate an optional second pump or blower. Auxiliary key is also used in conjunction with other keys to change settings. LIGHT Press Light to turn the light on/off. The Antigua Spa is equipped with an LED Multi- Color Light. The colors will cycle as you
Summary of the content on the page No. 8
Startup Preparations Before starting up your spa, make sure you have read and understand all of the previous instructions. Make sure the spa has been installed correctly, including the electrical wiring connections as specified, motor key pump • Spa's water is at the correct level • Pump is primed To prime the air from the system, simply turn open the key type screw at the right end of the motor/pump. The key should be turned just enough to allow the excess air in the water lines to escape. W
Summary of the content on the page No. 9
Changing Filter Cycles FILTRATION Proper filtration is an important key to maintaining the clarity of your spa's water. The filter system is designed for unsurpassed effectiveness at removing debris and suspensions from the water anytime the water is circulating. Your control panel is set to filter for two hours every twelve hours. A two speed pump is sup- plied with your spa that provides filtration on low speed, the low speed will shut off if the tem- perature creeps more than 2 degrees abov
Summary of the content on the page No. 10
Troubleshooting *indicates qualified service technician recommended Display flashes “hot” (OVERHEAT) • This indicates that the heater body is over 112ºF. The system should be shut down in this state and will re-start automatically when the water cools below 112ºF. Display flashes “HL” (HIGH LIMIT) • This indicates that either the heater or the spa has reached 118ºF or higher. The system will not re-start automatically. To re-start the system, the water temperature must be below 112ºF and the he
Summary of the content on the page No. 11
Spa Maintenance The maintenance and care of your spa is simple and easy to carry out, and if performed regu- larly as scheduled, problems will be minimal. It is important that the following procedures be read through and carried out on a regular basis for the best, long term, overall performance of your spa. The filtering cycle of your spa should be operated at least two hours or more a day (whether or not the heater is heating) to remove impurities and to prevent disposition of contaminants i
Summary of the content on the page No. 12
Spa Maintenance CONCENTRATED CHLORINATING GRANULES - The minimum chlorine level in the spa should be at least 2PPM (parts per million). Chlorine level should be tested frequently and the chemical added to maintain a safe level of 2PPM. This type of chemical can be added in quantities of 0.5 ounce per 500 gallons of spa water. Check the chlorine level at least seven hours or more after adding to determine the full effect of the added chemical. Liquid chlorine is not recommended. ORGANIC POLYME
Summary of the content on the page No. 13
n e p o o t e s i w k c o l c r e t n u o c n r u T Jets, Valves, Injection and Suction Jet 2” Bottom Suction Top Air Control Valve (Air Control Valve should be turned off when spa is not in use. The spa will heat up faster.) 11
Summary of the content on the page No. 14
WARRANTIES LIFETIME ON THE SHELL The Rio Spa is forge-cast from authentic granite resin and is warranted for the life of the spa to the original owner. ONE YEAR ON CONTROL EQUIPMENT AND PLUMBING The control equipment (power pack, heater, pump/motor) is warranted against defects in materials and/or workmanship for a period of one year on parts. The plumbing (including fittings) is warranted against leaking due to defects in materials and/or workmanship for a period of one (1) year on parts. Ozone
Summary of the content on the page No. 15
Points on Spa Safety for Strong Spas Spa Owners SAFETY PRECAUTIONS / DANGER - RISK OF INJURY 1. Please use the Hot Tub when others are present. 2. Children should be supervised at all times. 3. To avoid the risk of drowning, keep the filter clean and unclogged. Do not remove the suction drain cover. Do not modify the suction or filtration systems. 4. Exercise caution when entering or leaving the Hot Tub. When changing positions, be sure of your footing before applying your full weight as water
Summary of the content on the page No. 16
RETAIN THIS BOOKLET FOR FUTURE REFERENCE: FOR ANY MISSING PARTS, PROBLEMS OR QUESTIONS CALL: MONDAY THROUGH FRIDAY 8:30 AM - 5:00 PM E.S.T. (570) 275-2700 • QUANTITY AND TYPE OF PARTS • GIVE YOUR NAME • REASON FOR REQUEST • TELEPHONE NUMBER (AREA CODE) A. DAMAGED • NAME OF SPA B. DEFECTIVE • NAME OF MODEL PLACE STAMP HERE STRONG POOLS & SPAS 3204 Point Township Drive (Rte. 11) P.O. Box 108 Northumberland PA 17857
