Summary of the content on the page No. 1
LP GAS GRILL OWNER'S MANUAL
GUÍA DEL PROPIETARIO DEL ASADOR DE GAS LICUADO DE PROPANO - PG 25
GUIDE DE L’UTILISATEUR DU GRILL À GAZ PL - PG 44
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 4
#2020805
Customer Service: 1-800-382-2637
YOU MUST READ THIS OWNER’S GUIDE
NOTICE TO INSTALLER: These instructions
BEFORE OPERATING YOUR GAS GRILL
must be left with the owner and the owner
should keep them for future use.
DANGER
THIS GAS APPLIANCE IS DESIGNED FOR
If you smell gas:
1. Shut off gas to the appl
Summary of the content on the page No. 2
DANGERS AND W DANGERS AND WARNINGS ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING Do not lift the barbecue using the control panel as a handle. Lifting by the control panel can damage gas handling and electrical components. Damage to gas handling and electrical components can result in serious bodily injury or death and damag
Summary of the content on the page No. 3
I IMPOR MPORT TANT SAFEGUARDS ANT SAFEGUARDS Read all instructions. WARNING: Use only outdoors, do not expose to rain. This is to prevent electric shock which can cause serious bodily injury or death. WARNING: Disconnect appliance from supply circuit before performing maintenance and cleaning. WARNING: For protection against risk of electric shock, connect to properly grounded outlets only. WARNING: For protection against risk of electric shock, keep extension cord connection dry and
Summary of the content on the page No. 4
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful while handling any parts during assembly. IT IS STRONGLY RECOMMENDED THAT HANDS BE PROTECTED WITH A PAIR OF WORK GLOVES. WARNING: Do not lift the barbecue using the control
Summary of the content on the page No. 5
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE TOOLS NEEDED: HERRAMIENTAS REQUERIDAS: OUTILS NECESSAIRES: 2 11mm (7/16”) 1 3 1 1 2 5 1 1 1 1 8 1 1 8 1 1 5 2 1 5 3 2 1 1 2 NOTE: The bolts to install the stainless steel side shelf are threaded into the grill cart on the right side of the grill. Remove the bolts and re-install 3 when attaching the stainless steel side shelf. OBSERVACIÓN: Los tornillos utilizados para armar las mesas de acero inoxidables están atornillados
Summary of the content on the page No. 6
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE CAUTION: Always remove the 4 warming rack when using the rotisserie. OBSERVACIÓN: Siempre quite la rejilla de calentamiento cuando esté usando el sistema rotativo. REMARQUE: Enlevez toujours la grille de chauffage lors de l’utilisation de la rôtisserie. 5 6 WARNING: The rotisserie motor must be stored indoors when not in use. DO NOT leave it mounted to the grill. PRECAUCIÓN: El motor deber ser almacenado dentro
Summary of the content on the page No. 7
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 7 8 9 10 11 12 7
Summary of the content on the page No. 8
W WARRANTY ARRANTY, GARANTÍA, GARANTIE , GARANTÍA, GARANTIE This Limited Warranty does not cover failures or operating diffi culties due to accident, abuse, misuse, ® alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane Stain- maintenance, including but not limited to damage caused by insects within burner tubes, as described less Series gas grill that it will be free
Summary of the content on the page No. 9
SAFETY INFORMATION IMPORTANT We urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation of your new ® Ducane Gas Grill. We also advise you to keep this manual for future reference. WARNING: Your grill has been designed to operate using WARNING: Do not store a spare LP-gas cylinder under or near this appliance; Never fill the cylinder beyond 80 percent only the gas specified on the rating
Summary of the content on the page No. 10
C CONNECTION ONNECTION Liquid Propane Gas Grills Liquid Propane Gas Grills Handling Liquid Propane Gas Type of Gas Propane gas should be handled and stored with care. We suggest asking your propane � Your LP grill is factory built to operate using liquid propane only. Never attempt to gas dealer, when having your tank fi lled, for a short course in handling, care and operate your grill on gases other than the type specifi ed on the grill rating plate. storage of propane gas tanks. Most deale
Summary of the content on the page No. 11
C CONNECTION ONNECTION Liquid Propane Gas Grills Liquid Propane Gas Grills Temperature-Activated Shut-Off IMPORTANT The large plastic nut on the regulator assembly is designed in coordination with When connecting or replacing any gas pipe or fi ttings, all joints must be sealed with a check valve in the cylinder valve to shut off the fl ow of gas when exposed to leak-proof sealing compound approved for use with natural and propane gases. After temperatures between 240-300ºF. making connection
Summary of the content on the page No. 12
NORMAL OPERA NORMAL OPERATION TION Check your parts list or your authorized dealer for the proper replacement hose as- ® WARNING: Your Ducane grill was not designed to operate sembly. It will be necessary to open the doors to fully inspect the hose. with the Rotisserie Burner and the Main Burner(s) on at the DANGER: Make sure that the lid is in the full open postion same time. Failure to follow this warning will lead to an over- any time you attempt to light your grill. Failure to open th
Summary of the content on the page No. 13
N NORMAL OPERA ORMAL OPERATION TION Preheating Grill WARNING: Please remember that this is an outdoor gas It is extremely important that your grill be up to temperature before you begin using cooking appliance. Many areas of the grill generate extreme it. After lighting, close the lid and preheat the grill on “high” for 10 minutes. This preheating will ensure that the cooking grid is hot enough for proper grilling. heat. We have taken every precaution to protect you from the contact areas
Summary of the content on the page No. 14
N R U T O T H S U P N NORMAL OPERA ORMAL OPERATION TION Main Burner Snap Ignition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to OFF / ARRÊTÉ / APAGADO “START/HI”. This will ignite each individual burner. 1 4 Follow the simple steps listed below to light the Main Burner(s) of your grill: 1. Open the lid and make sure that all burners are in the “
Summary of the content on the page No. 15
NORMAL OPERA NORMAL OPERATION TION Side Burner Snap Ignition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to “START/HI”. This will ignite each individual burner. 1 5 1 5 Follow the simple steps listed below to light the Side Burner (SB) of your grill: DANGER: Failure to open the lid while igniting the side 4 4 burner, or not waiting 5 minutes to al
Summary of the content on the page No. 16
N R U T O T H S U P NORMAL OPERA NORMAL OPERATION TION 4. Push the ROTISSERIE BURNER control knob in and turn to “HIGH”. 5) Push in the electronic ignition button. Continue to hold the ROTISSERIE OFF / ARRÊTÉ / APAGADO BURNER control knob in until 20 seconds after the burner has ignited. Then release the ROTISSERIE BURNER control knob. 1 6 6. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat ignition step numbers 3 and 4. 7. Verify Rotisserie Burner has igni
Summary of the content on the page No. 17
NORMAL OPERA NORMAL OPERATION TION Using the Rotisserie WARNING: Setup the rotisserie with food before lighting Rotisserie Burner. Operating the Rotisserie WARNINGS: Read all instructions before using your rotisserie. 1. Remove rotisserie shaft from grill. 2. Loosen and remove right side bearing, the counterbalance and right side spit fork. This rotisserie is for outdoor use only. 3. Push the rotisserie shaft through the center of the food. Remove motor and store in a dry place when not
Summary of the content on the page No. 18
NORMAL OPERA NORMAL OPERATION TION Cooking with the Rotisserie � When using the rotisserie, the lid must be closed except when basting. � Meats (except poultry and ground meat) should be brought to room temperature before cooking. (20 to 30 minutes should be adequate for most foods. If frozen defrost completely before cooking.) � Tie meat or poultry with a string, if necessary, to make the shape as uniform as possible before putting it on the spit. � Remove cooking grates and warming rac
Summary of the content on the page No. 19
H HELPFUL HINTS ELPFUL HINTS Flare Ups When Using the Rotisserie Any time you cook fatty foods over an open fl ame, you can expect fl are ups. Flare ups WARNING: The rotisserie motor must be stored indoors when are caused by the fl ash which occurs when the natural juices fall on the heat distribu- tion plates. Controlled fl are ups give foods their delicious outdoor fl avor and appear- not in use. Do not leave it mounted on the grill. ance. Excessive fl are ups may occur when your grill is not le
Summary of the content on the page No. 20
TROUBLESHOOTING TROUBLESHOOTING PROBLEM CHECK and CURE IMPORTANT IGNITION SYSTEM Be sure that there is gas fl ow to the burners by attempting to match light your burners. If match lighting is successful, the problem lies somewhere in the ignition system and will need to be checked. MAIN GRILLING BURNERS AND If the main burner(s) still fails to ignite, make ROTISSERIE BURNER sure that there is gas fl owing to the burner(s) CAUTION: Always turn the gas supply off at the tank before by attempt
