Summary of the content on the page No. 1
Vertical Electric Smoker
Product Guide
Model 11201677
IMPORTANT: Fill out the product record information below.
Serial Number
See rating label on unit for serial number.
Date Purchased
Use only with GFI (Ground Fault Interrupter) protected circuit.
FOR OUTDOOR USE ONLY
WARNING: WARNING:
Do not use 16 or 18 gauge extension cords. Damage to Failure to follow all manufacturer’s instructions could result in
household wiring and/or fire could result. serious personal injury and/or proper
Summary of the content on the page No. 2
TABLE OF CONTENTS IMPORTANT SAFEGUARDS Product Record Information . . . . . . . . . . . . . . . . . 1 When using electrical appliances, basic safety Important Safeguards. . . . . . . . . . . . . . . . . . . . . . 2 precautions should always be followed including the Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 2 following: Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 READ ALL INSTRUCTIONS General Safety . . . . . . . . . . . . . . . . . . . . . .
Summary of the content on the page No. 3
24” OR 2FT. (.61 M) Use and Care of Your Smoker 10. Store smoker in weather protected area or under smoker cover when not in use and electric controller indoors when not in use. WARNING 11. Use only accessory attachments recommended by manufacturer. Use care when operating your smoker. Be sure you read and 12. It is the responsibility of the assembler/owner to assemble, understand all the information and safeguards in this product install and maintain smoker. guide before operating th
Summary of the content on the page No. 4
• Store smoker in weather protected area or under smoker cover Turn smoker off: when not in use. • Turn controller knob fully counterclockwise to OFF position. • Clean cooking grates regularly with warm soapy water or a • Unplug cord from outlet. baking soda and water solution. Use non-abrasive scouring • Remove controller from smoker and store indoors. powder for stubborn stains. If a bristle brush is used to clean Cleaning electrical controller and heating any of the smoker cooking surfa
Summary of the content on the page No. 5
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid by the consumer for re
Summary of the content on the page No. 6
PARTS LIST Make sure you have all items listed under PARTS LIST and HARDWARE BAG CONTENTS before you begin the assembly process. Key Qty Description Three chrome plated steel SMOKE CHAMBER ASSEMBLY A 1 cooking grates DOOR B 1 S/ DOOR HINGE C 2 // DOOR HANDLE D 1 TEMPERATURE GAUGE E 1 LEG F 4 GREASE CUP ASSEMBLY G 1 S/ // WATER PAN H 1 WOOD CHIP BOX I 1 WOOD CHIP BOX LID J 1 WIRE RACK, SMOKER & WATER PAN K 1 WIRE SUPPORT, COOKING GRATE L 8 COOKING GRATE M 3 SIDE HANDLE N 2 Water Pan CONTROLLE
Summary of the content on the page No. 7
N C E E M N A B D Q J P I G H F O L K Page 7 Page 7
Summary of the content on the page No. 8
12 1/4-20 x 5/8" Bolts (2) 10-24 x 1/2" Bolts 2 10-24 x 1/2" Bolts 4 10-24 x 1 1/4" Bolts (12) 1/4-20 x 5/8" Bolts (4) 10-24 x 1 1/4" Bolts Page 8
Summary of the content on the page No. 9
1/4-20 X 5/8” Install air vent tube by lining up the holes with the back panel holes on the inside of the smoker cabinet. Insert two 10-24x1 1/4" bolts from the outside of the cabinet. From inside the cabinet, thread 10-24 flange nuts onto bolts. Securely tighten nuts. Step 3 Attach side handles by using two 1/4-20 X 5/8" bolts through handle loops. Securely tighten. Repeat for other handle. Page 9
Summary of the content on the page No. 10
Step 4 10-24 x 1/2" Step 5 Soportes Laterales para Rejillas Page 10
Summary of the content on the page No. 11
Wood chip box and water pan rack Step 6 Wood chip box lid Water Pan Wood chip box Step 7 Page 11
Summary of the content on the page No. 12
Step 8 Insert the cooking grates into rack supports Cooking Grates as desired. Make sure all cooking grates are level. Step 9 Bolt 10-24x1 1/4" Heat Resistant Washer Washer Page 12
Summary of the content on the page No. 13
Step 10 Insert the temperature gauge through the mounting hole in the front of the door. Thread wingnut onto the temperature gauge stem from inside the door panel and tighten it firmly. Step 11 Page 13
Summary of the content on the page No. 14
Step 12 Page 14
Summary of the content on the page No. 15
Troubleshooting Problem Possible Cause Prevention/Solution smoker not heating • Controller turned to OFF position. • Turn controller knob to setting HIGH. • Be sure controller is fully seated in heating element bracket and smoker is • No power. properly plugged into outlet. • Check for tripped household circuit breakers or GFI (Ground Fault Interrupter). Reset or replace if necessary. • Try a known, working appliance in the outlet. • Try a different outlet, preferably on a different circuit. •
Summary of the content on the page No. 16
Warranty Registration Department P.O. Box 1240 Columbus, Ga 31902-1240 REGTEMP REV02 Page 16
