ملخص المحتوى في الصفحة رقم 1
Traulsen & Co., Inc.
Quality Refrigeration
OWNER’S MANUAL
Instructions for the installation, operation,
and maintenance of all VPS* Pizza Prep Table Models:
*U.S. Patent No. 6,089,036
VPS48S
VPS54S
VPS66S
VPS72S
VPS90S
VPS114S
This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated
cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial refrig-
eration since 1938. We thank you for your choice and
ملخص المحتوى في الصفحة رقم 2
TABLE OF CONTENTS I. The Serial Tag Page 1 V. Care & Maintenance II. Receipt Inspection Page 2 a-Cleaning The Condenser Page 4 III. Installation b-Hinge Replacement Page 4 a-Location Page 2 c-Replacing The Gaskets Page 4 b-Packaging Page 2 d-Cleaning The Exterior Page 5 c-Installing Casters Page 2 e-Cleaning The Interior Page 5 d-Installing Legs Page 2 VI. Misc. Operations e-Cord & Plug Page 2 a-Replacing The Shelves Page 5 f-Power Supply Page 2 b-Cleaning The Raised Rail Page 5 g-Clearance Page
ملخص المحتوى في الصفحة رقم 3
II. RECEIPT INSPECTION III. INSTALLATION (continued) All Traulsen products are factory tested for perfor- III. c - INSTALLING CASTERS (cont’d): mance and are free from defects when shipped. The or compartment, for proper support. See drawing on utmost care has been taken in crating this product to page 6 for correct placement. protect against damage in transit. All legs or casters are boxed inside to prevent damage. III. d - INSTALLING LEGS: Optional legs are installed in the same manner as c
ملخص المحتوى في الصفحة رقم 4
IV. OPERATION/START-UP IV. a - MASTER SWITCH: IV. h - ADJUSTING THE TEMPERATURE (cont’d): The master switch is located at main electrical box the bottom (see figure 2). To disable the keypad, slide behind the louver panel and should be in the OFF po- the switch to left (LOCK) position. To enable the key- sition. pad, slide the switch to the right (UNLOCK) position. Please note that the control is shipped from the fac- IV. b - POWER SUPPLY: tory in the locked position. Connect the power supply
ملخص المحتوى في الصفحة رقم 5
IV. OPERATION (continued) V. CARE & MAINTENANCE IV. h - ADJUSTING THE TEMPERATURE (cont’d): V. a - CLEANING THE CONDENSER: The proper control settings for the VPS models are: The most important thing you can do to insure a long, reliable service life for your Traulsen is to regularly clean STEP ANNUNCIATOR DESCRIPTION DISPLAY the condenser coil. 1F or C Fahrenheit or Celsius Scale The condensing unit requires regularly scheduled clean- ing to keep the finned condenser clean of lint and dust 2
ملخص المحتوى في الصفحة رقم 6
V. CARE & MAINTENANCE (cont’d) V. d - CLEANING THE EXTERIOR: VII. a - SERVICE INFORMATION (cont’d): Exterior stainless steel should be cleaned with warm your Traulsen unit. If you cannot locate this, you may water, mild soap and a soft cloth. Apply with a damp- also obtain the name of a service agent from the Tech ened cloth and wipe in the direction of the metal grain. Service page of our website: www.traulsen.com. Avoid the use of strong detergents and gritty, abra- If service is not satisfa
ملخص المحتوى في الصفحة رقم 7
VIII. PARTS LIST VPS48S & VPS54S KEY DESCRIPTION PART NUMBER 1 LOUVER 6132004 2 8” CASTER ASS’Y W/O BRAKES 409-010-310-000 3 8” CASTER ASS’Y W/BRAKES 409-010-311-000 4 DOOR HANDLE 6051000 5 LCD THERMOMETER (OPTIONAL) 403-130-079-600 6 CORD & PLUG (NOT SHOWN) 401-130-079-600 7 RH DOOR ASS’Y (INCLUDING GASKET & HARDWARE) VPS-18R 8 LH DOOR ASS’Y (INCLUDING GASKET & HARDWARE) VPS-18L 9 DOOR GASKET (16-1/8” x 22-1/8”) 418-130-105-200 10 DOOR HINGE 409-130-056-200 11 DOOR HINGE SPRING KIT 409-130-056-
ملخص المحتوى في الصفحة رقم 8
VIII. PARTS LIST (CONTINUED) VPS66S, VPS72S, VPS90S & VPS114S KEY DESCRIPTION PART NUMBER 1 LOUVER 6132004 2 LOUVER (VPS72S) 6132005 3 8” CASTER ASS’Y W/O BRAKES 409-010-310-000 4 8” CASTER ASS’Y W/BRAKES 409-010-311-000 5 DOOR HANDLE 6051000 6 LCD THERMOMETER (OPTIONAL) 403-130-079-600 7 CORD & PLUG (NOT SHOWN) 401-010-304-000 8 DOOR GASKET (22-1/8” x 22-1/8”) 418-130-105-300 9 DOOR HINGE 409-130-056-200 10 DOOR HINGE SPRING KIT 409-130-056-300 11 LIFT LID (VPS66S) 056-246 12 LIFT LID (VPS72S)
ملخص المحتوى في الصفحة رقم 9
IX. OPERATIONAL GUIDELINES Please follow these simple guidelines for proper VPS operation: • The defrost timer must be set to the proper time of day. If the unit is shut down at any time, the clock must be reset. • Rail inserts must be in place (under pans) before loading any pans. • For best results in holding product temperatures, stainless steel pans should be used in the rail, rather than plastic pans. • The rail area must have a full complement of pans in place at all times. This is true
ملخص المحتوى في الصفحة رقم 10
X. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE REMEDY 1.Condensing unit fails to start. a. Check if line has been disconnected. b. Check T-Stat setting and operation. c. Check switch behind louvers. 2. Condensing unit operates for a. Shortage of refrigerant, locate and repair prolonged periods or continuously. leak, evacuate and recharge per the manufacturer’s requirements. b. Dirty condenser or filter. Clean properly. c. Are doors closing properly? d. Evaporator c
ملخص المحتوى في الصفحة رقم 11
XI. PAN CAPACITIES XI. a - THE VPS SYSTEM: The Venturi Plenum System (VPS) pizza prep tables are designed to keep all foods fresh, at an even tem- Third Size Pan Capacity Full Size Pan Capacity perature, without freezing. The VPS system accom- Std. Rail Models (w/o adapter bars) (w/o adapter bars) plishes this task by surrounding product with cold air, top to bottom, and on all sides without drying the ingre- VPS48S 6 2 dients. This extends shelf life, eliminating the need to VPS54S
ملخص المحتوى في الصفحة رقم 12
XI. PLAN & ELEVATIONS VPS48S VPS54S VPS66S -11-
ملخص المحتوى في الصفحة رقم 13
XI. PLAN & ELEVATIONS (cont’d) VPS72S VPS90S VPS114S (drawings not to scale with those of other models) -12-
ملخص المحتوى في الصفحة رقم 14
XIII. WARRANTY INFORMATION STANDARD DOMESTIC WARRANTY TRAULSEN & CO., INC. warrants new equipment to the original purchaser, when installed within the United States against defective material and workmanship for one (1) year from the date of original installation, not to exceed 15 months from date of shipment. Under this warranty, TRAULSEN & CO., INC. will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty. The compressor p
ملخص المحتوى في الصفحة رقم 15
XIV. INDEX A N Adapter Bars 11 Adjusting The Temperature 3, 4 O B P Pallet - Shipping 2 C Pans 11 Calibration - Mode 4 Power Supply 2 Casters 2 Celsius 3, 4 R Cleaning - The Condenser 4 Rail Inserts 9 Cleaning - The Exterior 5 Rail - Refrigerated 5 Cleaning - The Interior 5 Refrigerant 2 Clearance 2 Return Authorization 2 Compressor - Oil 2 Condensing Unit 3, 4 S Control - Electronic 3 Serial Tag 1 Cord & Plug 2 Setpoint - Setting 3 Shelves 5 D Standard (12” Front to Back) Rail 11 Damage - Freig
ملخص المحتوى في الصفحة رقم 16
HOURS OF OPERATION: Monday thru Friday 7:30 a.m. - 4:30 p.m. CST EXTENDED WARRANTY SERVICE HOURS Monday thru Friday 4:30 p.m. - 6:00 p.m. CST Traulsen & Co., Inc. 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www.traulsen.com Quality Refrigeration
