ملخص المحتوى في الصفحة رقم 1
WELLSBLOOMFIELD,LLC
021
2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439
telephone: 775-689-5703
fax: 775-689-5976
www.wellsbloomfield.com
OPERATION MANUAL
BUILT-IN
BAIN MARIE
STYLE
HEATED
TANKS
MODELS
HT-200 thru
HT-527
including
AUTOFILL
Includes
Model HT-300
INSTALLATION
USE & CARE
IMPORTANT: DO NOT DISCARD THIS MANUAL
This manual is considered to be part of the appliance and is to be given to the OWNER or
MANAGER of the restaurant, or to the person responsible for TRA
ملخص المحتوى في الصفحة رقم 2
021 303333 OpManual for Built-In Bain Marie Warmers LIMITED WARRANTY STATEMENT Unless otherwise specified, all commercial cooking based upon the limitations in this warranty. Seller’s equipment manufactured by WELLS BLOOMFIELD, LLC is obligation under this warranty is limited to the repair of warranted against defects in materials and workmanship for defects without charge by a Wells Bloomfield factory a period of one year from the date of original install
ملخص المحتوى في الصفحة رقم 3
TABLE OF CONTENTS WARRANTY xi SPECIFICATIONS 1 FEATURES & OPERATING CONTROLS 2 PRECAUTIONS & GENERAL INFORMATION 3 AGENCY LISTING INFORMATION 3 INSTALLATION 4 OPERATION 6 CLEANING INSTRUCTIONS 7 TROUBLESHOOTING SUGGESTIONS 9 MAINTENANCE INSTRUCTIONS 10 PARTS & SERVICE 11 CUSTOMER SERVICE DATA 11 INTRODUCTION Thank You for purchasing this Wells Bloomfield appliance. Proper installation, pro
ملخص المحتوى في الصفحة رقم 4
021 303333 OpManual for Built-In Bain Marie Warmers FEATURES & OPERATING CONTROLS A. THERMOSTAT On THERMOSTATICALLY CONTROLLED heated tanks, power is applied to the heating element according to the control knob position and the actual temperature at the temperature sensing thermobulb. The desired temperature is controlled by rotating the TEMPERATURE CONTROL KNOB. The knob has a numeric scale, where higher numbers correspond to higher temperature. The INDICATOR
ملخص المحتوى في الصفحة رقم 5
PRECAUTIONS AND GENERAL INFORMATION This appliance is intended for use in commercial establishments WARNING: only. SHOCK HAZARD This appliance is intended to hold pre-heated food for human All servicing requiring access consumption. No other use is recommended or authorized by the to non-insulated electrical manufacturer or its agents. components must be performed by a factory Operators of this appliance must be familiar with the appliance use, authorized t
ملخص المحتوى في الصفحة رقم 6
021 303333 OpManual for Built-In Bain Marie Warmers INSTALLATION NOTE: DO NOT discard UNPACKING & INSPECTION the carton or other packing Carefully remove the appliance from the carton. Remove all materials until you have protective plastic film, packing materials and accessories from the inspected the appliance for Appliance before connecting electrical power or otherwise performing hidden damage and tested it any installation procedure. for proper operation. Refer to SHI
ملخص المحتوى في الصفحة رقم 7
INSTALLATION (continued) 3. For “top-mounted” installation: a. Verify that provided sealants are applied to the underside of the warmer top flange prior to setting the unit into the cutout. b. After installation, verify that the tabs on the Wellsloks are turned out to lock the warmer into the counter. c. Apply a thin bead of food-grade silicone sealant around the flange to seal it to the counter. d. Wellslok extension kits are available for installing warmers in counte
ملخص المحتوى في الصفحة رقم 8
021 303333 OpManual for Built-In Bain Marie Warmers OPERATION CAUTION: A. WET OPERATION HOT SURFACE Make sure the drain valve is fully closed before turning thermostat ON. Exposed surfaces can be hot Add approximately 1” of hot tap water before turning the warmer ON. to the touch and may cause Use of hot water will allow a faster preheat. burns. 1. For non-autofill units: check the water level frequently and add hot water as necessary to prevent the tank from run
ملخص المحتوى في الصفحة رقم 9
CLEANING INSTRUCTIONS DAILY CLEANING INSTRUCTIONS CAUTION: SHOCK HAZARD PREPARATIONS: Turn control knob to OFF. Unplug the warmer. Allow warmer to cool before proceeding. Do NOT splash or pour water Remove any insets, pans and/or adapter tops ( if into or over any control panel used). Drain water from tank. or wiring. FREQUENCY: Minimum - daily. CAUTION: TOOLS: Mild Detergent SHOCK HAZARD Solution: 10 Parts Warm Water to 4 Parts
ملخص المحتوى في الصفحة رقم 10
021 303333 OpManual for Built-In Bain Marie Warmers CLEANING INSTRUCTIONS (continued) WEEKLY CLEANING INSTRUCTIONS CAUTION: CHEMICAL BURN PREPARATIONS: Remove any insets, pans and/or adapter tops. HAZARD Drain or remove water from well if used for wet Deilimng chemicals may be operation. caustic. Wear appropriate personal protective equipment. FREQUENCY: Weekly, or whenever lime or scale is seen Follow cleaner manufacturer's accumulati
ملخص المحتوى في الصفحة رقم 11
MAINTENANCE INSTRUCTIONS CARE OF STAINLESS STEEL Stainless steel is a marvelous material: strong, lustrous and low maintenance. With a minimum of care, it will normally retain its beauty and durability for the life of the equipment. In some applications, however, special care is required in order to maintain stainless steel’s special properties. External components, such as cabinets and control panels, are finished with a grain pattern. This pleasing finish is best maintained
ملخص المحتوى في الصفحة رقم 12
021 303333 OpManual for Built-In Bain Marie Warmers TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Circuit breaker off or tripped Reset circuit breaker No power to warmer Unit not plugged in Make sure unit is plugged in to power receptacle Temperature control not set Set control to desired temperature Warmer will not heat Internal damage Contact you Authorized Wells Service Agency for repairs Water supply not turned on Turn on water supply Autofill does not
ملخص المحتوى في الصفحة رقم 13
PARTS & SERVICE DESCRIPTION PART NO. IMPORTANT: Use only factory authorized service parts. 6 oz. SOUP LADLE 21764 DRAIN VALVE EXTENSION KIT, extension from For factory authorized drain to counter front with remote handle 20385 service, or to order factory authorized replacement parts, DRAIN SCREEN 21709 contact your Wells authorized service agency, or call: Wellslok Extension Kits for UL Listed units approved for installation in wo
ملخص المحتوى في الصفحة رقم 14
Commercial Food Equipment Service Association Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association SER SERVICE VICE TRAINING TRAINING - - QUALITY QUALITY SER SERVICE VICE Genuine Parts Protect - YOU - All - Ways CUST CUSTOMER OMER SA SATISF TISFACTION ACTION WELLSBLOOMFIELD,LLC 2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439 telephone: 775-689-5703 fax: 775-689-5976 www.wellsbloomfield.com PRINTED IN UNITED STATES OF AMERICA
