Inhaltszusammenfassung zur Seite Nr. 1
1.800.423.0698 www.cookshack.com info@cookshack.com
Cookshack, Inc.
Operator’s Manual
Model FEC500
Fast Eddy’s Oven
Version 06.2
Serial No:
F ast Eddy’s Model FEC500 1 Ver. 06.2
Inhaltszusammenfassung zur Seite Nr. 2
1.800.423.0698 www.cookshack.com info@cookshack.com Dear Cookshack Customer: Your Model FEC500 FAST EDDY’S BARBEQUE OVEN by Cookshack will produce great barbecue and smoked foods. It is easy to operate, clean, and maintain. Use this Operator's Manual to familiarize yourself with the smoker and its operation. If you have a question or problem not covered in the book, call us at 1.800.423.0
Inhaltszusammenfassung zur Seite Nr. 3
1.800.423.0698 www.cookshack.com info@cookshack.com TABLE OF CONTENTS Fast Eddy’s Smoker Oven Model FEC500 Version 06.2 GENERAL INSTRUCTIONS............................................................................................... 4 INSTALLATION INSTRUCTIONS..................................................................................... 4 EXHAUST SYSTEMS.....................
Inhaltszusammenfassung zur Seite Nr. 4
1.800.423.0698 www.cookshack.com info@cookshack.com FAST EDDY’S BARBEQUE OVENS MODEL FEC500 GENERAL INSTRUCTIONS • This unit must be electrically grounded in accordance to your local codes, or with the National Electrical Code ANSI/NFPA 70-1990. • Keep the oven free from combustible materials. A good rule of thumb is to allow an 18” clearance space around gear motor access panel and the fire b
Inhaltszusammenfassung zur Seite Nr. 5
1.800.423.0698 www.cookshack.com info@cookshack.com EXHAUST SYSTEM(S) • All FEC500’s come with a standard system which vents smoke out of the oven through a 5 inch pipe. It is the customer’s responsibility to provide a method to move smoke from this exhaust to the outside, following applicable local codes. This system must remain in place any time the unit is operated inside a building. • Cooks
Inhaltszusammenfassung zur Seite Nr. 6
1.800.423.0698 www.cookshack.com info@cookshack.com IQ4 CONTROLLER OPERATION Directions for using the Controller 1. Turn Master Switch ON. 2. Set cooking time by pressing and holding the COOK TIME button while using the ADJUST TIME OR TEMP buttons to change settings 3. Set cooking temperature by pressing and holding the COOK TEMP button while using the ADJUST TIME OR TEMP buttons to change
Inhaltszusammenfassung zur Seite Nr. 7
1.800.423.0698 www.cookshack.com info@cookshack.com LOADING INSTRUCTIONS • When loading meat load the bottom racks first. In order to make the product fit, it may be necessary to remove the middle rack on a section when cooking thick cuts of meat like whole briskets or pork butts. • The product needs to be loaded so that the racks are balanced—i.e. hang evenly on the arm when finished. When lo
Inhaltszusammenfassung zur Seite Nr. 8
1.800.423.0698 www.cookshack.com info@cookshack.com • 110 Volt, 60 Hz, single phase, 4 amp service required. • A 15 amp fuse is required on the control panel. • Rotisserie motors are ¼ hp. Convection fans are ¼ hp each. • The fire box igniter elements are 200 watts. • Auger motors and burner induction fans are 25 watts each. MAINTENANCE • Clean ash from unit weekly. • Clean pellet slide fre
Inhaltszusammenfassung zur Seite Nr. 9
1.800.423.0698 www.cookshack.com info@cookshack.com APPENDIX A Two Year Limited Warranty Cookshack Smoker Ovens are guaranteed to be free from defects in material and workmanship under normal use and when installed in accordance with factory recommendations. This limited warranty includes parts and labor for the first 90 days. Following the 90 day period, the two (2) year limited warranty is f
Inhaltszusammenfassung zur Seite Nr. 10
1.800.423.0698 www.cookshack.com info@cookshack.com APPENDIX B Warranty Procedures If you have merchandise that you believe is defective please call Cookshack, Inc., at (580) 765-3669 and ask to speak to a Customer Service Representative (CSR). Have your smoker oven model and serial number available, if applicable. The CSR will take the information you provide and make a determination regarding t
Inhaltszusammenfassung zur Seite Nr. 11
1.800.423.0698 www.cookshack.com info@cookshack.com APPENDIX C National Service Policy Cookshack, Inc.’s National Service Policy is to build quality equipment with easy serviceability. Because of the ease in serviceability, Cookshack does not have National Service Companies to repair their equipment. This al- lows each restaurant to use the service company of their choice. If your unit needs
Inhaltszusammenfassung zur Seite Nr. 12
1.800.423.0698 www.cookshack.com info@cookshack.com APPENDIX D Electrical Wiring Diagram Fast Eddy’s Model FEC500 12 Ver. 06.2
Inhaltszusammenfassung zur Seite Nr. 13
1.800.423.0698 www.cookshack.com info@cookshack.com APPENDIX E Fast Eddy’s by Cookshack Model FEC500 Fast Eddy’s Model FEC500 13 Ver. 06.2
