Manual de instrucciones de Gale FORD 460

Resumen del contenido incluido en la página 1

oWn er s
Manu aL
WitH inst aLLation
instr uctions
stinger
®
syste M
ford 460 efi engine
1987-96 standard cab pickups
tHis ManuaL is for use WitH systeMs 49207, 49250 and 49253
1987-96 extended/creW cab pickups
tHis ManuaL is for use WitH systeMs 49218, 49252 and 49254
gaLe banks engineering
546 duggan avenue • azusa, ca 91702
(626) 969-9600 • fax (626) 334-1743
product information & sales: (800) 438-7693
www.bankspower.com
©2009 gaLe banks engineering 02/06/09 p.n. 96346 V.2.0

Resumen del contenido incluido en la página 2

this page intentionally left blank.

Resumen del contenido incluido en la página 3

® banks stinger systeM ford 460 efi truck dear customer: your new banks stinger is a unique combination of air intake and exhaust components designed to make the most of your engine’s power potential. by removing intake and exhaust restrictions, providing cooler intake air, and tuning the exhaust to create a scavenging effect, your engine can produce more power at a higher level of efficiency. if your driving habits remain the same, your fuel mileage should go up, and you can run on the

Resumen del contenido incluido en la página 4

figure 1 p.n. 96346 V.2.0 4

Resumen del contenido incluido en la página 5

instaLLation instructions r aise vehicle. see safety precautions, page 2. if install this hanger clamp into the factory rubber hanger to 1. possible, support vehicle from chassis and allow support the pipe. do not tighten at this time. rear axle to hang. install the muffler onto the catalytic converter or 8. r emove muffler and tailpipes from over rear axle. intermediate pipe. Hang the muffler by the front 2. if this assembly is to be saved intact, the vehicle and rear hanger clamps in the fa

Resumen del contenido incluido en la página 6

cLeaning and oiLing tHe banks raM-air fiLter NotificatioN dRyiNG hiNtS 5. always dry naturally. after rinsing, shake off t he Banks Ram-a ir f ilter comes pre-oiled and no all excess water and let the element dry naturally. oiling is necessary for initial installation. do not use co Mpressed air – do not use open Use Banks Ram-a ir f ilter cleaning system (part fLaMe – do not use Heat dryers ! #90094), available from Gale Banks Engineering excess Heat WiLL sHrink t He cotton to service t

Resumen del contenido incluido en la página 7

parts List banks stinger system ford 460 efi engine std./ext./crew cab pickups 1987-93 1987-93 1993-96 1993-96 1996 1996 std. ext./crew std. ext./crew std. ext./crew cab cab cab cab cab cab (’96 excludes ca) (’96 excludes ca) (ca only) (ca only) 49207 49218 49250 49252 49253 49254 Qty. description part# part# part# part# part# part# 1 adapter, cat. conv. to Muffler ................. 52601 52601 52604 52604 52604 52604 4 boLt, 6mm x 1.00 x 40mm . . . . . . . . . . . . . . .

Resumen del contenido incluido en la página 8

gaLe banks engineering 546 duggan avenue • azusa, ca 91702 (626) 969-9600 • fax (626) 334-1743 product information & sales: (800) 438-7693 www.bankspower.com