Resumen del contenido incluido en la página 1
Bio-ethanol fireplace burner and log set
Model # 61000
Distributed by:
Duraflame, Inc., Stockton, CA 95201
For questions about Assembly and Operating instructions or Warranty Claims
contact Duraflame, Inc. Consumer Affairs
info@duraflame.com
1 (866) 552-3015
www.duraflame.com/illuma
Patents Pending
Tested to UL 1370 for “unvented bio-ethanol burners” by PFS Corporation
WARNING: If the information in this manual is not followed exactly, a fire or explosion may
result, caus
Resumen del contenido incluido en la página 2
TABLE OF CONTENTS page I. Safety Information ........................................................................3 II. Air for Ventilation and Combustion ...............................................5 III. Setup ............................................................................................7 IV. Minimum Firebox Dimensions ......................................................9 V. Installation and Clearances ..........................................................9 VI. Inst
Resumen del contenido incluido en la página 3
I. SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this appliance. Improper use of this appliance or failure to comply with the safety rules can cause serious injury or death from burns, fire, explosion, or carbon monoxide poisoning. Keep this manual. It should be read by all users of the appliance. DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poi
Resumen del contenido incluido en la página 4
Do not store the duraflame illuma-fuel canisters near the appliance. Store illuma-fuel tightly closed in its original canister in a dry, cool place, out of direct sunlight and away from heat sources, flammable objects and open fires, and out of the reach of children. If swallowed, seek medical attention immediately. In case of contact with eyes, flush immediately with cool water for 15 minutes and seek medical attention. For contact with skin, rinse well with cool water. If irritation
Resumen del contenido incluido en la página 5
Do not dismantle the burner. Do not insert any other fuel canister into the burner. This appliance must be operated using only authorized accessories and equipment. Do not move the appliance while it is burning. This could cause burning fuel to spill and result in injury or a fire. Do not put anything into the flames of the appliance. This could cause sooting and the creation of harmful combustion products. Do not put your head over the burner while lighting it. Keep all body parts safely a
Resumen del contenido incluido en la página 6
• If your home meets all three of the above criteria, you must provide additional fresh air. See Ventilation Air from Outdoors, below. If your home does not meet all three of the above criteria, you must next determine whether or not you are installing the appliance in a confined space. • The National Fuel Gas Code, ANS Z223.1 defines a confined space as a space with a volume of 3 less than 50 cubic feet per 1,000 Btu per hour (4.8 m per kw) of the aggregate input rating of all appliances
Resumen del contenido incluido en la página 7
Step 5: Compare the numbers: 84 (Step 4) is larger than 52 (Step 2), so the space is unconfined. You may install the appliance in the room. If your space is confined, additional ventilation air must be provided, either from within the building or from outside. Within the building, you could ventilate to an adjoining space. To do this, you have two options: either remove the door to the adjoining room, or provide two permanent vented openings (one opening must be within 12” of the ceiling a
Resumen del contenido incluido en la página 8
Sliding Burner Cover Burner Slot Heat Shield Fuel Reservoir Tank Tray Burner Tube Sparker Piercer Handle Fuel Tank Bracket Screw-down Hole (Another hole on opposite side) Grate Burner / Base Ignition Button Figure 1 Appliance Overview Install this appliance in compliance with all local building codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code (ANSZ223.1, also known as NFPA54), available from: American National Standards Institute 25 West 43rd Street
Resumen del contenido incluido en la página 9
IV. MINIMUM FIREBOX DIMENSIONS WARNING: Maintain or exceed the minimum clearances. V. CLEARANCES (Vent-free operation only) Firebox Side Firebox Back 18” 19” 15” 31” Figure 2 Minimum Dimensions of Firebox WARNING: Maintain or exceed the minimum clearances. VI. INSTALLING DAMPER STOP (Vented operation) For vented operation of this appliance, a damper stop must be installed in the fireplace to prevent full closure of the damper blade. The damper stop must be adjusted to provide a minimum flue
Resumen del contenido incluido en la página 10
3. Check each component for shipping damage. If components are damaged, contact the store where purchased or Duraflame, Inc. 4. Check the firebox dimensions to ensure that they are at least equal to the minimum dimensions shown in Figure 2. The minimum clearances that the appliance originally required will be adequate for this installation. You will need the two (2) ¼” x 1 ½” masonry screws provided for this step. Place the burner / base in a solid-fuel-burning masonry fireplace, a UL127
Resumen del contenido incluido en la página 11
Figure 3 Figure 4 Logs Placement of Rear Log Figure 5 Figure 6 Placement of Front Log Showing space between tray and log inside wall on the left Figure 7 Figure 8 Showing space between tray All logs properly placed and log inside wall on the right -11-
Resumen del contenido incluido en la página 12
Figure 9 Proper placement of front log with a gap between the back of the tray and the hinge plate VIII. INSTALLING THE FUEL CANISTER ® ® NOTE: Use only 1 liter duraflame illuma-fuel bio-ethanol canisters with this appliance. The canisters are recyclable but NOT refillable. 1. Open the door on the top of the front log of the log pile (see Figure 10). 2. Remove the child resistant screw cap from a canister of illuma-fuel (by pushing down on it and twisting at the same time) to expose the fo
Resumen del contenido incluido en la página 13
® NOTE: Before burning the appliance for the first time, install a canister of duraflame ® illuma-fuel , let the fuel sit in the burner for five minutes, and check to ensure there aren’t any leaks below and around the front log or below the burner (see Figure 18). 1. Use the handle (located at the front of the appliance beneath the grate – Figure 12) to slide the snuffer device to the rear of the burner. Be sure that the cover is slid back far enough to fully expose the burner slot (see Fi
Resumen del contenido incluido en la página 14
4. To extinguish the flames, grasp the handle of the snuffer device, and slide the cover forward over the burner slot. The slot must be completely covered to extinguish the flames. This appliance can be relit at any time—even immediately after extinguishing, if desired, using the igniter. Figure 14 Check for leaks on the floor of the fireplace under the areas indicated. X. REFUELING ® This appliance is designed so that one canister of illuma-fuel (1 L) will provide a continuous supply o
Resumen del contenido incluido en la página 15
4. Install a new canister as described above (see INSTALLING THE FUEL CANISTER, Steps 2 and 3). 5. After the canister has been installed, close the door of the front log. The appliance is now ready for continued use. 6. If the flame is out by this time, use the igniter to start it again. *NOTE: Burn times will vary depending on conditions such as temperature, draft and how level the surface is. Figure 15 Figure 16 Area safe to touch log while How to remove canister when fire is burning
Resumen del contenido incluido en la página 16
2. Metal components of the appliance should be cleaned using a damp cloth and a mild dish detergent. Never use abrasive cleaners, as they can damage the metal. 3. Remove the logs carefully. 4. Lift out the piercer and clean underneath. 5. Clean the area inside the burner. Be very careful when doing so, because the top edges of the burner may be very sharp. 6. Dust the logs gently. 7. Make sure that all parts of the appliance are returned to their proper operating positions by following as
Resumen del contenido incluido en la página 17
XIII. TROUBLESHOOTING Use the following guide to solve any problems you might encounter in operating this appliance. PROBLEM SOLUTION 1. You see fuel on the ground near the • DO NOT light the burner. Extinguish any appliance. open flame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate. If you see no additional fuel on the ground, you may light the burner. If you see additional fuel on the ground, you might have a leak. DO NOT use this appliance
Resumen del contenido incluido en la página 18
XIV. PARTS LIST Part Number 61001 Burner / Base 61002 Igniter 61003 Front Log 61004 Back Log 61005 Left Small Log 61006 Right Small Log 61007 Canister Tray & Piercer 61008 Heat Shield 61009 Grate 61010 Masonry Screws -18-
Resumen del contenido incluido en la página 19
WARRANTY INFORMATION KEEP THIS WARRANTY Model: ________________________________ Serial No.: _____________________________ Date Purchased: ________________________ Always specify model and serial numbers when communicating with Duraflame, Inc. We reserve the right to amend the specifications of this product at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied. LIMITED WARRANTY – DURAFLAME ILLUMA™ LOG SETS AND
Resumen del contenido incluido en la página 20
INC. SHALL NOT BE LIABLE FOR ANY OTHER DAMAGES WHATSOEVER INCLUDING INDIRECT, INCIDENTAL, OR CONSEQUENTIAL DAMAGES. Some states do not allow a limitation on how long an implied warranty lasts or an exclusion or limitation of incidental or consequential damages, so the above limitation on implied warranties, or exclusion or limitation on damages may not apply to you. This warranty gives you specific legal rights, and you may also have other rights that vary from state to state. For informat
