Resumen del contenido incluido en la página 1
Compact Scooters
XtraLite 4 (TE-787NA-UL4)
XtraLite 3 (TE-787NA-UL3)
Scootie (TE-787NA)
Sunrunner S (777-3/4)
User Manual
Resumen del contenido incluido en la página 2
Table of Contents INTRODUCTION......................................................................................................................... 3 FEATURE GUIDE (FIG. 1-4) ..................................................................................................... 3 SAFETY ADVICE........................................................................................................................ 5 EMI Warning .................................................................
Resumen del contenido incluido en la página 3
INTRODUCTION Congratulations on your purchase of the Shoprider® scooter. This scooter incorporates the latest innovative designs patented and only available on a Shoprider® scooter. This scooter can be used in confined spaces both indoors and out. Direct drive transaxles and electromagnetic brakes give a safe and efficient ride. This Shoprider® scooter is designed for persons with limited mobility. Please ensure that you read this manual carefully, it is important for your safety t
Resumen del contenido incluido en la página 4
1 2 Scootie (Figure 3) 1. Tiller control head 6 2. Detachable seat with fold down back 3 3. Detachable basket 4. Detachable cover with integral battery pack 8 5. Tiller release knob 6. Carrying stay rod 7. Seat height adjustment 8. Anti-Tip wheels 5 4 9 7 9. Puncture proof tires Figure 3 Sunrunner S (Figure 4) 1 2 1. Tiller control head 2. Detachable swivel seat with fold down back 3. Detachable basket 4. Detachable cover with integral battery pack 3 5. Tiller angle
Resumen del contenido incluido en la página 5
SAFETY ADVICE • Do not carry passengers. • Do not exceed inclines over 8 degrees (14% grade). • Do not turn on steep inclines. • Do not turn suddenly at high speeds. • Do not get on or off the scooter unless the brake is on and the scooter is switched off. • Do not switch off the scooter while the scooter is moving. • Do not drive the scooter where you can not safely or legally walk. • Do not attempt to drive over curbs greater than 2 inches (5cm.) in height. Doing so could cause your s
Resumen del contenido incluido en la página 6
EMI Warning Shoprider® scooters may be susceptible to electromagnetic interference (EMI), which is a kind of interfering electromagnetic energy (EM) emitted from sources such as radio stations, TV stations, amateur radio (HAM) transmitters, two-way radio, and cellular phones. The interference (from radio wave sources) can cause the scooter to release its brakes, move by itself, or move in unintended directions. It can also permanently damage the scooter’s control system. The sources of
Resumen del contenido incluido en la página 7
ADJUSTMENTS Tiller Angle Adjustment (For XtraLite 4 & Sunrunner S ONLY) (Fig. 5) On the left hand side at the base of the tiller Tiller Angle Adjustment is a red lever. Push the lever in to release Lever the pin and select the required tiller angle. Refit the pin into one of the five location holes. Folding the Tiller (For XtraLite 3 & Figure 5 Scootie ONLY) (Fig. 6) Fold down the tiller by loosening the hand knob located at the base of the tiller stem. S
Resumen del contenido incluido en la página 8
Armrest Width Adjustments (Fig. 9) On the underside of the seat there are two hand knobs, one on each side. Loosening the arm rest tightening knob allows the armrest width to be adjusted or arm rests to be removed. Arm Rest Adjustment Hand Knob Armrest Angle Adjustment (Fig. 10) Flip up the armrests to allow access to the Figure 9 adjustment screw and lock nut, unscrew the lock nut and screw the bolt in or out to increase or decrease the angle. Re-tighten the lock
Resumen del contenido incluido en la página 9
SCOOTER TILLER CONTROLS (FIG. 13) Speed Controls The speed control allows you to set a speed between 1 (minimum) and 10 (maximum). Battery Level Indicator/Gauge The number of LED bars lit/where the needle sits, shows the amount of charge left in your batteries. The amount of charge will only show at its true level when the scooter is in drive. Caution – Do not allow the LED bars/gauge needle to go out completely as complete discharge of the batteries could cause irreversible damage
Resumen del contenido incluido en la página 10
FREE WHEEL OPERATION (FIG. 14) The free wheel release lever (red handle) is located next to the right rear wheel (Fig. 14). To disengage the motor, lift up the lever (the scooter can now be pushed). To re-engage the motor push down on the lever. WARNING! Always re-engage the free wheeling device after use. Failure to do so may result in injury. Anti-tip wheels The anti-tip wheels are located at the rear of the scooter frame (Fig. 14). The scooter should not be used unless the an
Resumen del contenido incluido en la página 11
Steering Steering the scooter is light and easy. Ensure when starting off you give a wide clearance when turning so that the rear wheels clear any obstacle that you are passing. When steering through limited spaces such as a doorway or when turning around, turn the tiller handles where you want to go and apply power gently. The scooter will turn very tightly, but will still move with complete stability as long as the speed is not too high. Reversing Before reversing ensure that the
Resumen del contenido incluido en la página 12
TRANSPORT / STORAGE The scooters are designed to be dismantled into separate sections for transportation and storage. Your scooter can be dismantled into the following sections: 6 1 XtraLite 3 (Fig. 15) 5 3 1) Small Front Basket 2) Large Rear Basket 2 3) Seat 4) Seat Post & Fasteners 5) Battery Pack 6) Fold Down Frame Figure 15 4 XtraLite 4 (Fig. 16) 6 1) Small Front Basket 5 2) Large Front Basket 2 3) Seat 1 4) Seat Post & Fasteners 5) Battery Pack 3 6) Fold Down
Resumen del contenido incluido en la página 13
Dismantling 1. Remove baskets. 2. Fold down the back of the seat. 3. For Sunrunner S: pull up on the red lever under the seat and at the same time lift and twist the seat off. For XtraLite 3; XtraLite 4; Scootie: unscrew the tightening bolt below the seat. Lift seat off. For XtraLite 3 & XtraLite 4 ONLY. 1. Lower tiller toward the foot rest and connect the carrying rod (For XtraLite 3) to the proper location or connect the two Velcro straps (For XtraLite 4) to the handle bars.
Resumen del contenido incluido en la página 14
MAINTENANCE Lubrication At six-month intervals you should lubricate the following parts with a light oil or similar lubricant: • Seat pivot post. • Seat release lever pinion. • Wheel bearings. • Axle of scooter. CAUTION – DO NOT USE WD40 TO LUBRICATE PARTS!! DO NOT LUBRICATE TRANSAXLE/GEAR BOX!! In the event of any difficulties please consult your dealer. Wheels and Tires The wheels of your scooter might have split rims (except for the XtraLite 3 where the rim and tire are one mo
Resumen del contenido incluido en la página 15
TECHNICAL SPECIFICATIONS UNIT SPECIFICATIONS XtraLite 3 XtraLite 4 Scootie Sunrunner S 37-40 (930- 43-46 (1090- 1 Overall Dimensions: L x W x 45 (1130) x 21 (520) x 41 (1040) x 20 (510) in (mm) 1015) x 17 (430) 1168) x 22 H 37 (930) x 35 (890) x 34 (865) (560) x 35 (890) Front 1 , 8” 2 , 7” 2 , 7” 2 , 8” Number, Size of Tires Rear 2 , 8” 2 , 8” 2 , 8” 2 , 8” Suggested User Weight lb (kg) Max. 220 (100) Max. 220 (100) Max. 225 (102) Max. 250 (113) (on the
Resumen del contenido incluido en la página 16
QUARTERLY INSPECTION For your own safety, quarterly inspection and service on the product has to be performed and signed by an authorized dealer. Maintenance records (below) should be kept at all times. The manufacturer / distributor / vendor will be indemnified from any product liability claim if the above maintenance / service requirement is not met. NOTE! Regular (Monthly) inspection is strongly recommended by the manufacturer to ensure ultimate performance of the vehicle. Se
Resumen del contenido incluido en la página 17
WARRANTY Please refer to warranty information included with unit. Serial No. DISCLAIMER Congratulations on your purchase of the Shoprider® It is not intended to be used by individuals with physical limitations that could prevent the user from operating this unit safely. Shoprider® disclaims all responsibility for any personal injury or property damage, which may occur as a result of improper or unsafe use of its products. Mechanical or electrical defects will be dealt with
Resumen del contenido incluido en la página 18
Notes 9/22/2004 18
