Résumé du contenu de la page N° 1
ASSEMBLY & OPERATING INSTRUCTIONS
300 400 500
200 600
100
700
800
Model: 720-0439
FOR OUTDOOR USE ONLY
FOR PROPANE GAS USE ONLY
J19Y06P-1
PLEASE CONTACT 1-866-984-7455 FOR ASSISTANCE
ABOUT ASSEMBLY OR GRILL OPERATION
DO NOT RETURN TO THE PLACE OF PURCHASE
Résumé du contenu de la page N° 2
MESSAGE TO OUR CONSUMERS Thank you for selecting our stainless steel gas grill. Because this appliance contains features which may not be found on other grills, we recommend that you read this entire booklet before your first use. Keep it in a handy place as it has answers to questions that may occur during future use. Read this booklet carefully and be sure your gas grill is properly assembled, installed and maintained. Failure to follow these instructions could result in serious bodily in
Résumé du contenu de la page N° 3
TABLE OF CONTENTS SECTION ONE SECTION FIVE Table of Contents & Importance Trouble Shooting-----------------------------21-24 Precautions--------------------------------------1-2 Exploded View--------------------------------25 Placement of the Grill--------------------------3 Part List-----------------------------------------26-27 Ordering Parts & Grilling Hints------------28 SECTION TWO Assembly Instructions-----------------------4-7 SECTION SIX To Match Light The Grill----------------------8 Gr
Résumé du contenu de la page N° 4
PRECAUTIONS WARNING SAFETY PRACTICES TO AVOID PERSONAL INJURY Do not try to light this appliance without first reading the “LIGHTING When properly cared for, your stainless INSTRUCTIONS” section in this manual. steel grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense TESTED IN ACCORDANCE WITH ANS heat and that can increase accident Z21.58a •CSA 1.6a-2006 STANDARD FOR potential. When using this appliance basic OU
Résumé du contenu de la page N° 5
PRECAUTIONS DO NOT STORE ITEMS OF INTEREST TO Moist or damp potholders on hot surfaces CHILDREN AROUND OR BELOW THE may cause burns from steam. Do not use a GRILL OR IN THE CART. NEVER ALLOW towel or bulky cloth in place of potholders. CHILDREN TO CRAWL INSIDE OF THE Do not let potholders touch hot portions of CART. the grill rack. Never let clothing, kitchen mitten or other Grease is flammable. Let hot grease cool flammable materials come in contact with or before attempting to handle it.
Résumé du contenu de la page N° 6
PRECAUTIONS Do not use the grill for cooking excessively outside in a well ventilated area, out of the fatty meats or products which promote flare- reach of children. ups. Do not operate the grill under DO NOT USE BRIQUETTES OF ANY KIND IN unprotected combustible construction. Use THE GRILL. only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or This stainless steel grill is designed for optimum other such enclosed areas. THIS UNIT IS performance without the
Résumé du contenu de la page N° 7
ASSEMBLY INSTRUCTIONS ASSEMBLE INSTRUCTIONS PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP. TOOLS REQUIRED: (1) PHILIPS HEAD SCREWDRIVER – NOT PROVIDED STEP 1: A. The screws used to attach the side shelf are already screwed into the left panel (see the figure below). Remove the screws from the left panel, align with the holes in the side shelf, and then re-screw into the holes on the left panel of the grill. B. The screws
Résumé du contenu de la page N° 8
ASSEMBLY INSTRUCTIONS STEP 2: Side Burner Assembly A. Push valve into side burner control panel. Insert screws from the front side of control panel and tighten. 300 400 500 600 200 100 700 800 B. Push the side burner control knob into the valve steam and tighten it using the Allen Wrench. 30 0 400 50 0 200 100 700600 800 C. Insert valve venturi into the side burner and tighten securely using an adjustable wrench. 200 300 40 0 50 0 60 0 100 700 800 D. Connect ignition wire with valve. 30 0 4
Résumé du contenu de la page N° 9
ASSEMBLY INSTRUCTIONS STEP 3: Battery is inserted for the rotisserie burner. To install the battery, turn the ignition button cap counterclockwise and remove it. Replace the ignition button cap after the battery is installed. 300 400 500 600 200 100 700 800 J19Y06P-1 5
Résumé du contenu de la page N° 10
CLO SE ASSEMBLY INSTRUCTIONS STEP 4: Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below. LP gas cylinder must be fitted with a listed overfill prevention device (OPD). Open the door and pull out the tray, place the gas tank cylinder in the tank tray , then use retention kit that showed as below diagram to secure the tank cylinder . Make sure tank is leveled with bottom panel for proper vapor withdrawal. g CYLINDER TANK FIXED 300
Résumé du contenu de la page N° 11
ASSEMBLY INSTRUCTIONS STEP 5: The screws for rotisserie drive motor bracket are attached to the motor bracket. Remove the screws and install the rotisserie motor bracket as shown in the figure below. Assemble the rotisserie skewer as shown in the figure below. J19Y06P-1 7
Résumé du contenu de la page N° 12
TO MATCH LIGHT THE GRILL 1. If the burner will not light after several attempts then the burner can be match lit. 2. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit extended match or lighter through the cooking grids to the burner. Press the control knob and rotate left to the HI setting, continue to press the knob until the burner ignites. Bur
Résumé du contenu de la page N° 13
GAS HOOK-UP Manifold pressure: 11 inches water column NEVER CONNECT AN UNREGULATED (W.C.). GAS SUPPLY LINE TO THE APPLIANCE. USE THE REGULATOR/HOSE ASSEMBLY L.P. GAS HOOK-UP SUPPLIED WITH THIS OUTDOOR GAS Ensure that the rubber “O” Ring on the LP APPLIANCE. cylinder valve is in place and that the hose This is a liquid propane configured grill. Do does not come into contact with the grease not attempt to use a natural gas supply. tray or the grill head. Set the liquid propane gas cylind
Résumé du contenu de la page N° 14
GAS HOOK-UP 5. When connecting regulator assembly to 7. If you have a gas connection leak you the valve, hand tighten the quick coupling cannot repair, turn gas OFF at supply nut clockwise to a complete stop. Do not tank, disconnect fuel line from your grill use a wrench to tighten. Use of a wrench and call 1-866-984-7455 or your gas may damage the quick coupling nut and supplier for repair assistance. result in a hazardous condition. 8. Also apply soapy solution to the tank 6. Open the ta
Résumé du contenu de la page N° 15
LEAK TESTING GENERAL Only those parts recommended by the manufacturer should be used on the grill. Although all gas connections on the grill are leak tested at the factory prior to shipment, a Substitution will void the warranty. Do not use complete gas tightness check must be the grill until all connections have been performed at the installation site due to checked and do not leak. possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. GAS FLOW
Résumé du contenu de la page N° 16
CAUTIONS Place dust cap on cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. The gas must be turned off at the supply cylinder when the unit is not in use. If the appliance is stored indoors, the cylinder must be disconnected and removed from the appliance. Cylinders must be stored outdoors in a well-ventilated area ou
Résumé du contenu de la page N° 17
OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND WARNING: IMPORTANT! ROTISSERIE USING THE SIDE BURNER: Each main burner is rated at 10,000 Inspect the gas supply hose prior to Btu/hr. The main grill burners encompass turning the gas “ON”. If there is evidence the entire cooking area and are side of cuts, wear or abrasion, it must be ported to minimize blockage from falling replaced prior to use. Do not use the side grease and debris. Above the burners are burner if the odor of gas i
Résumé du contenu de la page N° 18
OPERATING INSTRUCTIONS CAUTION: PLEASE TAKE OFF THE WARMING RACK WHEN USING THE ROTISSERIE BURNER. THE HIGH HEAT COMING FROM THE ROTISSERIE BURNER MAY CAUSE THE WARMING RACK TO BEND. GRILL LIGHTING INSTRUCTIONS WARNING: IMPORTANT! TO LIGHT THE GRILL BURNER: BEFORE LIGHTING… Make sure all knobs are “OFF” then turn on the gas supply from the LP tank. Always Inspect the gas supply hose prior to keep your face and body as far from the turning the gas “ON”. If there is evidence grill as pos
Résumé du contenu de la page N° 19
GRILL LIGHTING INSTRUCTIONS If you’ve just attempted to light the burner WARNING: Always keep your face and body as far away from the burner as possible with the igniter, allow 5 minutes for any when lighting. accumulated gas to dissipate. Keep your face and hands as far away from the grill TO LIGHT THE SIDE BURNER as possible. Insert a lit match attached to To light the side burner, remove any the lighting rod through the cooking grids to cooking utensils from the burner grate. the bur
Résumé du contenu de la page N° 20
GRILL LIGHTING INSTRUCTIONS J19Y06P-1 16
