Résumé du contenu de la page N° 1
Operating & Installation Manual
Sherborne
Wood & Multifuel Stoves
Sherborne Medium Multifuel Stove
PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE
Arada Ltd
The Fireworks
Bridport
Dorset, DT6 3BE
Great Britain
Rev 2
Tel. (44) 01308 427234
Nov 2006
Fax. (44) 01308 423441
AFS1237
www.aarrowfires.com
Résumé du contenu de la page N° 2
Congratulations on your choice of an Aarrow Stove. More than 20 years experience has been put into the development of our Sherborne, range to ensure ultimate performance and years of trouble free enjoyment. Every detail on the stoves has been carefully engineered and designed which is why we are so confident in the reliability of our product that we offer a Lifetime Guarantee. Should you have any questions about our Sherborne range of stoves that are not covered in this manual, please contact th
Résumé du contenu de la page N° 3
CONTENTS INTRODUCTION Page INSTALLATION Page Safety Notices 5 General Precautions 16 The Principle of the Fire 5 Handling 16 Check List 6 Hearth 16 Technical Data 7 Combustible Materials 16 OPERATING INSTRUCTIONS Firebox Liner Panels 17 Firebox Linings and Throat Plate Removal 8 Throat Plate Inspection 17 Multifuel Grate 8 Assembling the Multifuel Grate 18 Wood Stove - Wood Tray 8 Interchangeable Canopies 19 Air inlet Controls/Airwash
Résumé du contenu de la page N° 4
WARNING TO ALL MULTIFUEL USERS PETROLEUM COKE SOME OF WHOSE BRAND NAMES ARE "CALCO", "PETROCOKE" OR "WONDERCO" MUST NOT BE BURNED IN THIS APPLIANCE TO USE THESE FUELS WILL INVALIDATE THE APPLIANCE GUARANTEE IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0800 600 000 www.solidfuel.co.uk THE USE OF SPARE PARTS OTHER THAN THOSE SUPPLIED BY AARROW FIRES LTD WILL INVALIDATE THE APPLIANCE GUARANTEE. 4 Sherborne Wood & Multifuel Stoves
Résumé du contenu de la page N° 5
INTRODUCTION Safety is the most important consideration when SAFETY installing your fire. If not properly installed and A fireguard conforming to BS 8423: 2002 should operated a house fire may result. installation must be used in the presence of children and old/or comply with the Building Regulations and conform infirm people. If the appliance is used with the fire to all relevant fire safety standards. door open, a spark guard conforming to BS 3248 should be fitted. Aarrow Fires produce a vari
Résumé du contenu de la page N° 6
CHECK LIST Part Description Sherborne Sherborne Sherborne Sherborne Sherborne Sherborne Small Small Medium Large Large & Visual Aid Medium Wood Multifuel Multifuel Wood Multifuel Wood (not to scale) 1. Grate bars N/A 9 N/A 7 N/A 11 2. Fuel 2 2 2 2 2 2 retainers 3. Throat 1 1 1 plate 1 1 1 4. Flue spigot 1 (5”) 1 (5”) 1(5”) 1 (6”) 1 (6”) 1 (5”) 5. Hotplate 1 (5”) 1 (5”) 1(5”) 1 (5”) 1 (6”) 1 (6”) 1 6. Ashpan 1 1 1 1 1 7. Operating tool 1 1 1 1 1 1 8. Rear liner 2 2 2 2 2 2 9. Side liners 2
Résumé du contenu de la page N° 7
TECHNICAL DATA Sherborne Sherborne Sherborne Sherborne Sherborne Sherborne Small Medium Large TECHNICAL DATA Small Medium Large Wood Wood Multifuel Multifuel Wood Multifuel Room Min/Max Room Heater Only Output (kW) 2 - 8 2.5 - 11 1.5 - 6 1.5 - 6 2 - 8 2.5 - 11 Room Heater with Domestic Hot 9 9 10 10 8 8 Water with add in boiler type Max Output to Room (kW) 3.8 7.6 7.6 3.8 5.7 5.7 Max Output to Water (kW) 3.4 3.4 2.2 2.2 2.3 2.3 525 525 545 545 Height (mm) 505 505 490 Width (mm) 490 590 590
Résumé du contenu de la page N° 8
OPERATING INSTRUCTIONS PRIMARY AIR FOR SHERBORNE FIREBOX LININGS & THROAT On the Sherborne, primary air enters the appliance PLATE through the controls on the bottom of the fire The Sherborne range of Wood and Multifuel stoves door(s). Moving the control knobs to the right will firebox have reflective liners to the sides and rear increase the air inlet, to the left to reduce the air and a specially shaped throat plate which sits on the inlet, or to seal the ash door completely. liners. If th
Résumé du contenu de la page N° 9
OPERATING INSTRUCTIONS •Unscrew the two nuts, on the inside of the door securing the retaining clips. •Carefully remove any pieces of broken glass, and sealing gasket wearing suitable gloves. •Re-place the gaskets and line them up in relation to the door frame. (Fig.6) Fig. 4b Lifting cover from body of stove Fig. 4c Unscrewing Fig. 6 Lining up the gasket MULTI - PURPOSE OPERATING •Re-seat the new glass, ensuring the sealing gasket TOOL is flat and in contact with the glass. (Fig.7) Your
Résumé du contenu de la page N° 10
OPERATING INSTRUCTIONS DOOR ADJUSTMENT Once the appliance has been under fire for a period of time the fire door may appear to have moved out of alignment with relation to the door aperture. This is quite normal and due to the settling of the casing. The fire door can be re-aligned by the user as follows: •When the appliance is cold, open the fire door so that it is at a right angle to the front face of the fire. •Lift the fire door up off the hinges. •Gently tap the two hinge pins in a direct
Résumé du contenu de la page N° 11
OPERATING INSTRUCTIONS Approval does not cover the use of other fuels FUEL TYPES either alone or mixed with the suitable fuels listed above, nor does it cover instructions for the use of Wood- Any type of wood is suitable provided it is other fuels.For latest details please refer to Hetas well seasoned and has a moisture content below website www.hetas.co.uk. 20%. This usually implies that the timber has been suitably stored to allow moisture to evaporate for at Do not use smaller sizes than St
Résumé du contenu de la page N° 12
OPERATING INSTRUCTIONS ENSURE THAT YOU HAVE READ & Use the smallest size fuel (Stovesse or Small Nuts). UNDERSTOOD THESE INSTRUCTIONS Proceed as for manufactured smokeless fuel. Leave BEFORE LIGHTING THE FIRE. the air inlet control open about a quarter or less. ALWAYS WEAR SUITABLE PROTECTIVE Note: The high temperature paint acquires FIRE GLOVES WHEN REFUELLING YOUR durability by being "cured" during the initial STOVE. firings of the appliance will give off fumes which are non-toxic, but which
Résumé du contenu de la page N° 13
OPERATING INSTRUCTIONS • Check for flue or chimney blockage, and clean if easily start a fire or cause an injury. Replace the ash required. pan and close the fire door. Seek expert advice from your HETAS registered CLINKER installer. Do not attempt to re-light the fire until the The formation of clinker suggests that the unit is cause of the fume emission has been identified and being over-fired. Any clinker forming on the grate corrected. should be removed when cold. OVER-FIRING ASH REMOVAL
Résumé du contenu de la page N° 14
SERVICING Remove the firebricks lining and throat plate, - not coal ash - will provide a good soft scourer to inspect all gasketing on doors, glass etc., and remove the soot without scratching the glass. re-order any items that may need replacing, from your Aarrow dealer. With a wire brush clean inside OUTER FINISH the appliance paying particular attention to the The outside finish of the appliance is a durable high small inlet holes of the air wash on the inside, temperature paint. It is best c
Résumé du contenu de la page N° 15
ACCESSORIES ACCESSORIES WOOD BURNING TRAYS To turn your multifuel stove into a dedicated woodburner. As shown in Fig. 10a below Fig. 10a MULTIFUEL UPGRADE KIT Available for the wood burning range to enable you to burn solid fuel in your Sherborne woodburning stove. (See Fig. 10b) Fig. 10b ADD IN BOILERS Sherborne Sherborne Sherborne ADD IN BOILER Small Medium Large TECHNICAL DATA Wood & Multifuel Wood & Multifuel Wood & Multifuel Room Heater with Domestic Hot 8 9 10 Water with add in boiler t
Résumé du contenu de la page N° 16
INSTALLATION HEARTH GENERAL PRECAUTIONS The fire should be installed to stand on a constructional hearth of non-combustible materials Note - All installations must conform to the not less than 125mm (5'') thick conforming to appropriate building regulations. Building Regulations. Dimensions of the hearth should project at least 300mm (12'') forward of the The Building Regulations for England and Wales front of the appliance and 150mm (6'') at the sides. 2000 ref Approved Document J 2002 edition
Résumé du contenu de la page N° 17
INSTALLATION FIREBOX LINER PANELS The Sherborne Wood and Multifuel stoves use reflective liners to the sides and back. The throat plate sits on top of the side and rear panels. These should come fitted to your fire, if however they are not proceed as follows to fit them. •Remove the front fuel bars. •Set the small liners into the back of the fire. Fig. 12 Liners inserted in Sherborne •Insert side liner panels Medium Multifuel. •Fit the throat plate with the single bend and two cut outs to the
Résumé du contenu de la page N° 18
INSTALLATION MULTIFUEL GRATE GRATE BAR REPLACEMENT GRATE The grates in the Sherborne Multifuel units After extended use it may be necessary to replace comprise a series of reciprocating cast iron bars some of the grate bars. Periodic inspection of the seated on a pivoted "comb". All bars in the grate are bars is recommended and the removal of any nails identical, but every other bar is turned through 180 or wire that may be present after burning wood. degrees, with the ends of the bars marked "
Résumé du contenu de la page N° 19
INSTALLATION INTERCHANGEABLE CANOPIES The canopy versions for the Sherborne range are slab top stoves to which a low or high canopy can be fitted after installation and are interchangeable. These are fitted as follows: •To fit the interchangeable canopy (Fig 10c): •Remove the front clamps. •Tilt the canopy as shown in stage 1. •Engage the rear clips and pull fully forward. •Fit the front clamps and tighten. •Fit the required blanking plates shown in stage 2. Fig. 10c Sherborne Wood & Multifuel
Résumé du contenu de la page N° 20
INSTALLATION FITTING THE FLUE OUTLET AND FLUES AND CHIMNEYS HOT PLATE Please remember that chimney draught is dependent on four main factors: The flue outlet spigot is found inside the appliance. • Flue gas temperature. The hot plate (blanking plate) is supplied fitted to • Flue height. the top opening and is removed by turning • Flue size. clockwise (as is the flue outlet). • Flue terminal. Smear a very thin layer of fire cement on the faces The stove must be connected to a suitable and of the
