Résumé du contenu de la page N° 1
95HD
®
Backhoe
Published 7/04
Part No. F-3788
OPERA OPERAT TOR’S OR’S MANUAL MANUAL
This This Operator Operator’’s s Manual Manual is is an an integral integral part part of of the the safe safe operation operation
of of this this machine machine and and must must be be maintained maintained with with the the unit unit at at all all
times. times. READ READ,, UNDERST UNDERSTAND AND,, and and FOLLOW FOLLOW the the Safety Safety and and
Operation Operation Instructions Instructions contained contai
Résumé du contenu de la page N° 2
TO THE OWNER/OPERATOR/DEALER All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START!! Read the safety messages on the implement and shown in your manual. Observe the rules of safety and common sense!
Résumé du contenu de la page N° 3
TABLE OF CONTENTS SAFETY SECTION......................................... 1-1 Safety Precautions..................................... 1-2 Safety Hazard Signal Words................................ 1-7 Safety Decals........................................ 1-8 INTRODUCTION SECTION .................................... 2-1 Introduction......................................... 2-2 Specifications........................................ 2-3 ASSEMBLY SECTION....................................... 3-1 In
Résumé du contenu de la page N° 4
SAFETY SECTION Safety Section 1-1 © 2004 Alamo Group Inc.
Résumé du contenu de la page N° 5
SAFETY Watch for overhead wires. Do not touch wires with any SAFETY PRECAUTIONS part of backhoe. Never allow a person to work under a raised bucket. Safety of the operator was a prime consideration in the design of this Never lift a person with backhoe. backhoe. Proper shielding convenient Do not use bucket as a battering ram. controls, simple adjustments and other safety features have been built into this Always lower bucket to ground when not digging. backhoe. Never leave tractor unattended wi
Résumé du contenu de la page N° 6
SAFETY SAFETY PELIGRO! Si no lee Ingles, pida ayuda a alguien que si Io lea para que Ie traduzca las medidas de seguridad. Never operate the Power Unit or Implement until you have read DANGER! and completely understand this Manual, the Power Unit Operator s Manual, and each of the Safety Messages found in the Manual or on the Power Unit and Implement. Learn how to stop the Power Unit engine suddenly in an emergency. Never allow inexperienced or untrained personnel too operate the Power Unit and
Résumé du contenu de la page N° 7
SAFETY Never allow children to operate or ride on the Power Unit or Implement. DANGER! Do not mount the Power Unit while the Power Unit is moving. Mount the DANGER! Power Unit only when the Power Unit and all moving parts are completely stopped. DANGER! Start the Power Unit only when properly seated in the Power Unit seat. Starting a Power Unit in gear can result in injury or death. Read the Power Unit operator’s manual for proper starting instructions. DANGER! Never work under the Implement, th
Résumé du contenu de la page N° 8
SAFETY SAFETY Do not operate this Equipment with hydraulic oil leaking. Oil is expensive DANGER! and its presence could present a hazard. Do not check for leaks with your hand! Use a piece of heavy paper or cardboard. High- pressure oil streams from breaks in the line could penetrate the skin and cause tissue damage including gangrene. If oil does penetrate the skin, have the injury treated immediately by a physician knowledgeable and skilled in this procedure. Transport only at safe speeds. Ser
Résumé du contenu de la page N° 9
SAFETY Always read carefully and comply fully with the manufacturers WARNING! instructions when handling oil, solvents, cleansers, and any other chemical agent. Never run the Power Unit engine in a closed building or without adequate DANGER! ventilation. The exhaust fumes can be hazardous to your health. KEEP AWAY FROM ROTATING ELEMENTS to prevent entanglement DANGER! and possible serious injury or death. Never allow children to play on or around Power Unit or Implement. DANGER! Children can sli
Résumé du contenu de la page N° 10
SAFETY SAFETY Never interfere with factory-set hydraulic calibrations. Any change in WARNING! calibration could cause a failure of the equipment and result in injury. Always shut the Power Unit completely down, place the transmission in DANGER! park, and set the parking brake before you or anyone else attempts to connect or disconnect the Backhoe. Never crawl under a raised implement supported solely by the Power Unit DANGER! boom. Release of the control lever or mechanical failure will result i
Résumé du contenu de la page N° 11
SAFETY F3788-7-04 Safety Section 1-8 © 2004 Alamo Group Inc. SAFETY
Résumé du contenu de la page N° 12
SAFETY SAFETY ITEM PART NO. QTY. TYPE DESCRIPTION 1 50850 2 NAME RHINO, with Stripe 2 45970 2 WARNING To Prevent Bodily Injury 3 44907 1 WARNING To Prevent Instability 4 44895 2 DANGER Crushing Hazard 5 44896 1 WARNING To Prevent Bodily Injury 6 44897 2 DANGER Crushing Hazard 7 44898 1 OPERATION Boom Operation 8 44899 1 OPERATION Dipperstick & Bucket Operation 9 44900 1 OPERATION Left Side Stabilizer Position 10 44901 1 OPERATION Right Side Stabilizer Position 11 44908 2 OPERATION Boom Lock 12 4
Résumé du contenu de la page N° 13
SAFETY NOTE: Safety decal location is listed below each decal. Replace decal if damaged or illegible. Replacement decals are available from your dealer. 2 - - 45970 5 - - 44896 6 - - 44897 4 - - 44895 TO PREVENT BODILY INJURY Do not attach backhoe to tractors which have 3-PT Quick-Attaching Coupler. Backhoe may become unattached from tractor causing serious personal injury. 45491 17 -- 45491 3 - - 44907 14 -- 48280 F3788-7-04 Safety Section 1-10 © 2004 Alamo Group Inc. SAFETY
Résumé du contenu de la page N° 14
SAFETY SAFETY 10 - - 44901 12 - - 44909 9 - - 44900 1 - - 50850 11 - - 44908 ® 16 - - 35674-5 49696 13 - - 50851 15 - - 49696 7 - - 44898 8 - - 44899 F3788-7-04 Safety Section 1-11 © 2004 Alamo Group Inc.
Résumé du contenu de la page N° 15
SAFETY FEDERAL LAWS AND REGULATIONS This section is intended to explain in broad terms the concept and effect of federal laws and regulations concerning employer and employee equipment operators. This section is not intended as a legal interpretation of the law and should not be considered as such. Employer-Employee Operator Regulations U.S. Public Law 91-596 (The Williams-Steiger Occupational and Health Act of 1970) OSHA This Act Seeks: ...to assure so far as possible every working man and wom
Résumé du contenu de la page N° 16
INTRODUCTION SECTION Introduction Section 2-1 © 2004 Alamo Group Inc.
Résumé du contenu de la page N° 17
INTRODUCTION INTRODUCTION This manual provides operation, maintenance, assembly and parts identification for your new backhoe. Your backhoe has been designed to give many years of satisfactory service. Successful operation and long life of the backhoe depends on proper maintenance and operation. Please read this manual carefully and follow all instructions. Correct assembly, operation and maintenance will save you much time and expense. Also follow instructions included with backhoe mounting and
Résumé du contenu de la page N° 18
INTRODUCTION INTRODUCTION SPECIFICATIONS Specifications may vary depending on tractor model, tire size and bucket used and are subject to change without notification. Tractor must be equipped with ROPS and seat belt that will provide greater safety and installation of backhoe subframe. 95HD GENERAL DATA A Digging Depth (two foot flat bottom) .. .... .... .... 114" B Reach from center line of Swing Pivot . .... .... .... 153" C Loading Height (bucket at 60°). .... .... .... .... 96" D Load Reach.
Résumé du contenu de la page N° 19
INTRODUCTION SPECIFICATIONS F3788-7-04 Introduction Section 2-4 © 2004 Alamo Group Inc. INTRODUCTION
Résumé du contenu de la page N° 20
ASSEMBLY SECTION Assembly Section 3-1 © 2004 Alamo Group Inc.
