ページ1に含まれる内容の要旨
Cover
Assembly Instructions/Use and Care Manual
Liquid Propane Gas Grill
Model No.: 122.16118
•Parts
•Assembly
•Safety Rules
•Use and Care
•Troubleshooting
•Español
Note to Consumer
!
WARNING:
Leave this Owner’s Manual in a convenient
Read this Owner’s manual carefully and be
place for future reference.
sure your gas grill is properly assembled,
installed and maintained. Failure to follow
Customer Service Helpline:
these instructions could result in serious injury
For parts ordering, call
ページ2に含まれる内容の要旨
Table of Contents PRECAUTIONS Warranty------------------------------------------------2 WARNING ! Safety Precautions--------------------------------2~4 Combustion by products produced when using Hardware List------------------------------------------5 this product contain chemicals known to the Parts Diagram -----------------------------------------6 State of California to cause cancer, birth defects, Parts List------------------------------------------------7 or other reproductive harm. Asse
ページ3に含まれる内容の要旨
PRECAUTIONS A tank of approximately 12 inches in diameter by 18- • Have your LP gas tank filled by a reputable propane 1/2 inches high is the maximum size LP gas tank to gas dealer and visually inspected and re-qualified at use. You must use an OPD gas tank which offers each filling. an Overfill Prevention Device. • Do not store a spare LP gas tank under or This safety feature prevents the tank from being • near this appliance. overfilled which can cause malfunction of the LP gas • Never fil
ページ4に含まれる内容の要旨
Burner Flame Check WARNING ! A strong gas smell, or the hissing sound of gas indicates a serious problem with your gas grill or the LP gas tank. Failure to immediately follow the steps listed below could result in a fire or explosion that could cause serious bodily injury, death, or property damage. • Shut off gas supply to the gas grill. • Turn the control knobs to OFF position. • Put out any flame with a proper fire extinguisher. • Open Grill Lid. • Get away from the LP gas tank. Visually
ページ5に含まれる内容の要旨
Contents for Hardware Pack The following table illustrates a breakdown of the hardware pack. It highlights what components are used in the various stages of assembly. Item Description Specification Quantity Phillips Head Screw 18 1/4 x 1.38" pcs Phillips Head Screw 2 1/4 x 3/5" 27 pcs Phillips Head Screw 3 5/32 x 2/5" 10 pcs Nut 4 5/32" 4 pcs Flat Washer 5 1/4" 6 pcs Lock Washer 6 1/4" 31 pcs Lock Washer 7 5/32" 10 pcs Hex Nut 8 1/4" 2 pcs 5
ページ6に含まれる内容の要旨
Model 122.16118 Parts Diagram 1 2 3 21 22 23 4 24 25 5 6 26 7 8 9 27 36 37 10 29 11 12 30 13 38 14 31 39 15 32 33 16 40 34 41 35 52 42 17 43 44 45 46 18 49 47 19 50 48 20 51 6
ページ7に含まれる内容の要旨
Model 122.16118 Parts List KEY# PARTS # DESCRIPTION Q’TY KEY# PARTS # DESCRIPTION Q’TY 1 340-001 Main Lid 1 28 340-028 Side Burner Bowl Assembly Frame 1 2 340-002 Temperature Gauge 1 29 340-029 Side Burner Cooking Grate 1 3 340-003 Logo 1 30 340-030 Side Burner Igniter Wire 1 4 340-004 Side Shelf, Left 1 31 340-031 Side Burner Bowl Assembly, 1 Firebox 5 340-005 Side Shelf front panel, Left 1 32 340-032 Side Burner Head 1 6 340-006 Main Burner bowl assembly 1 33 340-033 Side Burner, Pipe 1 7 340-
ページ8に含まれる内容の要旨
Assembly Instructions CAUTION: While it is possible for one person to assemble this grill, obtain assistance from another person when handling some of the larger, heavier pieces 1. Open lid of shipping carton and remove top sheet of cardboard. Lay cardboard sheet on floor Figure 1 and use as a work surface to protect floor and grill parts from scratches. 2. Remove packing materials from shipping carton. 3. You may slice the carton front corners with a utility knife to lay ope
ページ9に含まれる内容の要旨
Installing Front Panel and Condiment Tray 1. Assemble front panel to front cart leg by using (4) ¼ x 3/5" screws with (4) ¼” lock washers. (Fig.5) 2. Assemble the condiment tray onto the front panel using (2) 5/32 x 2/5" screws and (2) 5/32” nuts with (2) 5/32” washers. (Fig.6) Installing Grill Head Figure 7 1. Remove grill head unit from carton, then place onto cart from above as shown in diagram. (Fig.7) Caution!! Head unit is heavy. To avoid injury, we strongly recommend 2 or more per
ページ10に含まれる内容の要旨
Installing Side Burner Installing Grease Tray 1.Attach side burner to grill cart by using (4) 1. Insert grease tray assembly into opening on 1/4x3/5" Phillips head screws with (4) ¼” lock backside of grill. Make sure to slide tray onto washers. Then use (1) 5/32” Phillips head screw tracks as illustrated and that the grease cup is on and (1) 5/32” lock washer to attach side burner the right hand side from the back. Using (2) 5/32 control panel to main control panel. (Fig.10) x 2/5" Phi
ページ11に含まれる内容の要旨
Installing Battery 1.Unscrew the ignition battery cap.(Found at far-left of control panel) 2.Insert battery into ignition box with positive terminal Figure 13 facing outward. 3.Replace the ignition battery cap after the battery has been installed. (Fig 13). Installing cooking components Important: Before cooking on your grill the first time, wash cooking grids and cooking rack with warm , soapy water. Rinse and dry thoroughly. Season with cooking oil regularly. After cooking is completed
ページ12に含まれる内容の要旨
Checking for LP gas leaks 6. Push and turn one burner knob counterclockwise to “HI” position. Pilot torch will Never test for leaks with a flame. Prior to first use, at light. Hold at high setting for 3-4 seconds until the beginning of each season, or every time your LP burner is lit. After the burner is lit, adjust the knob gas tank is changed, you must check for gas leaks. to desired heat setting. Repeat this step to turn on additional burners. 1. Make a 50/50 mild soap s
ページ13に含まれる内容の要旨
If Grill Still Fails To Light ! WARNING 1. Check gas supply and connections for leaks. Check Never lean over the grill cooking area while that all wire connections are secure. lighting your gas grill. Keep your face and body a safe distance (at least 18 inches) from the 2. Repeat basic lighting procedure. If your grill still fails cooking grid surface when lighting your grill by to operate, turn the gas off at source, turn the control match. knobs to OFF, then check the following: Manuall
ページ14に含まれる内容の要旨
Cleaning and Maintenance Cleaning Exterior Stainless Steel Surfaces To ensure a proper working unit the following proper care and maintenance is suggested. •Weathering and extreme heat can cause exterior stainless steel surfaces to turn tan in color. Machine Cleaning Cooking Grids oils used in manufacturing process of stainless steel We suggest you wash your cooking grids in a mild soap can also cause this tanning color. Use a stainless and warm water solution. You can use a wash cloth or
ページ15に含まれる内容の要旨
Cleaning and Maintenance Cleaning Burner Tubes and Burner Ports Regardless of which burner cleaning procedure you use, we recommend you also complete the following To reduce the chance of “FLASH-BACK” the procedure steps to help prolong burner life. below should be followed at least once a month in late summer or early fall when spiders are most active or 1. Use a fiber pad or nylon brush to clean the entire when your grill has not been used for a period of time. outer surface of each burner
ページ16に含まれる内容の要旨
TROUBLESHOOTING BEFORE CALLING FOR SERVICE If the grill does not function properly, use the following check list before calling for service. You should inspect the burners at least once a year or immediately after any of the following conditions occur: PROBLEMS WHAT TO DO Grill won’t light when the control knob is Check to see if LP tank is empty. rotated. Clean wires and/or electrode by rubbing with alcohol and clean swab. Wipe with dry cloth. Make sure the wire is connected to electrode
ページ17に含まれる内容の要旨
Cooking Instructions Indirect Cooking To cook indirectly, the food should be placed on the left or right side of your grill with the burner lit ! WARNING on the opposite side. Indirect cooking must be Do not leave the grill unattended. done with the Lid down. Your grill will get very hot. Never lean over the cooking area while using your grill. Do not Flare-ups touch cooking surfaces, grill housing. Grill Lid The fats and juices dripping from grilled food can or any other grill parts while
ページ18に含まれる内容の要旨
GRILL COOKING CHART FOOD Weight or thickness Temperature Time Special instructions and tips Slice or chop vegetables and dot with butter or Vegetables NA Medium 8 to 20 minutes margarine. Wrap tightly in heavy duty foil. Grill turning occassionally. Wrap individually in heavy duty foil. Cook Potatoes Whole Medium 40 to 60 minutes rotating occassionally. Pre heat grill for 15-20 minutes then sear steaks on each side for two minutes. Next Meat/Steaks 1/2 to 3/4 inches High-Medium 4 to 15 minu
ページ19に含まれる内容の要旨
Back cover
