ページ1に含まれる内容の要旨
PCG-GRX670/GRX690
SERVICE MANUAL For American Area
US Model
Canadian Model
Ver 1-2002J
Revision History
S400
Lineup : PCG-GRX670
PCG-GRX690
Illust : PCG-GRX690
• Design and specifications are subject to
change without notice.
NOTEBOOK COMPUTER
9-876-012-01
Confidential
ページ2に含まれる内容の要旨
Information in this document is subject to change without notice. Caution Markings for Lithium/Ion Battery - The following or similar texts shall be provided on battery pack of equipment or in both the Sony, VAIO and CLIE are trademarks or registered trademarks of operating and the service instructions. Sony. Microsoft, Windows, Windows Media, Outlook, Bookshelf and other Microsoft products are trademarks or registered trademarks CAUTION: Danger of explosion if battery is incorrectly replaced. o
ページ3に含まれる内容の要旨
TABLE OF CONTENTS Section Title Page CHAPTER 1. BLOCK DIAGRAM ............................... 1-1 (to 1-2) CHAPTER 2. FRAME HARNESS DIAGRAM ........ 2-1 (to 2-2) CHAPTER 3. EXPLODED VIEWS AND PARTS LIST ............................................ 3-1 3-1. Main Section .................................................................... 3-3 3-2. LCD Section – Made by HI – .......................................... 3-7 3-3. Connector Section (CH Type only) ................................. 3-9 (
ページ4に含まれる内容の要旨
Secondary Primary Headphone MIC Speaker CHAPTER 1. BLOCK DIAGRAM PCG-GRX Series BLOCK DIAGRAM Rev.0.10 266 MHz Memory Bus Memory Pentium 4 (DDR) Memory Pentium 4 CPU Local Bus CONTROLLER Processor CONTROLLER Processor CLKGEN 16inch UXGA HUB (MCH) 512KB L2 SMBUS2 SMBUS2 IMI HUB (MCH) 512KB L2 15inch XGA 593 FCBGA 9870GTD 478pins DDR(SO-DIMM) Port Repricator 593 FCBGA 478pins SONY uFCPGA uFCPGA Video- TV-O ut Refer to Clock Generator Out TV-O ut Block Diagram LCD CONN AV Cable USB Right Audio P
ページ5に含まれる内容の要旨
CHAPTER 2. FRAME HARNESS DIAGRAM AV OUT PHONE USB PRINTER MONITOR NETWORK DC-IN Rear Panel LCD CNX-157 Board (Side-A) PCGA-PRGX1 CN5001 INVERTER Port Replicator 1 12 CN1301 CN851 CN3501 CN2001 2 1 CN2901 CN1501 99 1 CN2005 DC FAN CN101 LCD HARNESS 21 100 2 MODEM USB CARD FFC L Side MBX-65 Board (Side-A) EXTERNAL CPU CNX-159 Board 1 119 MICROPHONE (Side-A) 120 2 HEADPHONE 2nd FAN CN1401 CN853 USB 21 CN2007 R Side IEEE 1394 i.LINK NICKEL HYDROGEN PC CARD CNX-158 Board BATTERY CONNECTOR (Side-A) C
ページ6に含まれる内容の要旨
CHAPTER 3. EXPLODED VIEWS AND PARTS LIST NOTE: • Items marked “ * ” are not stocked since they are seldom How to use properly the repair parts. required for routine service. Some delay should be anticipated when ordering these items. There are some parts that use the 2 types ; the [CH] parts or alternately the [JP] parts, in this series. • The mechanical parts with no reference number in the Use the [CH] repair parts for the [CH] type product, vice versa. exploded views are not supplied. • When
ページ7に含まれる内容の要旨
3-1. Main Section Ref.No. Part No. Description Ref.No. Part No. Description Ref.No. Part No. Description Ref.No. Part No. Description 1 4-660-888-01 ESCUSHION TOUCHPAD * 62 4-660-448-01 SUB-FRAME BAY 138 4-665-909-01 INSULATOR BAY2 B1 4-641-726-41 SCREW (M2), SPECIAL HEAD 2 1-796-166-21 PAD, TOUCH 63 X-4624-538-2 ASSY DOOR L 139 4-666-111-01 SHEET AUDIO GND B2 4-641-726-12 SCREW (M2), SPECIAL HEAD 3 X-4624-531-5 ASSY PALMREST 64 4-660-822-03 BRACKET DOOR L 140 4-666-114-01 SHIELD TAPE BRACKET IO
ページ8に含まれる内容の要旨
128 131 27 121 G ∗1 (Type Pa) 122 29 B1 100 12 B20 B3 F B1 E B20 B1 142 28 B1 D B1 38 25 B1 B1 126 B13 16 B5 143 24 B1 140 17 B10 100 B1 31 37 96 O 26 M 13 N N B6 B12 34 35 B9 19 H 33 72 B12 1 Y E H 54 F 133 36 32 B2 73 138 89 21 U 22 127 L 131 P B2 B4 88 3 A B2 (GRX690 only) B2 A I 2 B 23 B1 R 39 Supplied 4 B1 Supplied J 99 with 96 with 3 14 B3 B1 B1 120 40 B14 B B2 74 B12 62 B2 O S B1 B1 20 95 B11 C Q D 88 B2 4 10 126 65 90 66 132 135 B15 Y 64 B2 60 91 B17 41 B8 T Q 5 O Supplied 63 B2 8 6 with
ページ9に含まれる内容の要旨
3-2. LCD Section – Made by HI – Ref.No. Part No. Description Ref.No. Part No. Description 202 201 4-660-847-01 CAP LCD L ACCESSORIES B18 202 4-660-851-01 LCD SCREW COVER S ************ 204 203 4-660-897-02 COVER HINGE 204 4-660-850-02 LCD SCREW COVER T 0801 1-477-205-42 $ ADAPTOR, AC 205 X-4624-525-4 ASSY BEZEL 802 A-8067-482-A $# BP2NX SKD (U) ASSY (S) 203 0803 1-757-562-21 CORD, POWER 206 B18 B19 206 4-660-846-02 LATCH RUBBER 804 4-660-884-02 WEIGHT SAVER 207 A-8059-922-A $# ASSY LCD 16U (SH)
ページ10に含まれる内容の要旨
Ref.No. Fig. Part No. Description 3-3. Connector Section (CH Type only) 901 1-779-745-21 [CH]...JACK, DC DC IN connector 902 1-815-221-22 [CH]...USB CONNECTOR (VERTICAL) USB connector 902 ∗ Among the parts that are used on the boards of this model, only the connectors that are show in the list can be replaced. (The parts other that the specified connectors cannot be replaced.) 901 ∗Before replacing the connector of reference number 901 and 902 remove the bracket I/O. 901 902 901 902 Confidential
ページ11に含まれる内容の要旨
CHAPTER 4. OTHERS 4-1. Replacing the CPU 1. Removing the CPU 1 Insert a flat-blade screwdriver into the notch as shown in the illustration and rotate it so that the protrusion comes to the lock release position. 2 Pull the CPU gently upward to lift it out of the CPU socket. 1 1 CPU Lock position 2 CPU socket Lock release position 2. Installing the CPU 1 Align the triangle reference mark of the CPU with that of the CPU socket and insert all the pins of the CPU to the corresponding holes of the C
ページ12に含まれる内容の要旨
PCG-GRX670/GRX690 (AM) List of PCG-GRX Series (As of October, 2002) Service Manual Model Name Part No. PCG-GRX590 PCG-GRX570 9-874-524-03 PCG-GRX550 PCG-GRX510 PCG-GRX580P PCG-GRX580K PCG-GRX580 PCG-GRX560P PCG-GRX560K 9-874-542-02 PCG-GRX560 PCG-GRX520P PCG-GRX520K PCG-GRX520 PCG-GRX650 PCG-GRX616 9-874-581-01 PCG-GRX717 PCG-GRX670 9-876-012-01 PCG-GRX690 : Additional Models This manual and the constituent data may not be replicated, copied nor reprinted in whole or in part without prior writt
ページ13に含まれる内容の要旨
Revision History Suffix Ver. Date Contents QM No. First -01 Ver. 1 2002.10.07 Edition < Remarks > [Confidential] PCG-GRX670/GRX690 (AM)
