ページ1に含まれる内容の要旨
6522SH
Owner’s Manual
532 19 64-02 01.15.05 BY Printed in U.S.A.
ページ2に含まれる内容の要旨
SAFETY RULES Safe Operation Practices for Walk-Behind Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. Stop the blade(s) when crossing gravel drives, walks, Look for this symbol to point out im- or roads. portant saf ety precautions. It means Stop the engine (motor) whenever you leave the equip- CAUTION!!! BE COME ALERT!!! YOUR men
ページ3に含まれる内容の要旨
Never refuel the machine indoors. wire away from plug to prevent accidental starting. Never store the machine or fuel container where there Keep nuts and bolts, especially blade attachement is an open fl ame, spark or pilot light such as a water bolts, tight and keep equipment in good condition. heater or on other appliances. Never tamper with safety devices. Check their proper Never fi ll containers inside a vehicle, on a truck or trailer operation regularly. bed with
ページ4に含まれる内容の要旨
ASSEMBLY Read these instructions and this manu al in its entirety before you attempt to assemble or operate your new lawn mower . OPERATOR MOWING PRESENCE PO SI TION IMPORTANT: THIS LAWN MOWER IS SHIPPED WITH- CONTROL OUT OIL OR GASOLINE IN THE ENGINE. BAR Your new lawn mower has been as sem bled at the factory LIFT with the ex cep tion of those parts left unassembled for ship- UP ping purposes. All parts such as nuts, washers, bolts, etc., necessary to com plete the as sem bly have bee
ページ5に含まれる内容の要旨
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product. Learn and understand their meaning. OPERATOR PRESENCE CON TROL BAR DRIVE CONTROL LEVER STARTER HANDLE HANDLE KNOB EN GINE OIL CAP WI
ページ6に含まれる内容の要旨
OPERATION The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or per- forming any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask over spectacles. 1. Turn unit off and disconnect spark plug wire from plug. HOW TO USE YOUR LAWN MOWER 2. Turn nut on underside of drive control to increase drive ENGINE SPEE
ページ7に含まれる内容の要旨
OPERATION SIDE DIS CHARG ING (See Fig. 6) CAUTION: Do not run your lawn mower Mulcher plug must be installed into rear discharge with out mulcher plug or ap proved grass open ing of mower. catcher in place . Never at tempt to op- er ate the lawn mow er with the rear door Open mulcher door and install dis charge defl ector re moved or propped open. under door as shown. Mower is now ready for discharging operation. TO EMPTY GRASS CATCHER (See Fig. 7) To convert to mulch
ページ8に含まれる内容の要旨
OPERATION MOWING TIPS GASOLINE ENGINE FILLER OIL CAP CAP CAUTION: Do not use de-thatcher blade attachments on your mower. Such at- tachments are hazardous, will damage y our mo wer and could v oid y our warranty . Under certain conditions, such as very tall grass, it may be necessary to raise the height of cut to reduce pushing effort and to keep from overloading the engine and leaving clumps of grass clippings. It may also be necessary to reduce ground speed and/or run the lawn
ページ9に含まれる内容の要旨
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 10 25HOURS 100 STORAGE USE USE HOURS ORSEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * CheckTires Check DriveWheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication Clean and Recharge Battery ** Check Engine Oil level Change Engine Oil Clean Air Filter Inspect Muffler Replace Spark Plug Replace Air Filter Paper Cartridge Empty fuel sys
ページ10に含まれる内容の要旨
MAINTENANCE 3. Be sure the trailing edge of blade (opposite sharp edge) LAWN MOWER is up toward the engine. Always observe safety rules when performing main te nance. 4. Install the blade bolt with the lock washer and hard ened washer into blade adapter and crank shaft. TIRES 5. Use block of wood between blade and lawn mower Keep tires free of gasoline, oil, or insect control chem- housing and tighten the blade bolt, turning clock wise. i cals which can harm rubber. The recom
ページ11に含まれる内容の要旨
MAINTENANCE TO CLEAN AIR FILTER ENGINE 1. Loosen screw and tilt cover to re move. LUBRICATION 2. Carefully remove cartridge. Use only high quality detergent oil rated with API service 3. Clean by gently tapping on a fl at surface. If very dirty, classifi cation SG–SL. Select the oil's SAE viscosity grade replace cartr idge. according to your expected operating temperature. SAEVISCOSITYGRADES CAUTION: Pe tro leum solvents, such as ker o sene, are not to be used to clean SAE30 car tridge
ページ12に含まれる内容の要旨
SERVICE AND ADJUSTMENTS CAUTION: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: 1. Release control bar and stop engine. 2. Make sure the blade and all moving parts have completely stopped. 3. Disconnect spark plug wire from spark plug and place where it cannot come in contact with plug. TO ADJUST HANDLE (See Figs. 14 thru 16) LAWN MOWER The handle can be mounted in a high or low position. The TO ADJUST CUTTING HEIGHT mounting holes in the bottom of lower handle a
ページ13に含まれる内容の要旨
SERVICE AND ADJUSTMENTS ENGINE ENGINE SPEED Your engine speed has been factory set. Do not attempt to increase engine speed or it may result in personal injury. If you believe that the engine is running too fast or too slow, take your lawn mower to an authorized service center for repair and adjustment. CARBURETOR LOWER Your carburetor is not adjustable. If your engine does not HANDLE operate properly due to suspected carburetor problems, take your lawn mower to an authorized service
ページ14に含まれる内容の要旨
STORAGE CYLINDER ENGINE 1. Remove spark plug. FUEL SYSTEM IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS 2. Pour one ounce (29 ml) of oil through spark plug hole FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH into cylinder. AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK 3. Pull starter handle slowly a few times to distribute oil. DURING STORAGE. ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANOL) CAN 4. Replace with new spark plug. ATTRACT MOISTURE WHICH LEADS
ページ15に含まれる内容の要旨
TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refi ll tank with fresh,
ページ16に含まれる内容の要旨
16 ROTARY LAWN MOWER - - MODEL NUMBER 6522SH (96143000900) - PRODUCT NUMBER 961 43 00-09
ページ17に含まれる内容の要旨
17 ROTARY LAWN MOWER - - MODEL NUMBER 6522SH (96143000900) - PRODUCT NUMBER 961 43 00-09 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 532 18 97-40 Upper Handle (Includes Foam Grip) 37 532 15 00-78 Screw, Sems, Thread Cutting 5/16-18 x 3/4 2 532 18 35-67 Engine Zone Control Cable 38 532 19 70-30 Discharge Defl ector 3 532 12 51-62 Bracket, Upstop 39 532 19 71-51 Handle Bracket Assem
ページ18に含まれる内容の要旨
18 ROTARY LAWN MOWER - - MODEL NUMBER 6522SH (96143000900) - PRODUCT NUMBER 961 43 00-09
ページ19に含まれる内容の要旨
19 ROTARY LAWN MOWER - - MODEL NUMBER 6522SH (96143000900) - PRODUCT NUMBER 961 43 00-09 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 532 19 62-72 Drive Control Assembly (Includes Cable) 30 532 18 06-26 Hubcap 2 532 19 57-61 Cover, Drive Control, Top 32 532 19 40-18 Drive Pulley 3 532 18 70-03 Pulley 33 532 18 99-22 V-Belt 4 532 19 00-39 Lever, Drive Control 34 532 18 83-31 Pinion Asse
ページ20に含まれる内容の要旨
20 WARRANTY STATEMENT SECTION 1: LIMITED WARRANTY SECTION 4: EXCEPTIONS AND LIMITATIONS Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original pur- This warranty shall be inapplicable to defects resulting from the following: chaser to be free from defects in material and workmanship from the date of purchase for the “Warranty (1)Accident, abuse, misuse, negligence and neglect, including stale fuel, dirt, abrasives, moisture, rust, Period” of the p
