ページ1に含まれる内容の要旨
Gas-fired water boilers – Series 3
Featuring
User’s
Information Manual Flexibility
If the information in this manual is not followed exactly, a fire or explosion may result,
causing property damage, personal injury or loss of life.
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS —
• Do not tr y to light any appliance.
• Do not touch any electrical switch; do not use any telephone in your buildin
ページ2に含まれる内容の要旨
s ga -dfire ret aw iborle — User’s Information Manual How to use this manual . . . To . . . Read/use . . . See pages . . . Learn precautions Warnings and definitions 1 – 3 Read the list of air contaminants you must avoid. Prevent air If found, either remove the products permanently, or have 4 contamination your installer relocate boiler vent and air terminations to an uncontaminated area. Maintain the boiler using the schedule in this manual. Maintain the boiler 5 – 8 Schedule an annual star
ページ3に含まれる内容の要旨
s ag -derfi ert aw iborel — User’s Information Manual STOP! READ THIS BEFORE PROCEEDING . . . Failure to adhere to the guidelines on this page can result in severe personal injury, death or substantial property damage. Boiler service and maintenance — To avoid electric shock, disconnect electrical supply before performing mainte- ❏❏ nance. To avoid severe burns, allow boiler to cool before performing maintenance. ❏❏ You must maintain the boiler as outlined in this manual and have the boiler
ページ4に含まれる内容の要旨
s ga -derfi ter aw olerbi — User’s Information Manual Prevent combustion air contamination If the boiler combustion air inlet is located in any area likely to cause contamination, or if products which would contaminate the air cannot be removed, you must have the combustion air and vent re-piped and terminated to another location. Contaminated combustion air will damage the boiler, resulting in pos- sible severe personal injury, death or substantial property damage. Do not operate an Ultra
ページ5に含まれる内容の要旨
s ga -derif tre aw bilero — User’s Information Manual Annual startup and general maintenance Figure 1 Service and maintenance schedules OWNER MAINTENANCE (see the following pages for instructions) Contact your boiler service technician to inspect, service and start up your boiler. You must have an annual start-up performed by a BEGINNING OF SEASON qualified service technician to ensure reliable operation of the boiler and system. Check boiler area Check air openings DAILY Check pressure/temp
ページ6に含まれる内容の要旨
s ga -derfi ret aw relibo — User’s Information Manual Maintenance procedures — DAILY Check air openings The boiler must be serviced & maintained 1. Verify that combustion and ventilation air openings to the boiler room and/or building The boiler must be inspected and started annually, at the beginning of the heating season, by a qualified service tech- are open and unobstructed. nician. In addition, the maintenance and care of the boiler 2. Verify that boiler vent discharge and air intake
ページ7に含まれる内容の要旨
s ag -ferid ter aw lebrio — User’s Information Manual Maintenance procedures — MONTHLY 2. If you notice flue gas escaping, this indicates a dry conden- Check vent piping sate drain trap. See step 4 for procedure to fill trap. Call your qualified service technician to inspect the boiler and 1. Visually inspect the flue gas vent piping for any signs of block- condensate line and refill the condensate trap if problem age, leakage or deterioration of the piping. Notify your quali- persists regul
ページ8に含まれる内容の要旨
s ga -rdefi rte aw rboile — User’s Information Manual Maintenance procedures — EVERY 6 MONTHS To avoid water damage or scalding due Check the boiler piping to valve operation, a metal discharge line must be connected to relief valve 1. Remove boiler front access door and perform gas leak inspection per outlet and run to a safe place of disposal. steps 1 through 7, Operating Instructions, page 9. If gas odor or leak This discharge line must be installed by is detected, immediately shut d
ページ9に含まれる内容の要旨
s ga -rdeif ret aw lboire — User’s Information Manual OPERATING INSTRUCTIONS Figure 2 Operating instructions 9 Part number 550-100-067/0608
ページ10に含まれる内容の要旨
s ga -drife tre aw boelri — User’s Information Manual Boiler components & the U-Control display Figure 3 Ultra component locations Figure 4 U-Control display turns red when boiler locks out — select MANUAL RESET to reset boiler as shown below. 10 Part number 550-100-067/0608
ページ11に含まれる内容の要旨
s ga -edrif etr aw reliob — User’s Information Manual Boiler components & the U-Control display (continued) Figure 5 Ultra boiler’s U-Control display 11 Part number 550-100-067/0608
ページ12に含まれる内容の要旨
s ga -rfide ret aw rboile — User’s Information Manual 12 Part number 550-100-067/0608
