SERVICE MANUAL Ver.5-2012E Revision History Area Lineup Area Lineup Area Lineup VPCSA3AJ VPCSA3S9R/XI VPCSB35FG/S VPCSB38FJ/B VPCSA3T9E/XI VPCSB35FG/W VPCSB38FJ/L VPCSB35FH/L JP VPCSA3V9E/XI VPCSB38FJ/P VPCSB35FH/P VPCSA3X9E/XI (Japan) VPCSB38FJ/W VPCSB35FW/B VPCSA3X9R/XI VPCSB39FJ/B VPCSB35FW/L VPCSA3Z9E/XI VPCSB3AJ VPCSB35FW/P
ページ2に含まれる内容の要旨
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions change without notice. following or similar texts shall be provided on battery pack of equipment or in both the operating 1. Obey precautionary markings and 4. Inspect after completing service Sony, VAIO and CLIE are trademarks or regis- and the service instructions. instructions tered trademarks of Sony. Microsoft, Windows, After servicing, inspect to make sure that a
ページ3に含まれる内容の要旨
TABLE OF CON NTENTS Section Title Page Section Title Page CHAPTER1. BLOCK DIAGRAM…………………………… CHAPTER4.OTHERS 1-1 4-1. Note for WWAN Board Replacement …………………… (to 1-1) 4-1 CHAPTER2. FRAME HARNESS DIAGRAM 4-2. Note for WIMAX Board Replacement …………………… 4-2 2-1.VPCSA/SB/SC/SD Series (TOP)…………...………………. 2-1 4-3. Holding Method of Motherboard……………..…………… 4-3 2-1 2-2.VPCSA/SB/SC/SD Series (BOTTOM)……………………. 2-2 (to 4-3) 2-2 (to
ページ4に含まれる内容の要旨
CHA APTER1. BLOCK DIA AGRAM SO-DIMM 0 1066/1333 MHZ 1066/1333 MHZ dGPU DDR(III) 204 pin Sandy Bridge-DC ATI DDR3 VRAM (SNB) Processor (35W) Whistler Seymour XT PCIE X16 64Mx16bitx8/128Mx16bx8 1066/1333 MHZ BGA-1023 4GB/2GB On Board 512 MB (1Gb x 4) (1023-pin BGA) Seymour Whistler LP 64Mx16bitx4 1GB/2GB XDP CONN (EVT only) (1Gbx8/2Gbx8) FDI DMI X4 PECI GbE Controller REALTEK Transformer RJ45 cable TMDS PCIE(Gen 2) 4 RTL8111E HDMI On DOCK DB PCH Intel LVDS 13.3'' LVDS 1600 X 900 Cougar Point 136
ページ5に含まれる内容の要旨
CHA APTER2. FRAME HARNESS DIA AGRAM 2-1.VPCSA/SB/SC/SD Series (TOP) C CAMERA LCD BLUETOOTH H From board to connector () (direct connection) Harness(connector at both end) Harness(soldered at one end) USB Thermal Module USB USB RJ45 Cable HDMI WWAN CARD DC-In Cable VGA SIM SIM CARD CARD ODD FFC BATTER RY PACK MS MS CARD CARD SD CARD [Sony Confidential] 2- -1 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ6に含まれる内容の要旨
2-2. VPCSA/SB/SC/SD Series (BOTTOM) RTC Battery SPEAKER Switch Daughter Board WLAN CARD Keyboard HDD() (SSD) FPC Keyboard Touchpad Touchpad Daughter Board Spe eed Daughter Board LED Daug ghter B Board 2- -2 [Sony Confidential] VPCSA/SB/SC/SD Series (9-890-859-XX) (EN ND)
ページ7に含まれる内容の要旨
CHAPTER3. EXPLODED VIEWS AND PARTS LIST The parts list is compiled by blocks of a Palmrest and bottom etc. Double-click on the paper clip mark in the Spec column to open the specifications list. The sections of the parts list are different depending on the model. To open the parts list, Microsoft office Excel or Excel viewer is required. Please refer to list of contents shown. Palmrest Main Board Bottom ODD HDD LCD Accessories Spec Section Page
ページ8に含まれる内容の要旨
Double-click on the paper clip mark in the Spec column to open the specifications list. To open the parts list, Microsoft office Excel or Excel viewer is required. Palmrest Main Board Bottom ODD HDD LCD Accessories Spec Palmrest Main Board Bottom ODD HDD LCD Accessories Spec SA3C5E SB35FG/L P-1 M-1 B-1 D-1 H-1 L-2 A-1 P-1 M-1 B-1 D-1 H-1 L-1/L-2 A-1 SA3J1E/XI P-1 M-1 B-1 D-1 H-1 L-1 A-1 SB35FH/S P-1 M-1 B-1 D-1 H-1 L-2 A-1 SA3L9E/XI SB35FG/P P-1 M-1 B-1 D-1 H-1 L-2 A-1 P-1 M-1 B-
ページ9に含まれる内容の要旨
Note Parts List is attached on the upp pper rig ght p portion of each EXPLODED VIEW. If there is the Remarks column in the p, parts list, the features of ap ppplicable models are indicated in it for Items marked “*” are not stocked since they are seldom required for routine service. the parts that are different depending on each model. Some delay should be anticipated when ordering these items. For the abbreviations used in the remarks column, please refer to the
.
ページ10に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. S-1. Screws To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -3 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ11に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. P-1. Palmrest To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -4 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ12に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. M-1. Main Board To open the parts list, Microsoft office Excel or Excel viewer is required. * When thermal module is removed, clean off the CPU PAD and VGA PAD. Put the Ref. No. 308 and Ref. No. 309 to the place shown in the figure. [Sony Confidential] 3- -5 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ13に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. B-1. Bottom To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -6 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ14に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. D-1. ODD To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -7 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ15に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. H-1. HDD To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -8 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ16に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. H-1. HDD To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3-8 8(a) VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ17に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. L-1. LCD (For Hot) To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3- -9 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ18に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. L-2. LCD (For Mild) To open the parts list, Microsoft office Excel or Excel viewer is required. [Sony Confidential] 3-10 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ19に含まれる内容の要旨
Parts List Double-click on the paper clip mark to open the parts list. A-1. Accessories To open the parts list, Microsoft office Excel or Excel viewer is required. 2006 2005 2006 AC Adapter(Stick Type) Power Cord AC Adapter 2007 2008 2009 Battery Pack Extended Battery Battery Adapter 2011 2010 2012 Carrying Carrying Pouch Pouch Cl Cleaniing C Cllot th h Cable Cable Clip Clip [Sony Confidential] 3-11 VPCSA/SB/SC/SD Series (9-890-859-XX)
ページ20に含まれる内容の要旨
LCD DIP Switch DIP switch h setting is different by the type of LCD. LCD LCD DIP DIP Sw Switch itch Location Location For setting g method, please refer to the table. VPCSB38FJ/SB B39FJ/SB3AJ (JP) VPCSB38FJ/SB39FJ/SB3AJ (JP) VPCSA390X /S SB31FX/SB33GX/SB35FX/SB390X (US) VPCSA390X /SB31FX/SB33GX/SB35FX/SB390X (US) VPCSB31FD/S SB35FB/SB35FL/SB390L /SB390S (PA) VPCSB31FD/SB35FB/SB35FL/SB390L /SB390S (PA) VPCSA3C5E /SB3C5E /SB3L9E/SB3M1R/SB3M9E/SB3N9E/SB3Q9E/ VPCSA3C5
