ページ1に含まれる内容の要旨
TECHNICAL MANU TECHNICAL MANUAL AL
TECHNICAL MANU TECHNICAL MANU TECHNICAL MANUAL AL AL
AVPTC Air Handlers
• Refer to Service Manual RS6200006 for installation, operation & troubleshooting information.
• All safety information must be followed as provided in the Service Manual.
• Refer to the appropriate Parts Catalog for part number information.
• Models listed on page 3.
This manual is to be used by qualified, professionally trained HVAC technicians only. Goodman
RT6121001r2
does not assume
ページ2に含まれる内容の要旨
PRODUCT IDENTIFICATION The model number is used for positive identification of component parts used in manufacturing. Please use this number when requesting service or parts information. A V P T C 1830 14A A EXPANSION MINOR PRODUCT DEVICE: REVISION* TYPE: F: Flowrater T: TXV A: Air Handler (Expansion Device) MAJOR REVISION* CABINET FINISH: U: Unpainted REFRIGERANT CHARGE: P: Painted 4: R-410A N: Uncased APPLICATION EXPANSION
ページ3に含まれる内容の要旨
PRODUCT IDENTIFICATION The model number is used for positive identification of component parts used in manufacturing. Please use this number when requesting service or parts information. AVPTC183014** AVPTC313714** AVPTC426014** The United States Environmental Protection Agency (“EPA”) has issued various regulations re- W WA ARNI RNING NG garding the introduction and disposal of refrigerants introduced into this unit. Failure to follow these regulations may harm the environment and can lead to
ページ4に含まれる内容の要旨
PRODUCT DESIGN AIR HANDLERS WARNING *See Air Handler Specification Sheet for Proper Combinations. ALL AIR HANDLERS USE DIRECT DRIVE MO- When installing or servicing this equipment, safety TORS. POWER SUPPLY IS 220-240 V, 60 HZ, 1 clothing, including hand and eye protection, is PHASE strongly advised. If installing this equipment in an Installation area that has special safety requirements (hard hats Before installing this appliance insure that it is properly sized etc.), observe these require
ページ5に含まれる内容の要旨
PRODUCT DESIGN When this product is installed in the downflow installation in See following chart for the correct DPIH kit. an unconditioned space, remove the horizontal drain pan and install the following insulation kit AVPTC Model Insulation Kit AVPTC Model Insulation Kit 1830 DPIH36-42 1830 DPI36-42/20 3137 DPIH48-61 4260 3137 DPI48-61/-20 4260 *AVPTC is a multi-position, variable-speed air handler and is used with R-410A. The unit's blower design includes a vari- This kit is used to prevent
ページ6に含まれる内容の要旨
PRODUCT DIMENSIONS AVPTC D B C E A SUCTION LINE LIQUID LINE INLET TUBE F G I INLET H (RIGHT SIDE VIEW) INLET (FRONT VIEW) Model A B C D E F G H I J AVPTC183014 46 3/4" 22" 17 1/2" 19 1/2" 10' 14 1/2" 11 15/16" 17 1/8" 17 15/16" 2" AVPTC313714 53 1/4" 24" 20" 22" 12" 19 5/8" 11 15/16" 19 5/8" 19 15/16" 1 13/16" AVPTC426014 53 1/4" 24" 20" 22" 12" 19 5/8" 11 15/16" 19 5/8" 19 15/16" 1 13/16" 6
ページ7に含まれる内容の要旨
PRODUCT SPECIFICATIONS AVPTC AVPTC183016* AVPTC313716* AVPTC426016* Blower Wheel Diameter 9 1/2" 10 5/8" 10 5/8" Width 8" 10 5/8" 10 5/8" Lineset Connection Size Coil Drain Connection FPT 3/4" 3/4" 3/4" Liquid 3/8" 3/8" 3/8" Suction 3/4"7/8"7/8" Electrical Data Voltage 208/240 208/240 208/240 Min. Circuit Ampacity 4.9/4.9 6.5/6.5 8.6/8.6 Max. Overcurrent Device (amps) 15/15 15/15 15/15 Minimum VAC 197 197 197 Maximum VAC 253 253 253 Blower Motor FLA 3.90 5.20 6.90 HP 1/2 3/4 1 Ship Weight (lbs)
ページ8に含まれる内容の要旨
BLOWER PERFORMANCE DATA Electric Heat Airflow and Temperature Rise Table Speed Selection Dip Switches Cool Adjust Profile Htr Kw 9 10 11 AVPTC 183014* AVPTC 313714* AVPTC 426014* Selection Selection Selection 3 ON ON ON 600 600 600 Switches Switches Switches 5 ON ON OFF 700 700 700 TAP 1 2
ページ9に含まれる内容の要旨
BLOWER PERFORMANCE DATA Outdoor Data Line Indoor Control Control Voltages, Vdc TERM TERM BIAS Dipswitches Dipswitch Dipswitches 1-C 2-C 1-2 Switch 1 Switch 2 Switch 3 Switch 1 Switch 2 ON ON ON ON ON >2.5 <2.5 >0.2 ON ON OFF ON ON >2.8 <2.2 >0.6 ON ON ON OFF ON >2.8 <2.2 >0.6 ON ON ON ON OFF >2.8 <2.2 >0.6 ON ON OFF OFF OFF 5 0 5 OFF ONONON ON 0 0 0 ON OFF ON ON ON 550 ON or ON or OFF OFF ON or OFF 000 OFF OFF TERM1 / TERM2 = Termination dipswitches at outdoor unit. See installation TM inst
ページ10に含まれる内容の要旨
24V THERMOSTAT CONNECTIONS 24 V THERMOSTAT CONNECTIONS - WIRING DIAGRAMS AVPTC FL FL FL FL HTR1TL BK HTR 2 TL FL FL HTR1 TL HTR1 TL BK FL HTR2 TL RD FL HTR1 TL TL RD HTR2 RD FL TL HTR3 YL BK BK 1 FL TL HTR3 BK BK 1 HTR4 TL BL BK 2 1 BK RD 1 2 2 PU RD YL 3 RD 2 BK YL PU BL BK PU PU BL RD 3 BL 3 BK 4 M1 BK RD BL 3 BL M1 M3 M1 RD BL R RD 4 4 M1 M3 M5 M7 M1 M3 RD M2 M4 M2 YL BL 5 4 M2 RD M2 M4 M6 M8 R1 R R2 BR 5 5 R1 R2 M2 M4 BK BR 5 WH 6 BK RD BK WH 6 BK WH 6 RD WH BK 6 7 BK RD 7 BK 7 RD 7 YL BK 8
